Professional Documents
Culture Documents
SWANSEA UNIVERSITY
School of Engineering
SEMESTER 2 EXAMINATIONS
JUNE 2008
EG-284
Manufacturing Technology II
LEVEL 2
2 hours
Answer THREE questions
TURN OVER
Page 1 of 3
1. The photograph below shows a typical cross section through a spot weld joining two
thin plates.
A)
B)
The figures below show a typical steel weldment cross-section. Which techniques
would permit you to carry out non-destructive testing to determine the integrity
and quality of this type of weld?
[10 marks]
C)
You have been asked to carry out an NDT investigation of a large grey cast iron
component using ultrasound. What difficulties can you foresee?
[5 marks]
Page 2 of 3
TURN OVER
3. Describe wire cutting Electric discharge machining.
[18 marks]
What unique feature of the machining process make it particularly suited to the manufacture
of compacting dies, extrusion dies and turbine blades?
[7 marks]
4. What is glow discharge?
[6 marks]
Describe the process of plasma nitriding using a glow discharge. What are its advantages and
disadvantages?
[16 marks]
What advantage does this form of surface treatment confer to a component?
[3 marks]
END OF PAPER
Page 3 of 3