Professional Documents
Culture Documents
Reg 00
Reg 00
Important Notes
OM650
Process Control for Introduction
A7.5
1
TELEPERM XP Features of Pictographs
A7.0 2
Features of Operation/Indication Windows
A7.5
3
Manual Features of Function Diagrams
A7.2 4
Features of Detail Windows
A7.0
5
Operation and Monitoring of Closed-- loop
Control Functions A7.5 6
Operation and Monitoring of Open-- loop
Contol Functions A7.5 7
Operation and Monitoring of Special Tasks
A7.5 8
Overview of Pictographs
A7.0 9
Operating Sequence Log
A7.2 10
Parameter Change and Controller Tuning
A7.0 11
Abbreviatons
A7.0
12
References 13
A7.5
The reproduction, transmission or use of this document or its contents is We have checked the contents of this manual for agreement with the
not permitted without express written authority. hardware and software described. Since deviations cannot be precluded
Offenders will be liable for damages. All rights, including rights created entirely, we cannot guarantee full agreement. However, the data in this
by patent grant or registration of a utility model or design, are reserved. manual are reviewed regularly and any necessary corrections included
in subsequent editions. Suggestions for improvement are welcomed.
Copyright Siemens AG 1999 All Rights Reserved Technical data subject to change.
Device Manual
Basic Functions
Basic Elements
Process Information
System Components
and
Peripheral Devices
Installation
and
Interfaces
e Siemens AG A7.5
Warning
!
The operating and monitoring system OM 650 should be used only by quali-
fied personnel familiar with the process technology and safety cencepts of
process control.
The OM 650 is exclusively for the operating and monitoring of process con-
trol equipment for power plants, waste incineration plants and refineries.
The user manual should be followed at all times.
Qualified Personnel
Improper use of the system or failure to observe the instructions in this manual could result in personal
injury or damage to property. Only qualified personnel may use the OM 650 to operate process control
equipment.
e Siemens AG A7.5
TELEPERMR, SIMATICR and SINECR are registered trade marks of Siemens
AG.
The reproduction, transmission or use of this document or its contents is not per-
mitted without express written authority. Offenders will be liable for damages. All
rights, including rights created by patent grant or registration of a utility model or de-
sign, are reserved.
Disclaimer of liability We have checked the contents of this manual for agreement with the hardware and
software described. Since deviations cannot be precluded entirely, we cannot guar-
antee full agreement. However, the data in this manual are reviewed regularly and
any necessary corrections included in subsequent editions. Suggestions for im-
provement are welcomed. Technical data subject to change.
Safety--related This manual contains notices which you should observe to ensure your own
guidelines personal safety, as well as to protect the product and connected equipment. These
notices are highlighted in the manual by a warning triangle and are marked as
follows according to the level of danger:
Warning
! Indicates that death, severe personal injury or substantial damage to property can
result if proper precautions are not taken.
Caution
! Indicates that minor personal injury or damage to property can result if proper pre-
cautions are not taken.
. Note
Is important information on the product, the handling of the product or the respec-
tive part of the documentation to which particular attention should be paid.
Mouse and OM 650 operations are completed via the mouse or keyboard.
keyboard Mouse and keyboard operations are normally symbolized as follows:
denotes operations via the keyboard. The key to be pressed (the ”return” key,
for example) is identified by a symbol.
e Siemens AG A7.5
OM 650 Process Control for TELEPERM XP
e Siemens AG A7.5