Professional Documents
Culture Documents
[Type text]
[Type text]
AutoCAD
Lab#05
Submitted to:
Sir Talha
Submitted by:
Moazma Batool
12-EE-58
Submitted on:
05-06-2013
AutoCAD:
Lab#06
ECAD
05-06-2013
Toolbar DRAW main strip to draw lines, 2D characters, but also we can use this command to draw in 3D. The same
commands can be used via the draw. Locate the tape can be anywhere on the working window in the system of Drag
and Drop
Line, Ray, Construction line, Multiline, Polyline, 3D Polyline, Polygon, Rectangle, Helix, Arc, Circle, Donut, Spline,
Ellipse, Block, Table, Point, Point, Hatch, Boundary, Region, text
Lines using the line command can be drawn with the mouse, as well as absolute, relative, polar coordinates and the other concerned
the chapter coordinator.
Techniques:
Moazma Batool
12-EE-58
A1
Lab#06
ECAD
05-06-2013
Figure # 01:
Moazma Batool
12-EE-58
A1
Lab#06
ECAD
05-06-2013
Figure # 02:
To form the required figure, we will click anywhere on the auto CAD
area, and then write the required measurements in the command
line, for example we will write @3<150 for a line of 3m length and at
150 angle.
Angles like 0, 90,180,270,360 are known, in addition to these 30,-30,
150 and -150 can be found visually.
We will draw a reference line and the whole figure is drawn with
reference to it.
Moazma Batool
12-EE-58
A1