Professional Documents
Culture Documents
Practical Test 1 - S22016 PDF
Practical Test 1 - S22016 PDF
Objectives
After performing this experiment, the student will be able to:
Use correct procedure to measure voltage, current and resistance by using multimeter.
Use the Oscilloscope to set the input waveform from Function Generator and output
waveform.
Construct electronic circuit on breadboard and use of facilities on analogue trainer.
Use of passive and active components in circuit construction.
Components
1. Resistors
2. IC op amp
Equipment
1.
2.
3.
3.
Oscilloscope + Probe
Function Generator (Analogue/Digital Trainer)
Analogue multimeter
Wire jumper
Procedure 1
Measure and draw the multimeter reading of resistors by using analogue multimeter. State the
range position used for multimeter reading. Please refer to appendix A.
No
1.1 k
10 k
___________________________
Write multimeter reading
(3 marks)
Range Position:
(3 marks)
Resistor Value:
(4 marks)
_________________________________
(3 marks)
Range Position:
(3 marks)
Resistor Value:
(4 marks)
47 k
4.7 k
_______________________
Write multimeter reading
(3 marks)
Range Position:
(3 marks)
Resistor Value:
(4 marks)
______________________________
Write multimeter reading
(3 marks)
Range Position:
(3 marks)
Resistor Value:
(4 marks)
Procedure 2
1. Calibrate the oscilloscope.
2. Use function generator to produce a signal Vin. Set Vin to become a sine wave with peak
to peak voltage of 500mV p-p and frequency = 10 kHz.
3. Use oscilloscope to measure Vin. Sketch Vin in the figure below
(3 marks)
T/div X
1
div X
probe)
div )
(5 marks)
(4 marks)
Procedure 3
1. Construct the circuit as shown Figure 2 on a breadboard with VCC equal 15V (DC) and
VEE equal -15V (DC).
2. Vin must be set to 500mV p-p and frequency = 10 kHz.
T/div X
2
(3 marks)
div X
probe) (5 marks)
div )
(4 marks)
Procedure 4
1. Use the multimeter to measure VCC. Write the multimeter reading and state the range
used.
i).
ii).
(2 marks)
(2 marks)
(4 marks)
Range Position:
VCC Value:
2. Use analogue multimeter to measure VEE. Write the multimeter reading and state the
range used.
i).
ii).
(2 marks)
(2 marks)
(4 marks)
Range Position:
VEE Value:
Procedure 5
a)
Draw the components layout of the circuit as shown in 10 on the dummy breadboard (below)
correctly and neatly.
(20 marks)