Professional Documents
Culture Documents
N WRITING
2
IT
N
U
BRIEF SPECIFICATION FOR 1ST CLASS
BRICKWORK IN CM (1:6)
Properties of Bricks – Soaking in water – mortar – Workmanship –
measurement – Scaffolding.
Brick shall be table – moulded, well burnt in approved kiln, copper
coloured, free from cracks and with sharp and square edges
The brick shall be uniform in shape and shall be of standard size
and shall give a clear ringing sound when struck with each other.
The brick shall not absorb water more than one fifth of their weight
after one hour of soaking in water.
Brick shall have maximum crushing strength of 10.5 N/mm2.
The bricks shall be well soaked in water for atleast 12 hours before
their use, preferably in water tank provided at site of work.
The proportion of mortar shall be 1:6 by volume.
The cement shall be standard quality.
The sand shall be clean and course.
The cement mortar shall be prepared in required quantity of
not more than one bag of cement at a time and this shall be
or in a steel trough.
and level.
The mortar shall break for bonding and shall not exceed 10
mm in thickness.
Only skilled masons shall be employed on the work and the work
shall be kept well watered for at least 15 days.
The thickness of wall shall be paid for as one brick, one and half
bricks, two bricks and so on.
The marble to be used for the work shall be first class quality,
free from cracks, non porous, uniform in colour and carefully
selected so as to present harmonious veins throughout the
finished work.
The samples of each type to be used shall be submitted to
show the full range of variation and the work shall be
completed with marbles in accordance with the approved
sample by the engineer.
All necessary bronze or brass anchors , dowels, clamps, wires
etc, required to secure the marbles in place shall have to be
provided by the contractor and built in at no extra cost to the
The vertical work commencing at floor level shall be allowed to
set before the flooring is laid and the marble shall extend
about 25mm below the finished floor level.
The marble for dado and skirting shall be set in non staining
white cement and of height described in drawing.
The payment shall be made for the actual work done on site on
superficial area basis and no extra amount shall be paid for
wastage of materials, anchors, dowels, etc,
The rate of the marble work shall include any drilling, cutting,
fitting or making any special provisions required in the marble
work.
SPECIFICATION FOR 12MM THICK CEMENT PLASTER
IN CM (1:4)
Preliminary – process of first coat – second coat of
sagol finish after six hours of first coat – watering –
three coats of white or colour wash - measurement