Professional Documents
Culture Documents
NOSE Kator-Berci
SKULL BASE THROAT &
Weerda
SURGERY
ENT
Projects
2008/2009 SInuFit
LaryngoFit
Unidrive ENT
OUT PATIENT
NPU Set
EAR Simulator Fiberscopes
ENDOSCOPIC EAR SURGERY
Rationale
Following the ear canal with the endoscope leads directly to the attic
Anatomie de l’Oreille
Anatomie Oreille : les 3 compartiments
Field of View
•Allows a “what- you- see- is- what- you- get” •Leads to the creation of extensive cavities
open cavity •Causes the removal of a huge number of healthy
•Would open up only the areas where disease bones
reside •Inferior hearing results
•Maintains much of the healthy and cortical
•Trauma in the ear canal which results in fibrosis
bone intact
and narrowing of the meatus
•Allows the surgeon to observe any residual
cholesteatoma
•Does not affect hearing results
•Allows for minimally invasive surgery that
facilitates the ossicular reconstruction
8
Endoscopic Management of Cholesteatoma
9
Endoscopic-Guided Middle ear Surgery
recommended Set according to Dr. M. TARABICHI
Endoscopic-Guided Middle ear Surgery
recommended Set according to Dr. M. TARABICHI
Endoscopic-Guided Middle ear Diagnosis recommended Set according to Dr. M. TARABICHI
Endoscopic-Guided Middle ear Diagnosis recommended Set according to Dr. M. TARABICHI
Endoscopic-Guided Middle ear Diagnosis recommended Set according to Dr. M. TARABICHI
Endoscopic-Guided Middle ear Diagnosis recommended Set according to Dr. M. TARABICHI
Endoscopic-Guided Middle ear Surgery
recommended Set according to Dr. M. TARABICHI
Endoscopic-Guided Middle ear Surgery
recommended Set according to Dr. M. TARABICHI
Endoscopic-Guided Middle ear Surgery
recommended Set according to Dr. M. TARABICHI
Tarabichi Live Op Recommended set for EES
Tarabichi EES Workshop Miniset
Endoscopic
Lenarz Ear Surgeries
Cochlear Fisch Prosthesis
Implantation
Steiner
Stammberger
Laser Set
FESS Set
EAR
NOSE Kator-Berci
SKULL BASE THROAT &
Weerda
SURGERY
ENT
Projects
2008/2009 SInuFit
LaryngoFit
Unidrive ENT
OUT PATIENT
NPU Set
EAR Simulator Fiberscopes
Closed Cavity Technique
Stapedotomy
22
S Incus- Stapedotomy tapedotomy
23
Incus- Stapedotomy
24
Incus- Stapedotomy
The correct size of the opening (0.5 mm) is confirmed with a 0.4
mm Calibre Rod
26
Malleo- Stapedotomy
27
Malleo- Stapedotomy
28
Malleo- Stapedotomy
The shaft of the prosthesis may be bent along various planes on the cutting
block to accommodate the anterior position of the malleus. This is done
while the prosthesis is in the 0.4 mm hole of the cutting block by gently
bending it to the correct extent by pushing the shaft with Watchmaker
Forceps
29
Malleo- Stapedotomy
31
Stapedotomy
The loop is crimped over the incus with a The loop is crimped over the malleus
small straight Smooth Alligator Forceps handle using a small and a large straight
Smooth Alligator Forceps
32
Total Reconstruction of the Ossicular Chain
33
Total Reconstruction of the Ossicular Chain
If more strength is
required, a special
Crimping Forceps can
be used to squeeze the
foot tightly to the shaft Special Titanium Scissors can be
used to reduce the diameter of the
prosthesis head
The FTTP is used without a shoe if the oval window is too narrow or the stapes
arch remains in place
The thickness of the FTTP head is only 0.1 mm which makes the plane of the
prosthesis adaptable to the drum position in the vertical and horizontal planes
The FTTP has the ability to change the length of its L-shaped arm. For this
purpose it shall be grasped with two watchmaker forceps and straightened then
bent in the desired angle
34
Total Reconstruction of the Ossicular Chain
The FTTP is
transported from the
cutting block to the
middle ear using a
