You are on page 1of 2

Key Advantages

NO DIRECT CONTACT
between heating coil & water
NO REQUIREMENT FOR
internal sensors to detect
any leakage
NO MIXING
of stored water with refrigerant
NO CONTAMINATION
of stored water by refrigerant in
the event of leakage
MINIMAL SCALING
due to sacrificial anode
NO RISK OF DAMAGE
to your air-conditioning
system
RENEWABLE SOLUTION
Exclusively Distributed By:
Address
242-246 Del Monte Ave.,
Brgy. St. Peter, Quezon City,
Philippines 1114
Contact
Tel. No.: (632) 411-3121
Fax No.: (632) 416-8192
towards GREEN building
Ambient heat absorbed
from surroundings
Cool Air to Room
Heat Absorbed
and transferred to
condensing unit
Waste heat from
compressor is transferred to
tank to heat up stored water
Hot water is
ready to be used
Tested and approved by Singapores TUV SUD PSB to SS 146
Part 2: 8 Safety of household and silimar electrical appliances
Part 2: Particular requirements for storage water heaters.
Our Ecogen is a renewable energy system whereby, compressor exhausted heat
is recycled to provide cost free hot water. Saving are significant as energy use for
hot water is a large % of our living cost.
Start up cost may be higher that the typical electric storage / electric water heaters
units. Yet, conservative calculations show that the Return on investment (ROI)
ranges from less than one year to two years based on conservative estimates.
How the Heat Recovery Works?
Energy Efficiency in action
ZERO OPERATING
COSTS
NO ELECTRICAL
COST INCURRED
SAFE AND
QUIET
WEATHER
RESISTANT
MAINTENANCE
FREE
ENVIRONMENTAL
FRIENDLY
Certificate
Made in
Singapore
ZERO OPERATING
COSTS
NO ELECTRICAL
COST INCURRED
SAFE AND
QUIET
WEATHER
RESISTANT
MAINTENANCE
FREE
ENVIRONMENTAL
FRIENDLY
Red Inn Court Hotel, Penang
Installed in 2011
2 units of 120 liters Heat Recovery Water Heater
Anantara Resort, Maldives
Installed in 2006
6 units of 60 liters Heat Recovery Water Heater
160 units x 90 liters Heat Recovery Water Heater
275 units x 150 liters Heat Recovery Water Heater
9 units x 340 liters Heat Recovery Water Heater
The Four Season Hotel, Langkawi
Installed in 2009
60 units of 340 liters Heat Recovery Water Heater
Velaa Private Island, Maldives
Installed in 2012
41 units of 340 liters Heat Recovery Water Heater
7 units of 340 liters Heat Recovery Water Heater
AL60 AL90
Tank Capacity
Diameter
Height
(Tank Section Only)
(Overall (Standard Unit)
Weight
(Empty Tank)
(Full Tank)
Dimension WXDXH
Max Operating Pressure
(Water)
(Refrigerant)
Pressure
Temperature
Capacity
Power Supply
SPECIFICATION UOM AL60 AL90
liters
mm
mm
mm
kg
kg
-
kPa
psi
kPa
deg C
kW
V/ph/Hz
60
455
610
700
36
95
510x510x750
1000
400
1000
99
1.5 Standard,2.4 Optional
220 - 240 / 1 / 50
90
455
860
950
41
129
510x510x1000
1000
400
1000
99

You might also like