Professional Documents
Culture Documents
Company Review
Company Review
Presentation
Design basis of NRL project
Basics of Staad modeling was A piperack layout was modelled The modeling image has been
revisted. Various tools in staad in staad with the given attached.
software was introduced. Dimensions where tools learnt
are put into practice.
3D View of the Staad drawing
Introduction to Navis and Pipe rest Conditions
At 2 end bays
Elevation of Piperack
PIPE LOADS
CALCULATION IN
SPREADSHEET :
REFERENCE AXIS :
Comparing the axis given in the pipe load file and the staadpro software, axis were
changed according. Consequently, the values of loads were also entered in the
respective changed columns.
13
DESCRIPTION OF PIPE LOADS
Accordingly,
Beam number :
The beam(number) on which the pipe lies.
Grid number :
6 grids were considered and was entered accordingly.
14
DESCRIPTION OF PIPE LOADS
Pipe name :
for 1st rack :
12"-GO-1S80-06003-BIA-NI
16"-GO-1S80-06007-B1A-NI
20"-HSD-1S80-07007-A1A-NI
16"-MS-1S80-11006-A1A-NI
16'-HSD-1S80-07002-B1A-NI
15
DESCRIPTION OF PIPE LOADS
Node name :
Viewing the navisworks drawing, the nodes and the corresponding resting conditions
are noted in excel file. The input file from the piping section in which the pipe loads are
given with support conditions is taken as a reference file.
16
DESCRIPTION OF PIPE LOADS
Piping loads :
As per the test cases and the loads of input from the piping section, loads were entered
accordingly by changing the axis for the staad file.
18
DESCRIPTION
OF PIPE LOADS
19
Developmental Activity
THANK HARINI T
YOU
VISALAKSHI G R
22