special Curved
Holding Forceps or
with the largest
microsuction tube
35
The Fisch Titanium Neo Malleus
36
FISCH Instruments
Instruments
Retractors
Scissors
Suction tubes
Dressing forceps
Micro instruments
Micro-forceps and -scissors
FISCH Instruments
NOSE Kator-Berci
SKULL BASE THROAT &
Weerda
SURGERY
ENT
Projects
2008/2009 SInuFit
LaryngoFit
Unidrive ENT
OUT PATIENT
NPU Set
EAR Simulator Fiberscopes
Cochlear Implantation
by Dr. Lenarz
Definiton:
Incision
Incision approximately 1 cm behind the retroauricular fold
The pinna is elevated from the underlying tissues
Periosteal pouch
A pouch is created with the straight raspatory
NOSE Kator-Berci
SKULL BASE THROAT &
Weerda
SURGERY
ENT
Projects
2008/2009 SInuFit
LaryngoFit
Unidrive ENT
OUT PATIENT
NPU Set
EAR Simulator Flexible Scopes
LASER
Light
Amplification by
Stimulated
Emission of
Radiation
71
LASER
72
CO2-LASER
Procedures, Indications, Instruments
73
CO2-LASER
Procedures, Indications, Instruments
Polyps
Reinke-Edema
Granuloma
Papilloma
Nodules
Cysts
Carcinoma of oral cavity
and pharynx
Vocal cord carcinoma
Laryngeal cancer
74
CO2-LASER
Procedures, Indications, Instruments
Instruments
75
Le larynx
laryngoscopie
Endolaryngeal Microsurgery - Instrumentation
80
LASER Instruments acc. to STEINER
8661 AN Distending Laryngo-Pharyngoscope
8661 AN 8666 AN
LASER instruments acc. to STEINER
8666 DN Distending Oropharyngoscope
8661 CN 8661 DN
8661 EN
-For routine -For use in patients where -For special cases with
the introduction of the difficult anatomy
Laryngoscopy
laryngoscope is impaired -For use of attachable,
-Integrated suction (difficult anatomy) as movable suction tubes of
channel to remove vapor well as for use on varying lengths (8661 M,
allows unobstructed view children 8661 N in combination
with adaptor 8661 P) is
-Medium-large, for adults, -Integrated suction recommended
length 18 cm channel
-Extra small size, flat,
-Length 19 cm length 20 cm
LASER Instruments acc. to STEINER
8661 CN/DN/EN Operating Laryngoscopes
All laryngoscopes 8661 CN, DN, EN now with new matt finish for
LASER surgery.
These models NOT weight reduced, only 8661 AN and 8666 series.
87
LASER Instruments Acc. to STEINER
8662 D/E/F/G/GL/H Grasping Forceps
For carefully yet effectively grasping tissue, available in 5 sizes; two of them
are additionally equipped with a suction tube
Length 22 cm
All forceps with new alligator teeth
88
LASER Instruments Acc. to STEINER
8593 GM/HM Ultra Fine Grasping Forceps
89
LASER Instruments Acc. to STEINER
8593 GM/HM Ultra Fine Grasping Forceps
90
LASER Instruments Acc. to STEINER
Additional Instrumentation
Extra delicate grasping forceps with insulated shaft, curved to the right or left
Clip forceps for endoscopic introduction of vascular clips for closing vessels, jaws
angled to the right or left
Unipolar cannula for suction and coagulation with different diameters
Protectors for protecting lower regions of the mucous membrane against accidental
LASER irradiation
91
Recommended Sets - Tender, Basic, Specialist
RECOMMENDED SETS
Tender Set
Basic Set
Specialist Set
92
Endoscopic
Lenarz Ear Surgeries
Cochlear Fisch Prosthesis
Implantation
Steiner
Stammberger
Laser Set
FESS Set
EAR
NOSE Kator-Berci
SKULL BASE THROAT &
Weerda
SURGERY
ENT
Projects
2008/2009 SInuFit
LaryngoFit
Unidrive ENT
OUT PATIENT
NPU Set
EAR Simulator Fiberscopes
Throat
KANTOR / BERCI
Video-Laryngoscopes
-
Better Protection due to Smart
Design
Throat
• Greater Depth
Focus
• No need to adjust
focus
• The magnified
image can be
observed from
the ideal distance • Better acces to
the anterior
comissure
• No operation
fatigue
• Simplifies the
work of the
assistant
Endoscopic
Lenarz Ear Surgeries
