Professional Documents
Culture Documents
com
Ricoh MP2800/3300/4000/5000
Ricoh MPC2851/3351/4000/4001
Ricoh MP 5000/5001/6000/7000/8000
Ricoh MP 6001/7001/8001/9001
Ricoh MP C6000/6501/7500/7501
Replacing Toner B/W
1. Open the front cover of 2. Take the new toner bottle from
the machine. the box.
Loading the Tandem Paper Tray
Carefully pull out paper tray
until it stops to open tray.
When closing paper tray,
do not slam the drawer,
Note:
When paper loaded in the right side of Tray 1 runs out, paper on the left is automatically shifted to the right. While the paper is moving, a
message instructing you to wait appears. Do not pull out the tray at this time. TO AVOID OR MINAMIZE PAPER JAMS WHEN LOADING
TRAY1,ONLY LOAD PAPER ON THE LEFT SIDE OF PAPER TRAY.
Loading & Using the By-pass Tray
Place originals in feeder or on glass
Important
Do not use chemical cleaners or organic solvents, such as thinner or benzene. If such substances get inside the machine or
melt plastic parts, a failure will occur.
Do not clean parts other than those explicitly specified in this manual. Other parts should only be cleaned by your service
representative.
Using the Document Feeder
Our products are engineered to meet the highest standards of quality and
functionality. When purchasing expendable supplies, we recommend using only
those provided by an authorized dealer.
The toner bottles allow you to print about 43,000 pages. These numbers were
obtained from printing A4 5% charts, but the actual number of pages will vary
depending on paper type, size, contents, and print settings.
If the toner bottle does not click into position, pull it slightly back toward you,
rotate it 10-20 to the right, and then re-insert it.
Do not insert and remove the toner bottle more than necessary, as toner spills
may result.
Changing Toner Color Device
Copier panel will indicate when toner is low and which color needs to be
Replaced. Instructions are located on inside of front door, on the toner box
And on copier panel. Follow directions carefully and only add toner when indicated
on copier panel.
Replacing Toner Cartridges
Note: Copier Panel will indicate when toner requires replacement and which color
needs to be replaced.
Open the front cover of the machine.
Pull out the toner cartridge slowly.
Replacing Toner
Hold the toner cartridge and shake it five or six times.