Professional Documents
Culture Documents
Features Enhanced
Fix the disconnect issue reduce connect when set wpa security and run zftp
New Features
Features Enhanced
Fix the disconnect issue of heavy traffic (zftp) when use WPA
Features Enhanced
New Features
DMZ
Port Forwarding
Add WPA enterprise Group key & Pairwise key Update timeout setting
Add WPA enterprise accounting
Support 802.1x EAP-TTLS & EAP-PEAP in client mode
WAN Ping Enable/Disable
Bring device name into Assoc Req/Rsp frame
Features Enhanced
Bring security type into site survey function when select hyperlink of Hidden SSID’s
MAC
Add description “Super G” to Wireless Mode field of Main webpage
Change string “Interface” to “Connection Status” in Connect Status webpage
Allow user to select Hidden SSID’s MAC in Site Survey function
Change connection status webpage refresh interval from 10sec to 30sec
Change Factory Default & Reboot warning message
- Factory Default warning message: This will reset all settings back to factory
defaults. All of your settings will be erased.
- Reboot warning message: This will reboot the device and may take few seconds.
Add Factory Default warning message in Backup/Restore webpage
Change Device Name from “Access Point” to “EOC2611P”
Change country name “the Former Yugoslav Republic of Macedonia” to “The
Former Yugoslav Republic of Macedonia”
Align id number of multiple ssid to center in Main webpage
Correct country name (Bosnia and Herzegovina, Trinidad and Tobago, Vietnam)
PPPoE Throughput Improved
Support Service Name Element in Kernel Mode PPPoE
In the WAN Settings, status of interface change from "up" to "Up", "down" to
"Down"(GUI)
In the WAN Settings of Main page, change string “Interface” to "Connection
Status"(GUI)
Change the description of field from “Channel/Frequency” to “Frequency/Channel”,
and change the string from “channel” to “Channel”(GUI)
Change the string of WAN Connection Type from “DHCP client” to “DHCP
Client”(GUI)
Establish a successful connection with AP in b/g mixed mode, the connection status
will show "IEEE 802.11b/g Mixed" in client mode(GUI)
Set WAN IP, subnetmask, and gateway default value to 0.0.0.0
Change these strings of 802.1x auth from “MSCHAP” to “MS-CHAP”, “MSCHAPV2”
to “MS-CHAPV2”(GUI)
Realign Backup/Restore Settings web page(GUI)
Not allow to set “ symbol into Service Name of Port Forwarding(GUI)
Fix the issue that PPPoE connection fail when PPPoE server relay too late
Change the string of Port Forwarding from “Protocal” to “Protocol”(GUI)
Fix issue that AP crash when enable isolation, auto channel and multiple ssid
function at the same time
Fix issue that br0 doesn’t up when enable DHCP Client after setting LAN IP to some
range(ex: 192.168.”10”.1,192.168.”99”.1)
Change DHCP option 60 from “udhcp 0.9.9-pre” to “EnGenius”
Remove Status column in WDS Link Status webpage