A OPEN/CLOSE CONTAINER YES NO N/A 1 Are manifest against container’s contents correct? 2 Is a copy of test certificates available and valid? 3 Is SWL labeled? 4 Loaded items are within the weight limit against manifest certificates. 5 Has the container been check for physical damage/corrosion (including floor, forklift pockets, front/back/right/left sides, ceiling/roof, doors and bottom support under carriage the container) . 6 Has the container been check for loose object on top/inside/outside/forklift channel? 7 Are door hinges, handles and locking device in good condition. 8 Are doors locked and secured correctly. B SLINGS/WIRE ROPE YES NO N/A 1 Is inspection date valid throughout the project duration? 2 Is the correct colour coding applied? 3 Is there any physical damage (kinks/bird coging/broken wire/corrosion)? 4 Is sling/wire rope capacity more than the container load? 5 TEST CERT? C SHACKLES YES NO N/A 1 Is the correct SWL and ID number match with the test certs? 2 Is there any physical damage? 3 Is the correct colour coding applied? 4 Is the size of safety pins and nuts used match with the shackle size? 5 Is the right size of cotter pin used? 6 Is cotter pin installed fully bent? 7 Are the test certificates available and valid? D PAD EYE YES NO N/A 1 Is the correct SWL and ID number match with the test certs? 2 Is there any physical damage? 3 Is the correct colour coding applied? 4 Are the test certificates available and valid? E CHEMICAL YES NO N/A 1 Are all the chemicals stored and secured properly? 2 Are the updated chemical Safety Data Sheet(SDS) attached? 3 Are the chemicals labeled properly? F LOAD YES NO N/A 1 Are the loads in open top container secured properly? 2 Are palletized materials safely and correctly stacked? 3 Are safety net secured (if applicable) 4 Are all the load arranged properly for easy handling? G PRESSURE TEST EQUIPMENT YES NO N/A 1 Is the calibration cert valid and available? 2 Visually inspected to ensure no leaking? 3 Is the fitting rating as per testing requirement? H HAND TOOL YES NO N/A 1 Ensure there are no homemade tools in toolkit 2 Are the handles in good condition? 3 Are the handles firmly attached to the heads? 4 Are the heads in good condition?( no mushrooming, chisels sharp) 5 Are the tools packed and stored properly? HSE LOADING INSPECTION CHECKLIST
FUNCTION 3RD PARTY REPRESENTATIVE CLIENT REPRESENTATIVE