Professional Documents
Culture Documents
Data Input
References
Applicable Code
Piping class
151440Y
Material of Pipe
OD of Pipe (D)
2.375
inch
in
(Pipe Size(NPS))
Pressure (P)
261.1
psig
18
bar G
Temperature (T)
185
deg F
85
deg C
0.000
inch
mm
38700
psi
0.4
P * D 2(S*E*W+P*Y) in
thk = Adding Corrosion Allowance ,"tm" thk= Adding Mill Tolerance of 12.5%, "tm" thk= \ Min Wall Thickness required, "tm" = Selected Pipe Thickness
0 008 0.008
0.008
in
(tm = t + CA)
in
mm
mm
OK
1of2
EPC FOR TIE-IN WORKS AT SE PIPE WALL THICKNESS CALCULATION SHEET DOC. NO. : 30.99.23.0688 APPENDIX G REV. 1
CALCULATION TABLE - PIPING CLASS 013842X Sr. No 1 2 3 4 5 6 7 8 Pipe Size "NPS" 0.5 0.75 1 2 3 4 6 8 Pipe OD "in" 0.84 1.05 1 31 1.315 2.375 3.5 4.5 6.625 8.625 Dsgn Thk ( t ) "in" 0.003 0.004 0 004 0.004 0.008 0.012 0.015 0.022 0.029 DsgnTh k 0.003 0.004 0.004 0.008 0.012 0.015 0.022 0.029 Min. thk reqd "in" mm 0.003 0.082 0.0040 0.103 0 00 1 0.0051 0 128 0.128 0.0091 0.232 0.0135 0.342 0.0173 0.439 0.0255 0.647 0.0332 0.842 Selected Selecte "Sch" d Sch.- 40S 2.77 Sch.- 40S 2.87 S h 10S Sch.2 2.77 Sch.- 10S 2.77 Sch.- 10S 3.05 Sch.- 10S 3.05 Sch.- 10S 3.40 Sch.- 10S 3.76 Status OK OK OK OK OK OK OK OK
NOTE: 1 Design pressure, allowable stress, joint efficiency factor, factor-y and weld joint strength reduction factor are taken same as indicated in sample calculation
2of2