Professional Documents
Culture Documents
NOTE
* Take care not to allow the system to tip over when folding it up.
* When setting up or storing the system, take care not to pinch the fingers that grasp the stand.
3. Folding tom 1.
Loosen the bolt on the tom at the
location shown in the illustration,
and fold the tom so it is in a
vertical position.
Tighten the bolt.
NOTE
Align
MEMO
If the hi hat support
and sound module
arm mounts are
close together on
the pipe, you can
achieve the most
compact, folded
position.
1. Folding tom 3.
4
4. Loosen the hand knob, and lower the pipe while aligning
Loosen the hand knob on the pipe and lower it while turning it to
align with the frame, as shown in the illustration.
NOTE
Loosen the hand knob, and swing the pipe and tom around to the
front side of the kit as shown in the illustration.
Tighten the knob firmly.
MEMO
For easy transportation, you can place the
system in a carrying case (CB-TDP; sold
separately) designed specifically for the
Roland V-Drums Portable.
Setup Guide 2
Setting Up for Use
* Take care not to allow the system to tip over when setting it up.
* When setting up or storing the system, take care not to pinch the fingers that
grasp the stand.
NOTE
4. Raise tom 2.
NOTE
* Take care that the cables
are not excessively
stretched.
85 cm
3. Extend tom 1.
Use the drum key to loosen the tom
bolt at the location shown in the
illustration, and position the tom.
When the tom is positioned correctly,
tighten the bolt securely.
4. Rotate the hi-hat arm around the outside and position it.
NOTE
hi-hat.
1. Adjust the position and angle of each pad as shown in the illustration.
NOTE
* Before every performance, check to make sure that none of the bolts or hand knobs are loose.
Otherwise, if left untightened, it can be quite dangerous, since the stand could fall over during a performance, or a pad could come off.
CY-5
Position so there is
1215 cm of space
between the snare
and tom.
Place at a slightly
lower position than
the crash symbol.
Allow for 36 cm of
space between tom
1 and tom 2.
CY-5
Pad
Pad
The hi-hat should
be placed about 20
cm higher than the
snare.
CY-5
TD-4
Pad
Beater
Cable
holder.
Install the kick pedal
securely.
HHC
Place directly
below the hi-hat.
FD-8
* To prevent damage to your floor or carpet, and to ensure a stable setup, we recommend that you use a separately sold drum mat (TDM series).