Professional Documents
Culture Documents
SahagunJasier Activity02
SahagunJasier Activity02
Microelectronics Laboratory
BS Computer Engineering January 26, 2018
1. Load Electric.
3. Create new facet inverter_sch with schematic as the facet view. Make sure that
the library indicated is Exercise.
4. Draw the schematic shown in Figure 2-a. Make sure that the current technology
is schematic, analog.
a. Add the PMOS and NMOS transisitors.
Note: Lp, Ln = 0.35μm; Wp = 3.2μm; Wn = 0.8μm
b. Add the export pins. Label each pin properly.
c. Add the connecting wires.
5. Save the inverter_sch schematic.
7. Create new facet inverter_sch_tst with schematic as the facet view. Make sure
that the library indicated is Exercise.
8. Create the inverter instance by clicking on Edit → New Facet Instance. Choose
library Exercise. Select inverter_sch{ic} from this library. Press OK. Click on the
design window.
9. Export all the pins by clicking on Export → Re-Export Everything. Add other
necessary components for simulation. Please refer to Figure 2-b.
Figure 2-b. Schematic diagram for the transient analysis of a CMOS inverter.
10. For the analysis, choose Transient Analysis from the Spice list instead of a DC
Analysis. Specify the required SPICE card by following the instructions given in
the Schematic section of the Training Manual.
Note: SPICE card for transient analysis→ 5p 500n 0 5p
13. Complete the table below by varying the width of the PMOS transistor. Round off
your answers to two decimal places.
Note: To view and edit the inverter schematic while in the inverter_sch_tst
schematic, select the inverter icon instance in the design window and press Ctrl-
D. To go back to the inverter_sch_tst schematic window, simply press Ctrl-U.
14. Repeat the above procedures for loadcap = 500fF. Complete the table below.
Round off your answers to two decimal places.