Professional Documents
Culture Documents
4G3 ATN910i Commissioning Guide: Huawei Technologies Co., LTD
4G3 ATN910i Commissioning Guide: Huawei Technologies Co., LTD
www.huawei.com
GE fiber cable
2G 3G 4G-TDD 4G-FDD
2G 3G 4G-TDD 4G-FDD
Once enter the system view ,the bracket NE Name changed successful
becomes “[ ]”
Command Lines:
<ZBR058_ATN_NE1> sys #To enter system view
[ZBR058_ATN_NE1] undo dcn #To disable dcn
Y #To confirm the configuration
ATN910i ATN910i
Trunk port means the port which can allow more than 1 VLAN ID;
All ATN ports should be configured as “TRUNK”;
Configure the interface0/2/10 for “Trunk” as below (for example):
Command Lines:
interface Gigabit Ethernet 0/2/X #To enter the required port
Undo shutdown #To enable this port
Portswitch #To configure this port as layer2
port link-type trunk #To configure this port as trunk
Port trunk allow-pass vlan xxxx xxxx #Configure the vlans which
need be allowed on this port ,
separate different vlans by space.
RTN310-NE1 NE4
GNE
XPIC E-LAG
E-LAG XPIC
GE0/2/5 GE0/2/4
ATN910i ATN910i
To run this save command , you should under the <HUAWEI> view, if your are under system-view
[HUAWEI] , please use “quit” command quit system-view.
As 0/2/8 and 0/2/9 configured as access, you can just connect the lap top to this 2 ports to
do CWO test for 2G and 3G.
0/2/10 is configured as “trunk”, the message come to these ports must be tagged with vlan.
So If your laptop is vlan-supported, you can just configure the required vlan to your lanport,
and do the CWO test for 4G.
If your laptop is not vlan-supported, you can configure the 0/2/11(last one) which is spared
as “access” , and assign the 4G vlan on it to do CWO test.