Professional Documents
Culture Documents
NOTE: Take care to observe the following precautions when performing inspections or
removal and replacement of body electrical related parts.
1. Headlight System
Halogen bulbs have pressurized gas inside and require special handling. They can burst if scratched or
dropped. Hold a bulb only by its plastic or metal case.
The RAV4 is equipped with an SRS (Supplemental Restraint System) such as the driver airbag and front
passenger airbag, failure to carry out service operation in the correct sequence could cause the SRS to
unexpectedly deploy during servicing, possibly leading to a serious accident. Before servicing (including
removal or installation of parts, inspection or replacement), be sure to read the precautionary notices in
AIR BAG SAFETY PRECAUTIONS .
3. Audio System
If the negative (-) terminal cable is disconnected from the battery, the preset AM, FM1 and FM2 stations
stored in memory are erased, so be sure to note the stations and reset them after the battery terminal is
reconnected.
If the vehicle is equipped with a mobile communication system, refer to precautions in IF VEHICLE IS
EQUIPPED WITH MOBILE COMMUNICATION SYSTEM .
TROUBLESHOOTING
PROBLEM SYMPTOMS
Helpmelearn
November-03-08 5:28:18 PM Page 2 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Interior Light System - RAV4
INSPECTION
Helpmelearn
November-03-08 5:28:18 PM Page 5 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Interior Light System - RAV4
Helpmelearn
November-03-08 5:28:18 PM Page 6 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Interior Light System - RAV4
b. Check that no continuity exists between terminal and the switch body with the switch OFF (Switch
pin pushed in: closed door).
Helpmelearn
November-03-08 5:28:18 PM Page 7 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Interior Light System - RAV4
b. Turn the room light switch ON, check that continuity exists between terminal 2 and body ground.
c. Turn the room light switch to DOOR, check that continuity exists between terminals 1 and 2.
Helpmelearn
November-03-08 5:28:18 PM Page 8 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Interior Light System - RAV4
Helpmelearn
November-03-08 5:28:18 PM Page 9 © 2005 Mitchell Repair Information Company, LLC.