Professional Documents
Culture Documents
SERVICE BULLETIN
GROUP: Fuel System
DATE: May 2018
This document contains trade secrets and know-hows of Mitsubishi Heavy Industries Engine & Turbocharger, Ltd. (Hereinafter referred as
MHIET.) The whole intellectual property right including the trade secret and copyright belongs to MHIET. Any duplication, use, or disclosure or
provision of this document to a third party for the purpose other than the after servicing of MHIET engine without prior consent of MHIET is
strictly prohibited.
1. Purpose
The injection pump bracket for S12A2 engine is changed, and also its centering shim is newly specified to ease the
pump centering job.
2. New and Old Parts
Interchange-
NEW OLD
ability
Ref.
Part name Remarks
No.
Part No. Qt. Part No. Qt.
APPLICABLE No.:
MODIFIED No.:
DATE OF SERVICE PARTS AVAILABLE:
RELATED SERVICE BULLETIN:
INTERCHANGEABILITY:
R=(NEW) (OLD) S=(NEW) (OLD) N=(NEW) (OLD) EO - No.
1=Out of Supply. 2=Yes as an assembly. 3=Yes as a single part. 3260-D035
3. Description
● Ref. No. 2 shim of 0.4 mm on Ref. No. 1 RH bracket, and Ref. No. 4 shim of 0.2mm on Ref. No. 3 LH
bracket are the standard combinations.
2・4・11・12・13
2・4・11・12・13
(New) LH
3・8・9・10
1・5・6・7
RH
(11)
(11)
(Old)
LH
1 RH
M18-118-E (3/3)
Note: 1. The illustration shows the new RH bracket (32661-31140) and new shim (32662-07980) as an example.
2. The old bracket does not have the ID stamp for combination of shim.
The part No. (32661-31100 or 32661-31200) of old bracket is shown with raised characters.
3. The additional machining margin shows the allowable machining depth to the parts for old bracket
to install on the crankcase.
(New) (Old)
One body
One place
supporting 4 places supporting type
2-φ11
2-φ14
236 φ 28(OD)
(Clearance hole for
positioning pin) No ID character for thickness
ID character for thickness
(See section 4-1 Table.)