Professional Documents
Culture Documents
1) LIGHT 2)WATER
3)EXTERN 4)REL
By pressing 1-4 you select what equipment is connected to the actual relay.
If no equipment is connected to one or more of the outputs, select external equipment by pressing 3.
When all outputs are defined, setting of the connected equipment is concluded.
1)FILL. 2)OUTPUT
3)ACTIVE 4)SETUP
Press 2 if the system operates with two completely separate feed circuits. Press 1 if the system operates with
one feed circuit delivering feed to the other circuit. See section 7.10 on page 32.
DELAY. START-UP
1)SYS. 1 2) SYS. 2
34
In this menu either 1 or 2 must be pressed, whether delay is required or not. Otherwise the choice
of “same system” will not be saved.
It can now be determined whether system 1 or system 2 is to be delayed. This might be useful if
it takes a long time before the feed reaches the circuit in which it should be delivered.