Professional Documents
Culture Documents
DenMasBroto : Technology Make It Possible : VSWR Measurement using Anritsu Site Master
To measure the VSWR there are several ways you can use, one of them by using the VSWR
Anritsu Site Master S332B.
With this tools we are very watered down to take measurements with accurate results and the
results can be printed or in the save in a files.
1/6
21/7/2014
DenMasBroto : Technology Make It Possible : VSWR Measurement using Anritsu Site Master
1. Press the START CAL the message "Connect Open to the RF out port"
2. Pairs of precision "OPEN" and then press ENTER, the message "Measuring
OPEN" after the process is complete the message "Connect SHORT to RF out port"
3. Remove the precision OPEN, SHORT precision pairs and then press the ENTER
key and the message will appear "Measuring SHORT" after that message appears
again 'Connect termination to the RF out "
4. Remove the plug precision and precision termination SHORT press ENTER and the
message "Measuring termination"
5. Check at the top left corner posts CAL ON (measuring instruments are properly
calibrated).
http://denmasbroto.com/cetak-12-vswr-measurement-using-anritsu-site-master.html
2/6
21/7/2014
DenMasBroto : Technology Make It Possible : VSWR Measurement using Anritsu Site Master
http://denmasbroto.com/cetak-12-vswr-measurement-using-anritsu-site-master.html
3/6
21/7/2014
DenMasBroto : Technology Make It Possible : VSWR Measurement using Anritsu Site Master
MARKER SETTING
4/6
21/7/2014
DenMasBroto : Technology Make It Possible : VSWR Measurement using Anritsu Site Master
5/6
21/7/2014
DenMasBroto : Technology Make It Possible : VSWR Measurement using Anritsu Site Master
THINGS TO NOTE:
http://denmasbroto.com/cetak-12-vswr-measurement-using-anritsu-site-master.html
6/6