Professional Documents
Culture Documents
DIVISION
32 - EXTERIOR IMPROVEMENTS
SECTION 32 11 23
- Aggregate Base Course
June 2013
Project :
Location :
DIVISION
SECTION 32 11 23
EXTERIOR IMPROVEMENTS
-
PART 1 GENERAL
1.1
SCOPE
a.
b.
c.
Page 1 of
1.2
SUB-BASE
+10
mm
Permitted variation
from design LEVEL
OF SURFACE
+20
-30
mm
-10
Permitted SURFACE
IRREGULARITY measured
by 3m straight-edge
mm
30
20
Permitted variation
from design CROSSFALL
or CAMBER
0.
5
0.
2
Permitted variation
from design LONGITUDINAL
GRADE over 25m length
0.
1
0.
1
-10
+5
PART 2 PRODUCTS
2.1
MATERIAL REQUIREMENTS
a.
Aggregates
1.
Page 2 of
The material shall comply with the following grading and quality
requirements.
1.
c.
2.
3.
4.
5.
6.
7.
Filter
Page 3 of
PART 3 EXECUTION
3.1
CONSTRUCTION REQUIREMENTS
a.
Placing
Crushed aggregate base shall be delivered to the site of the work as a
uniform mixture. The placing of the material shall conform to the
requirements of Section 32 11 16.16 entitled Granular Sub-base
Course.
b.
Compacting
Compacting shall conform in all respects to the requirements specified
in Section 32 11 16.16 entitled Granular Sub-base Course.
c.
Compaction Requirement
The compacted dry density of each layer of the compacted base shall
not be less than 100 percent of the maximum dry density determined
according to AASHTO T180, Method D. the field density shall be
determined according to AASHTO T191.
d.
Trial Sections
Trial sections shall conform in all respects to the requirements specified
in Section 32 11 16.16 entitled Granular Sub-base.
e.
Tolerances
The base shall be laid to the designated level and transverse slopes as
shown on the Drawings. The allowable tolerances shall be in
accordance with Table 1.
END OF SECTION
32 11 23
Page 4 of