Professional Documents
Culture Documents
Page 1 of 3
Removing and installing 1 - Glove box Without compartment for maps With compartment for maps With CD changer Removal and installation are identical for all versions Removing Note Removal and installation are described for a glove box with CD changer. Mark connectors before unplugging to ensure correct assignment and avoid confusion. Switch off all
vw-wi://rl/A.en-GB.A00.5036.29.wi::28974857.xml?xsl=3
30/03/2008
Page 2 of 3
electrical equipment. Remove ignition key. Remove dash panel end trim on right -4- Chapter. Open glove box lid. Remove CD changer -9- Rep. Gr.91. Unscrew bolt -5-. From underneath, remove bolts -6- (3x) at front edge of glove box. Support glove box. Remove bolts -7- (2x) at rear edge of glove box. Right-hand drive vehicles: Unscrew bolt -8-. All models: Unplug connector -2- between supply lead/wiring harness for glove box. Take out glove box. If necessary remove glove box wiring harness. Remove key switch for front passenger's airbag deactivation Chapter. Removing and installing cushioning mechanism for glove box lid Chapter. Removing and installing footwell light Rep. Gr.96. Removing and installing glove box light Rep. Gr.96. Installing Installation is carried out in the reverse order, note the following: Make sure connectors engage correctly (audibly). Secure glove box wiring harness in clips provided Chapter. Tighten bolts in the correct sequence Fig.. 2 - Connector between supply lead and wiring harness Routing and securing glove box wiring harness Chapter 3 - Dash panel 4 - Dash panel end trim (right) Removing and installing Chapter 5 - Bolt, 3.5 Nm Tightening sequence Fig. 6 - Bolts, 3.5 Nm Qty. 3 Tightening sequence Fig. 7 - Bolts, 3.5 Nm Qty. 2 Tightening sequence Fig. 8 - Bolt, 3.5 Nm Right-hand drive vehicles only 9 - CD changer -R41Removing and installing Rep. Gr.91
vw-wi://rl/A.en-GB.A00.5036.29.wi::28974857.xml?xsl=3
30/03/2008
Page 3 of 3
vw-wi://rl/A.en-GB.A00.5036.29.wi::28974857.xml?xsl=3
30/03/2008