Professional Documents
Culture Documents
Mode Control
Suryanarayana K
Department of Electrical and
Electronics Engineering
NMAM Institute of Technology
Karkala, India
suryanarayana@nitte.edu.in
I.
INTRODUCTION
Vishwas K
Design Engineer
HEXMOTO Controls Pvt. Ltd
Mysore, India
vishwas@hexmoto.com
(1)
V = V = DV .
IV.
i = i
(3)
= H F sF s
H =
F s =
F s =
(6)
(7)
.
(8)
(9)
=
(10)
Q =
m = 1 +
(11)
(12)
m =
(5)
(13)
H s =
1
;
CR
. .
R = 1 4f T + 16f T ;
R = 1 +
39.48C f L R
L + 0.32RT
(14)
V.
(15)
VII. CONCLUSION
Peak current mode control was implemented mainly with
analog components until now. The control loop and ramp
generation for slope compensation had analog components
and so limits the design flexibility. But with present day
processors having on chip peripherals like analog to digital
converters, digital to analog converters and comparators, the
control has become more feasible. Slope compensation to
eliminate the sub harmonic oscillations can be easily
incorporated with these processors. The amount of slope
compensation can be adjusted depending on operating
parameters of the converter. This guarantees required
dynamic performance of the current control loop digitally
REFERENCES
[1]
Figure 11. Inductor Current and PWM Pulses with Slope Compensation
Bode Diagram
80
Power Stage
Controller
60
Mag (dB)
40
20
0
-20
-40
0
-45
Phase
(degree)
-90
-135
-180
10
10
10
10
Frequency (Hz)
100
Mag(dB)
50
-50
-100
-90
Phase
(degree)
-135
-180
-225
-270
-1
10
0
10
1
10
2
10
3
10
10
10
Frequency (Hz)
Figure 13. Frequency Response of the Converter with Peak Current mode
Control