Professional Documents
Culture Documents
1
2
Ethernet module should be configured using ConfigView Suite or from the meters Setup Mode (push
buttons). With the help of Push Buttons, IP Address, Subnet Mask and Default Gateway can be configured.
3
How to verify that the Ethernet Module is connected to the meter?
Answer: If the Ethernet Module (properly attached to the Ethernet Module socket of the meter) is connected
to the TCP/IP network through the LAN cable (as shown in below figure), then the two LEDs (green and
orange) present at the rear of the Ethernet module will indicate the following:
The green coloured LED will continuously glow indicating that it is connected to the TCP/IP network
The orange coloured LED will blink indicating the data flow.
4
5