Professional Documents
Culture Documents
High Voltage DC Transmission PDF
High Voltage DC Transmission PDF
UNIT-1
2- MARKS
16- MARKS
1. For a fixed power transmission explain how the economic choice of voltage level selected in dc
transmission system
2. Explain the technological development in control and protection , for better performance and
reliability of dc transmission system
3. What are the different applications of dc transmission system? Explain them in detail?
4. With neat sketches explain the different kinds of dc link available?
5. Explain the comparison of AC and DC transmission in detail
6. Explain the application of dc transmission
7. Explain in detail about the planning of hvdc transmission?
8. Explain the technological development of modern trends in dc transmission
9. Explain the major components of a hvdc transmission in converter station unit?
10. State the advantages and disadvantages of dc transmission system with following economics,
reliability, performance..
UNIT-2
2- MARKS
16-MARKS
1. For a 3 phase 6 pulse gratez's circuit draw the timing diagram considering overlap angle is less
than 60 degree and without overlap for the following
a) Voltage across load
b) Voltage across any two pair of conduction valves
2. Explain the individual characteristics of a rectifier and an inverter with sketches
3. Draw the schematic circuit diagram of a 6 pulse gratez's circuit and explain its principle of
operation
4. Discuss in detail the effect of source inductance on hvdc system
5. Show the rating of the valve used in gratez circuit is 2.094Pd where Pd is dc power transmitted
6. Explain the effect of overlap angle on the performance of converter circuit
7. Explain the choice of converter configuration for any pulse number
8. Explain the analysis of 12 pulse converter with bridge rectifier
9. Explain the technique involved in harmonic elimination of bridge rectifier
10. Explain the analysis of two and three valve conduction mode
11. With detailed analysis of converter with steady state analysis
UNIT- 3
2- MARKS
16-MARKS
UNIT-IV
2- Marks
1. Define Harmonic.
2. How harmonics are generated?
3. Write the characteristics of Harmonics?
4. Write the fundamental components of harmonics with a order of 'h'?
5. Define AC filter?
6. Define DC Filter?
7. What are the components present in AC & DC filter?
8. What are the interference produced in the communication lines.
9. Define total harmonics distortion?
10. How can we avoid the interference occur in communication line?
11. Define Telephone influence factor.
12. What are the types of AC filters & Dc?
13. Define single tuned filter?
14. How will protect the filter?
16-Marks
UNIT-V
2-Marks
1. Define Dc Cables?
2. State the basic physical phenomenon arising in DC insulation?
3. What is meant by dielectric constant in DC cable?
4. Define dielectric stress?
5. Compare the economics of Dc cables with AC cables.
6. Define system simulation.
7. What is meant by HVDC system simulation?
8. Draw the block diagram of system simulation.
9. Distinguish AC cable vs DC cable transmission?
10. State the number of tools used for simulation of dynamic system.
11. What are the requirements for good simulation tool?
12. What are the two approaches are available in transient analysis of simulation?
16-Marks
If you like the website please use the g+ button and facebook
like button.