Professional Documents
Culture Documents
4) Make a rectangular block in the workspace, this block is actually the boundary of
your PCB.
6) Place all these components in the workspace one by one as shown below. The
At this point the routing properties box will open that allows you to set the width of
the connections and PCB layers etc. The ARES software will automatically route the
connections for you resulting in a diagram similar to the one below:
9) The complete circuit should be printed on paper to proceed with the next
steps.
Tasks:
1) Draw the schematic for H-bridge. (To be submitted in schematic format, NOT
jpeg /image).
2) Convert to PCB format using ARES and route all connections. Explain any
gaps and differences in your PCB.
3) Take a printout of your project with name of group members in lower right
hand corner.