Professional Documents
Culture Documents
Step 1: Open A Sketch On The Front Plane
Step 1: Open A Sketch On The Front Plane
Step 1
open a sketch on the front plane
2. Step 2
draw a line 75mm
3. Step 3
continue
4. Step 4
continue
5. Step 5
continue
6. Step 6
use revolve command
7. Step 7
open a sketch on the front plane .
8. Step 8
draw a 23mm line
9. Step 9
continue
10. Step 10
finish the sketching
11. Step 11
use revolve command.
next: http://grabcad.com/questions/tutorial-how-to-make-engine-part-47
1. Step 1
open a sketch on the front plane
2. Step 2
draw a line up to origin
3. Step 3
continue
4. Step 4
draw two lines and use trim command
5. Step 5
continue to sketch
6. Step 6
continue to sketch
7. Step 7
continue to sketch
8. Step 8
finis the sketch
9. Step 9
use revolve command
10. Step 10
open a sketch on the front plane again
11. Step 11
draw shown sketch
12. Step 12
use fillet command
13. Step 13
extrude it
next: http://grabcad.com/questions/tutorial-how-to-make-engine-part-48
1. Step 1
open a sketch on the blue face
2. Step 2
draw a hexagon
3. Step 3
use cut extrude command
4. Step 4
open a sketch on the front plane....
5. Step 5
draw shown triangle
6. Step 6
exit from the sketch and open a sketch on the shown face
7. Step 7
draw a circle
8. Step 8
insert a helix
9. Step 9
enter shown values
10. Step 10
use cut sweep command
11. Step 11
open a sketch on the front plane again .
12. Step 12
draw shown sketch..
13. Step 13
draw the upper side
14. Step 14
draw a centerline
15. Step 15
use revolve cut command
16. Step 16
save the "sparg plug"
next: http://grabcad.com/questions/tutorial-how-to-make-engine-part-49
17. Step 17
GrabCAD sparg plug