Professional Documents
Culture Documents
Homework IV
Given two-view 3rd angle orthographic drawings below (Figure 1,2,3,4), draw the new front view in a section view
according to the given cutting plane (replace place the new section view with the front view) in AUTOCAD. Show
appropriate scale and dimensions. For each drawing grid size is 5mm. The radius of the arcs is 2.5mm.
Figure 1
Figure 2
Page 1/2
Istanbul Technical University
Engineering Drawing and Design - 2016-2017 Fall Semester Lecturer Ali Sinan ABUK, PhD.
Homework IV
Figure 3
Figure 4
Page 2/2