Professional Documents
Culture Documents
CONFIDENTIAL
The information contained within is © Copyright 1998 Paul Pantone. All Rights
Reserved - GEET International Institute. No part of this information may be
duplicated, copied, re-sold or shared in any way. Purchase of these plans
constitutes a single user license for personal research and development ONLY.
Drawings © Copyright 2013 Adrian Asfar, GEET Australia. For more Information
contact geet.australia@yahoo.com
1” x ¾”
Bushing
Connect
1”x1”x1”
Exhaust
T-Piece
1” x 6” 1” x ¾”
Bushing
Pipe
Size as
required
Connect
1”x1”x1”
Muffler
T-Piece
1” x ¾”
Bushing
Connect to ½” x ½”
Engine via
AMV
Elbow
3/8” to ½” ½” x 12”
copper pipe Pipe
Brass
compression Brass
fitting compression
fitting
½“ x ½“ x ½“
3/8” to
T-Piece ½” copper
pipe
Connect To
½“ Plug Carburettor
or bubbler
7/16” x 4(1/8)”
Cupped on North (Up)
Bullet Head South (Down)
N
S
Use a magnetic compass to identify the natural field
of your cold pressed rod before machining. The south S
attracting end is machined into the bullet head.
The north attracting end is cupped.