ELECTRICAL AND ELECTRONIC TECHNOLOGY CARIBBEAN SECONDARY EXAMINATION CERTIFICAE (CSEC)
YEAR OF EXAMINATION: 2022
SECTION 2: ELECTRICAL AND ELECTRONIC DRAFTING
SCHOOL NAME: BERBICE HIGH SCHOOL SCHOOL CODE: 090006 CANDIDATE’ S NAME: METISH SANICHARRA CANDIDATE’S NUMBER: 0900060816
TEACHER: SIR. D. PETER
SYMBOLS and NOTATIONS:
This part must have Symbols and Notations which are
commonly used in Electrical Drawing/Drafting. You should NOT photocopy pages from any source and attach them as your submission, but choose the appropriate ones and draw and (fully) label them. (Check Syllabus, pages 65 to 70, or Study Guide 47 to 50)
1. LINE AND BLOCK REPRESENTATIONS:
2. SCHEMATIC DIAGRAMS and ELECTRICAL INSTALLATION DRAWINGS:
3. WORKING DRAWINGS (BLUE PRINTS):
In this section, you will complete the drawing to show
the electrical installations to be done on the given FLOOR PLAN. Follow the example given on page 141 (FIGURE 7-19) Of Volume 2 OF TEXT BOOK. You will find this drawing at the end of the chapter on electrical and electronic drafting. The drawing shows a floor plan for a building with position of lights, switches etc. shown. Note that there are lines which represent conductors, and the short cross lines tell how many conductors have to be run from breaker panel, to switch, to lights etc. After you have studied this drawing, Use the floor plan below it to show YOUR installation plan for it. (Check text book, Volume 2,pages 140, 141) (TEACHER MAY CHOOSE ANY SIMPLE FLOOR PLAN FOR THIS EXERCISE.)