Sanding was a key part of the project that gave a smooth finish and rounded edges. The author sanded down points and edges on the handle and top to give it a cleaner look with curved rounded edges meeting at points. Sanding also helped thin parts that had become chipped. Multiple sandings of points were needed to prevent chipping from too much force.
Sanding was a key part of the project that gave a smooth finish and rounded edges. The author sanded down points and edges on the handle and top to give it a cleaner look with curved rounded edges meeting at points. Sanding also helped thin parts that had become chipped. Multiple sandings of points were needed to prevent chipping from too much force.
Sanding was a key part of the project that gave a smooth finish and rounded edges. The author sanded down points and edges on the handle and top to give it a cleaner look with curved rounded edges meeting at points. Sanding also helped thin parts that had become chipped. Multiple sandings of points were needed to prevent chipping from too much force.
Sanding, I had gotten cutting done fairly quickly compared to most people.
So, I had plenty
of time to sand. Sanding was the key part in my project. It gave me the extra Sanding smooth finish, rounded edges and a sleek design that flows nicely. On the points on my handle and my top, there were all curved down to give it a cleaner look. Two and Even rounded edges would meet at this point, which caused it to be more rounded down. I had to sand out my mistakes from using the rasp. It fixed the problem fairly More well and still had a nice look to it. Sanding down the face of the handle and top also helped as it made the piece thinner, as it was chipped on the front at the edge. Sanding I also had to go back and sand the points of my top multiple times because it would end up chipping itself because it had too much force. Making and Putting in the Dowel In reality, Mr. Spiers had made the point on the dowel for me and also glued it into my top. But, I had helped a couple of my friends on how to put in the dowel. Many of them were not aligning the top of their dowel, with the top of their spinner. So I helped them fix that. One was also having a hard time figuring out how to put the dowel in. I helped him with that. Even though Mr. Spiers did it for me, I believe I could have done it just the same. Drilling the Hole For the String First time around, I had filed the dowel too much. Also, the first time I drilled the hole. The dowel had splintered and broke in half. The file could have been a contribulting factor. So, I had to glue it back together. Fortunately, it was the end of the class, so I did not waste time by having nothing to do. Next class, the glue had dried and I filed way less and did not end up breaking the dowel. I had drilled the hole at another spot to minimize it breaking again, and it ended up working. Burning the String Burning the string was not just difficult, bit painful too. I had problems with getting the right temperature (I didn’t want to burn my hand, I still ended up doing that plenty of times, or it being too cold to handle) and not burning it too much because that would make the string too rigid at the ends. I also had to burn the string multiple times because when I would launch the top, it would end up ripping. This made me lose a lot of string. But, in the end, after trial and error, and burning alot of my string off, I managed to get the perfect burn amount which didn’t rip or too thick on the ends. The Final Product Click to next slide to see beyblade fight Please wait while the video is loaded…