Service Engineering Section 1, ALOKA Technical Service Co., Ltd.
Subject: Rev.: e-DMS 0 Company: Name: Date: - -
dd -mm -yyyy
Result Point Trainer Approved by
GOOD (points 60 or higher)
Need to be trained again
Check out either YES or NO in each question below.
1. We cannot set up the Network Setting with D4E though we need to
change the setting of eDMS's own TCP/IP when using DICOM communication.
Yes No
2. Though a hardware key that protects D4E is connected to the USB
port, D4E isn't started up if the key is removed.
Yes No
3. All settings of common preset and each application can be stored to
a floppy disk at a time.
Yes No
4. If eDMS doesn't finish completely after turning Power SW off, SSD-
5500 turns off after 40 seconds without receiving the Shutdown signal from eDMS.
Yes No
5. Though Basic Measurement & Optional Analysis Application could be
used in eDMS, acquired images can be handled with each application regardless of image data format. For example, TDI analysis is possible to use in B/W image.