Professional Documents
Culture Documents
8. MTCS
a. (i) & (iii) are correct
b. (ii) & (iv) are correct
c. (ii) & (iii) are correct
d. (iii) & (iv) are correct
9. Identify the symbol shown in figure:
a. aluminium alloys
b. brass
c. babbitt
d. bronze
10. MTCS
a. push reset, switch type, momentary switch, push reset pull off
b. switch type, push reset pull off, push reset, momentary switch type
c. push reset pull off, switch type, push reset, momentary switch type
11. Identify the symbol shown in figure:
a. potentiometer
b. rheostat
c. fixed resistor
d. variable resistor
a. .00001
b. .001
c. .0001
18. Figure show the measurement reading on the micrometer is:
a. .297
b. .3004
c. .3108
Ans. d
Ans. c
29. Shows the arrow A, B. C & D are
a. edge, face, tang, tip
b. face, tang, heel, tang
c. tip, edge, heel, face
d. tip, edge, tang, face
ans. a
32.Figure indicates:
a. air frame bolt
b. internal wrenching bolt
c. Al alloy close tolerance bolt
d. standard head bolt
a. 0.4695
b. 0.4699
c. 0.4569
d. 0.4592
a. normal ON
b. Momentary ON
c. Pressure switch
d. Single through switch
a. turn buckle
b. ball end terminal
c. push pull rod
d. rod end terminal
a. (iii)
b. (ii)
c. (i)
d. (iv)
a. special bolt
b. AN standard steel bolt
c. low strength material bolt
d corrosion resistant steel bolt
.
58. Identify the figure:
a. CRS bolt
b. 2024 bolt
c. AN standard bolt
d. None of the above