Professional Documents
Culture Documents
RAMESH
1. Write an ISO program for step turning operation of the component shown in figure using
canned cycles. The diameter of the work piece = 30mm
3. Write the CNC lathe programming for a FANUC controlled machine using canned cycles. Take
the diameter of the work piece = 30mm, depth of cut = 0.5mm, speed = 1200rpm. Assume
feed and other data suitably.
5. Write a part program for a FANUC controlled CNC Lathe for the given component using
canned cycle. Take the depth of cut 0.5mm & speed 1200rpm. Assume suitable cutting
conditions and cutting tools.
6. Write an ISO program for the component shown in figure using canned cycles. The diameter of
the work piece = 30mm. Take the depth of cut 0.5mm & speed 1200rpm. Assume suitable cutting
conditions and cutting tools.
7. Write the CNC lathe program for a FANUC controlled machine using subroutine codes. Take the
diameter of the work piece = 40mm, depth of cut = 0.5mm, speed = 1200rpm. Assume feed and other
data suitably.
O2000;
N30 G73 U12 R24
N40 G73 P50 Q120 U0.05 W0.05
N50 G01 X16 Z0
N60 G01 X16 Z-20
N70 G03 X30 Z-28 R8
N71 G01 X30 Z-45
N80 G01 X40 Z-60
N90 G01 X40 Z-68
N100 G02 X40 Z-78 R8
N110 G01 X40 Z-88
N120 G01 X50 Z2
N121 M99
8. Write the CNC lathe programming for a FANUC controlled machine using canned cycle. Take the
diameter of the work piece = 40mm, depth of cut = 0.5mm, speed = 1200rpm. Assume feed and other
data suitably.
9. Prepare part program for the CNC lathe using subroutines for the component shown below. Assume suitable
cutting conditions and cutting tools. Doc=1 MM
10. Write an ISO part programming for the FANUC controlled CNC Lathe using canned cycle.
Work piece diameter = 30mm, Work piece material = Mild Steel, Feed = 0.2mm/rev, Speed for
turning = 1200rpm, Depth of cut = 0.5mm.
11. Write the CNC lathe programming for a FANUC controlled machine. Take the diameter of the
work piece = 30mm, depth of cut = 0.5mm, speed = 1200rpm. Assume feed and other data suitably.
12. Write an ISO part programming for the FANUC controlled CNC Lathe using canned cycles.
Work piece diameter = 30mm, Work piece material = Mild Steel, Feed = 0.2mm/rev, Speed for
turning = 1200rpm, Depth of cut = 0.5mm.
R5
40
R5
R5
13. Prepare part program for the CNC lathe using subroutines for the component shown below. Assume suitable
cutting conditions and cutting tools.
30
O7000;
G01 U0 W-30
G02 U0 W-10 R5
N60 M99
30
30
30
14. Prepare part program for the CNC lathe using subroutines for the component shown below. Assume
suitable cutting conditions and cutting tools
- PARTING OPERATION