Professional Documents
Culture Documents
232 Recovery Guide Boot
232 Recovery Guide Boot
1. Make sure that the receiver is disconnected from the power supply (via the switch on the rear panel)
and connected to a computer via an RS232 port.
2. Change the name of the firmware to rom.bin and place the file in the folder UARTLOADER.
3. Opening the file with notepad ConsoleDown.bat you will see the default settings -
”ConsoleDown_v1.3.3.11.exe-f. \ Rom.bin-c 3-i 1512-b 115200 \ n pause".
4. You need to change the "-c 3" which is the number of COM ports in your system. Set the desired
number of the COM port. The default is No. 3, change to No.1, 2…etc. this is your COM Port.
5. After confirming the settings, save the file. Then run the modified file ConsoleDown_v1.3.3.11.exe
10. If a successful connection will transfer the data and write flash memory in the receiver. With a
successful recording, the program will display the following:
11. Restart the receiver after the successful completion of the procedure of firmware.
12. When an error occurs, press ctrl + c to stop the program and restart the procedure.