CARRIER AGGREGATION by Ishant Kukreja CARRIER AGGREGATION
Its combination of two component carrier which increase the throughput .
Here we have Primary component carrier(PCC) and Secondary component carrier (SCC) There will be total 5 component carrier that Ue Listen So, we have 5CC=PCC+4SCC Primary cell is responsible for the signalling part. Primary cell adds or deletes the Scell. Primary cell activates or deactivate Scell. Here CA depends on various factors UE capability Scell addition Scell activation UE CAPABILTY Access stratum Release if access stratum release having REL10 ,REL11 it means it supports ca. UE CATEGORY • Its means if it supports Cat 6,7,8 its means it supports ca . CA BANDWIDTH CLASS Here we have bandwidth class. (A-1) it means its having only one component carrier. (B-2 ) it means its having only two component carrier. (C-2) it means its having only two component carrier. (D-3) it means its having only three component carrier. (E-4 ) it means its having only four component carrier. Here we can achieve CA schemes in three ways. Intra band contiguous Primary component carrier PSS and Secondary component carrier SSS have same band.. EXAMPLE = CA-3C Intra band non- contiguous Primary component carrier PSS and Secondary component carrier SSS have same band.. EXAMPLE= CA25A-25A Inter band non-contiguous. P Primary component carrier PSS and Secondary component carrier SSS have Different band.. EXAMPLE=CA25A-41A BANDWIDTH COMBINATION SET No of possibilities each band supported on bandwidth that is bandwidth combination set .. SCell Addition and Activation Scell addition and activation is done in two ways: 1.Blindly 2. Based on measurement report Here UE sends its UE capability to p-cell as attach complete . UE sends the measurement report to p-cell. then p-cell sends RRC Reconfiguration message to UE to Add ScellToAddModList. Ue sends RRC Reconfiguration Message Complete THANKYOU