Cochlear Fisch Prosthesis
Implantation
Steiner
Stammberger
Laser Set
FESS Set
EAR
NOSE Kator-Berci
SKULL BASE THROAT &
Weerda
SURGERY
ENT
Projects
2008/2009 SInuFit
LaryngoFit
Unidrive ENT
OUT PATIENT
NPU Set
EAR Simulator Fiberscopes
Flexible Endoscopes
Video Rhino-Laryngoscope
Video Rhino-Laryngoscope
Sterilizable
Waterproof With Eto gas, Steris and
item number:
11101 VP (PAL)
11101 VN (NTSC)
direction of view: 0°
angle of view: 70° 85 °
deflection: up 180°, down 90°
working length: 30 cm
outer diameter: 3,5 mm
Video Rhino-Laryngoscope
Leakage Tester
With bulb and manometer
11025 E
Rhino-Pharyngo-Laryngo-Fiberscope
Rhino-Pharyngo-Laryngo-Fiberscope
EDGE PRODUCTS
Improved flexible Rhino-Pharyngo-Laryngo-
Fiberscope
Smoother Sheath
More robust
More Flexible
• Ref. No.:
11101 RP
• In the catalogue and in the
confirmation of order it will
be written 11101 RP
Rhino-Pharyngo-Laryngo-Fiberscope
Laryngo-
Fiberscopes
1101 RD 1101 UD 11101 RP 11101 SK 11101 SP
Diameter
Deflection
Working
Channel
Inner 1.5 mm 2.3 mm - - -
Diameter
HERRMANN
Pharyngo-Esophago-Fiberscope
HERRMANN Pharyngo–Esophago-Fiberscope
HERRMANN Pharyngo-Esophago-Fiberscope
13304 C Pharyngo-Esophago-Fiberscope,
working length 76 cm, O.D. 3.7 mm,
deflection up 200° and down 100°
Contact:
Prof. Ingo. F. Herrmann, Rome
i.herrmann@europeanhospital.it
HERRMANN Pharyngo-Esophago-Fiberscope
Usage
The fiberscope is
introduced transnasally
Usage
Rhino-
Laryngo
…
Fiberscopes
Pentax Wolf
Competitors
Rhino-Laryngo Fiberscopes
Pentax Wolf
TFS 2.4 150°/90°
61288FNL-7RP3 TFS 2.5
120°/90°
160°/120°
TF 3 180°/90°
61289FNL-10RP3 160°/90°
170°/90°
61287FNL-15RP3 TFA 5
140°/90°
180°/90°
TF 5 4 way:
Up/ Down 130º TF 6/ TF 8/ TF 11
180°/140°
4 way:
120°/120°
Competitors
Rhino-Laryngo Fiberscopes
Rhino-Laryngo Fiberscopes
61288FNL-7RP3 70 cm
110 cm
TFS 2.5 70 cm
61289FNL-10RP3 30 cm TF 3 45 cm
70 cm
61287FNL-15RP3
110 cm
140 cm
190 cm
TFA 5 69 cm
69 cm
TF 5 104 cm
130 cm
TF 6/ TF 8/ TF 11 132 cm/ 182 cm
Competitors
Rhino-Laryngo Fiberscopes
Rhino-Laryngo Fiberscopes
Video Rhino-
Laryngoscope
Endoscopic
Lenarz Ear Surgeries
Cochlear Fisch Prosthesis
Implantation
Steiner
Stammberger
Laser Set
FESS Set
EAR
NOSE Kator-Berci
SKULL BASE THROAT &
Weerda
SURGERY
ENT
Projects
2008/2009 SInuFit
LaryngoFit
Unidrive ENT
OUT PATIENT
NPU Set
EAR Simulator Fiberscopes
UNIDRIVE ENT Features
Save Time
Save Money
Relieve OR Personnel
Other features
2 Motor outputs
2 Motors can be connected simultaneously
Possible to change active output from the sterile area via footswitch
No plugging or unplugging during an operation
Shaver system for paranasal sinus and anterior skull base surgery (7000
rpm with DrillCut-X shaver handpiece)
40711040
126
STAMMBERGER-CASTELNUOVO DrillCut-X Shaver handpiece
Hygiene
No clogging Security Ergonomic
WHEN POWER MEETS PRECISION
STAMMBERGER-CASTELNUOVO DrillCut-X Shaver
handpiece
40711040
129
STAMMBERGER-CASTELNUOVO DrillCut-X Shaver handpiece
With Lock for positioning shaver blades and sinus shavers, if required
Thinner
Reduced vibration
No overheating
New surface easier to clean
132
Tubing - Set
sterilizable or disposable
EC - Micro
Motor
Shaver Sinus
Blades Burrs
NOSE Kator-Berci
SKULL BASE THROAT &
Weerda
SURGERY
ENT
Projects
2008/2009 SInuFit
LaryngoFit
Unidrive ENT
OUT PATIENT
NPU Set
EAR Simulator Fiberscopes
Karl Storz GmbH & Co. KG
Out Patient
Clinics
ENT
Table of Content
TelePack
Fiberscope 11101 RP
LED battery Light 11301 DF
Headlight 094120
Nose and Ear Scope 7209 BA
Larynx and Nose 7230 CA
Special Instrument set for Clinics
Power Of Light
LED -Technology from KARL STORZ
LED Portable Light Sources
LED-battery handle
power of light -
LED-battery handle
- power of light -