Connector Part Information 32 Pin VCM Connector C2 (RED) Yellow highlight are wires in the OBS harness that will not be needed when marring to a LS harness. Blue highlight are wires in the OBS harness that will need connected to the 03 LS PCM Pin Wire Color Circuit No. Function Green highlights are either way, depending on emission requirements 1 — — Not Used 2 WHT 1310 EVAP Vent Valve Control ----- The EVAP Vent solenoid is located on the charcoal cansiter. The PCM supplies GROUND to activate it. This wire 3 — — Not Used can be moved to the LS PCM EVAP Vent Control Wire. 2-3 Shift Solenoid Valve Control 4 YEL/BLK 1223 Empty with M/T 5 — — Not Used 2–3 Shift Solenoid Control 6 LT GRN 1222 Empty with M/T PWM TCC Solenoid Control 7 BRN 418 Empty with M/T 8 BLK 1744 Injector #1 Control 9 YEL/BLK 846 Injector #6 Control 10 BRN 1456 EGR Pintle Position 11–12 — — Not Used 13 LT GRN/WHT 1749 IAC B High 14 LT BLU/WHT 1747 IAC A High 15 LT GRN/BLK 1745 Injector #2 Control 16 PNK/BLK 1746 Injector #3 Control 17–18 — — Not Used 19 DK BLU 496 KS Input www.lt1swap.com 20 — — Not Used 21 LT GRN 432 MAP Signal 22 TAN 472 IAT Signal 23 YEL 410 ECT Signal 24 DK BLU 417 TP Signal 25 DK GRN 890 Fuel Tank Pressure Signal ----- The EVAP system has a pressure sensor on the fuel tank. This is the signal wire back from the sensor indicating 26 — — Not Used pressure or vacuum inside the gas tank. TFT Signal 27 YEL/BLK 1227 Empty with M/T 28 YEL 292 MAF Signal 29 LT GRN/BLK 444 IAC B Low 30 LT BLU/BLK 1748 IAC A Low 31 BLK/WHT 845 Injector #5 Control 32 LT BLU/BLK 844 Injector #4 Control