Professional Documents
Culture Documents
Published at http://gtrebaol.free.fr/doc/catia/worm.html The worm is a part of a worm / worm wheel reduction gear
This tutorial shows how to make a basic worm that you can freely re-use in your assemblies.
The worm can be coupled with a worm gear or with an helical gear. The principle for designing a worm consists in drawing a thread helix that cuts a cylinder. The worm dimension is taken from the part catalog Engrenages H.P.C, June 1999 edition. The worm above corresponds to the part ref. W1,5-1 page 358.
angular degree
20deg
Angle de pression.
2 3 4 5
m N D L
millimeter real
Module. Nombre de tours du filet de la vis. Diamtre du cylindre primitif. Longueur du filetage. Angle d'hlice de la vis. Doit tre gal l'angle d'hlice de la roue correspondante. Dcalage de la surface de la vis suivant l'axe Z. Pas de la denture sur une crmaillre gnratrice rectiligne. Epaisseur d'une dent mesure sur le cercle primitif.
(psi)
dZ
millimeter -L/2
millimeter m *
millimeter p / 2
10 ha
millimeter m
11 hf
millimeter m * 1.25
12 rr
millimeter m * 0.38
normative formula.