Professional Documents
Culture Documents
PDK Intro
PDK Intro
Email: automationjunction@gmail.com
RS232 communication with selectable Rx and Tx Port A is connected to the resistor network, using SW1.If SW1 is not in ON position, the appropriate pin has neither pull-up or pull-down resistor attached. Turns ON/OFF Seven segment digits
All Switches 1,2,3,4 should be at On Position to enable Serial Programming. It is recommended to Off all switches when serial programming is not in use. Choose how pressing the button will affect the pin, High or Low state.
Setting jumper to the lower position sets the pins of the appropriate port to logical one (pull-up). If the jumper is set to the upper position, pins are set to logical zero (pull down).
Very fast and flexible USB programmer Any External Programmer LCD Connector LCD Contrast External Power Supply from 8 to 15 V DC/AC