Professional Documents
Culture Documents
CAT 6060
2
Grease Pump Service Training
Active Oil
Pressure on
Grease Pump
Example:
Servo Pressure: 48 bar
3
1000kg Tank Service Training
4
Control Panel Service Training
On/Off Solenoid
for Grease Pump
Undercarriage System
-5Y4
Unloader Valve
Undercarriage System
-5Y5
Undercarriage System
Pressure Sensor -5B7
From Undercarriage
Grease Pump
Tank Return
Oil / Grease
Grease Supply
Grease Tank Return
5
1000kg Tank – 2 Pumps Service Training
6
Undercarriage Grease Supply Service Training
to the Injectors
8
Grease Injectors Service Training
9
Grease Injectors Service Training
11
Greasing System Function Service Training
Grease
Grease Pump “ON” Grease Pump “ON”
Pump
Travel
Travel Function “activated”
Function
180
Pump
Pressure
[bar]
50
[Time]
min. 5 s max. 30 s max. 60 s max. 60 s 5s max. 30 s max. 60 s
12
Greasing System Function Service Training
As well in the normal mode as in the test mode the following conditions must be given:
• The engine must be running.
• The grease drum must not be empty.
• There must not be any error message.
• No “50bar pressure built up” after start of the pump within 30sec (t2 – t1)
• No “50bar to 180bar pressure built up” within 60sec (t3 – t2)
• No “180bar to 50bar pressure decrease” after switch off the pump within 60sec (t4 – t3)
=>Fault messages can only be deleted by pressing the reset button (for 1 sec).
BCS fault messages (without grease pump being switched off) undercarriage:
The test mode is initiated by pressing the reset button for 5 sec. The pump operates 15 min. continuously.
The test mode can be stopped by pressing the reset button for 1 sec !
13
More Information? Service Training
Hey Fellows,
14