Professional Documents
Culture Documents
Non Preload BSEN15048 CE1 PDF
Non Preload BSEN15048 CE1 PDF
Cert No:
0038/CPD/LRQ4006773/B
BAPP
Group of Companies
CE Markings Construction Products Regulation 305/211/EEC
Each label must provide the following information. In addition to any specific information relating to dangerous substances,
the product will also be accompanied, when and where required and in the
1. Identification number of the FPC Certification body. appropriate form, by documentation listing any other legislation on dangerous
2. Name or identifying mark and registered address of the producer. substances for which compliance is claimed, together with any information
3. Last two digits of the year in which the marking was affixed. required by that legislation, for example a COSHH sheet.
4. FPC Certificate number.
5. No. of European Standard. NOTE: European legislation without national derogations need not be mentioned.
6. Description of product.
BAPP CE ID number is unique for every batch and is recorded by the factory.
Information on regulated characteristics which may be in the form of the standard
Colour Coding CE Label
product designation or a declaration of actual values for the essential characteristics
BZP Finish = Blue
(see Table ZA) if the values exceed the minimum threshold values required for
HDG Finish = Orange
compliance with the standard.
0038 0038
BS EN 15048-1 BS EN 15048-1
Non-preloaded structural bolting assembly Non-preloaded structural bolting assembly
Tolerances EN/ISO 4017/4032/7091 Tolerances EN/ISO 4017/4032/7091
Setscrew EN ISO 4017 M16 x 50 - 8.8 - HDG Setscrew EN ISO 4017 M16 x 50 - 8.8 - BZP CR3
Nut EN ISO 4032 M16 - 10 - HDG Nut EN ISO 4032 M16 - 8 - BZP CR3
Washer EN ISO 7091 M16 - - HDG Washer EN ISO 7091 M16 - - BZP CR3
Dangerous substance X: Less than 0,2 ppm Dangerous substance X: Less than 0,2 ppm
This standard refers to assemblies that do not require a specific tightening load and HEAD MARKINGS
replaces previous standards Din 931, 933, BS EN 4014, BS EN 4017, Din 934 & Din 125 BS EN 15048 GRADE 8.8 & 10.9
etc. This standard must be adhered to on all manufactured product after October 2009.
Any products produced previously to Din 931, 933, BS EN 4014, BS EN 4017, Din 934
& Din 125 etc. can still be sold as non pre-loadable bolts. BDL BGL BDL BGL
Set Screws BS EN ISO 4017 Grade 8.8 & 10.9 Set Screws BS EN ISO 4017 Grade 8.8 & 10.9 Note - The SB means that the product
Fullnuts BS EN ISO 4032 Grade 8 & 10 Fullnuts BS EN ISO 4032 Grade 10 & 12 was manufactured to BS EN 15048.
Washers EN ISO 7089 - 2000 Washers EN ISO 7089 - 2000