Professional Documents
Culture Documents
Lesson 4 - Train 4: Input Hopper Walls 3 Hopper Flange 4
Lesson 4 - Train 4: Input Hopper Walls 3 Hopper Flange 4
Lesson 4 - Train 4
Study first the drawing(s) and Start New Model Create 3d View Create Grids Create Views (3d, Plans & Elevations)
Input Hopper Walls 3 Hopper flange 4 Construct workpoints for Hopper flange 4 Input flange 5 Add holes to Hopper flange 5
Page 4-1
Page 4-2
Page 4-3
Hopper flange
Construct workpoints for Hopper flange
Using the elevation view on Grid B, place points on the outside edge of the hopper wall where it intersects with the +0.400 level. See below.
Do this for both left and right edges. Repeat this in the Elevation views on Grids C, 2 & 3. Bring up the plan view at RL +0.400 and you will see the points that have just been created as yellow crosses.
Page 4-4
Construct the corner points using the Create line line intersection point command. Pick two of the points on a side and then two points on an adjacent side.
Input flange
Now input the flanges using the Beam Properties dialogue box.
Page 4-5