Professional Documents
Culture Documents
FAULT MESSAGES
TRUCKNOLOGY GENERATION
This SD supersedes
SD 812-08.2001
Brake lights without function - - yes Brake light signal failure on CAN
Flasher test - - no
Light test - - no
SET xxkm/h - - no
MEMO xxkm/h - - no
LIMIT - - no
Info ! Fault or
- - yes
grease fault in central lube
EDC failure - - yes EDC not on CAN
Boost pressure cannot be measured
Boost pressure sensor defective - - yes
correctly
Engine brake (in vehicles without re-
No text - - no
tarder)
FFR failure - - yes FFR not on CAN
LGS failure - - yes LGS not on CAN
SD 812a en-online 05.2007
Page 13 of 276
Check Buz-
Display Text in display LED Remarks
lamp panel zer-
KSM failure - - yes KSM not on CAN
Engine brake (in vehicles with retar-
No text - - no
der)
Primary retarder (water pump) not
RET P failure - - yes
on CAN
RET S failure - - yes Secondary retarder not on CAN
Oil temperature at retarder outlet too
Retarder temp. too high - - yes
high (advance warning)
Retarder temp. too high - - yes Retarder temp. much too high
No text - - no
T-CAN BusOff,
CAN Verbund Ausfall - - yes
Reaction saved in instruments
Low beam lh failure or
- - yes Low beam lh on tractor
low beam rh failure
Automatic beam regulator
Headlight height lh failure autom. - - yes
implausible on lh side
Automatic beam regulator
Headlight height rh failure autom. - - yes
implausible on rh side
Steering oil level fault - - yes Oil level too low
No text - - no
No text - - no Function feedback from rear foglamp
SD 812a en-online 05.2007
Page 15 of 276
Check Buz-
Display Text in display LED Remarks
lamp panel zer-
No text - - no
No text - - no
Display message for moving-off aid
No text - - no ECAS Nordland or
ECAS EFR Nordland
00703 VSM Output stage 'Request for neutral position in the transfer case'
00704 KSM Switch 2 terminal 30 output, adjustable parameters
00704 VSM Output stage 'Request for on-road range in the transfer case'
00705 KSM Switch 3 terminal 30 output, adjustable parameters
00705 VSM Output stage 'Request for rear axle transverse lock'
00706 KSM Switch 4 terminal 30 output, adjustable parameters
00706 VSM Output stage 'Request for front axle transverse lock'
00707 KSM Switch 5 terminal 30 output, adjustable parameters
00707 VSM Output stage 'Request for transfer case interaxle lock'
00708 KSM Earth switch 2 output, adjustable parameters
00708 VSM Output stage 'Request for rear axle interaxle lock'
00709 KSM Earth switch 3 output, adjustable parameters
00711 EDC6 Duration of main injection
00711 EDC7 Duration of main injection
00723 AB Auxiliary engine speed sensor
00723 ACC Auxiliary engine speed sensor
00723 AST Auxiliary engine speed sensor
00723 ASTMID Auxiliary engine speed sensor
00723 BHTC Auxiliary engine speed sensor
00723 CNG_ME7 Auxiliary engine speed sensor
00723 CRT Auxiliary engine speed sensor
00723 DIW5 Auxiliary engine speed sensor
00723 EBS Auxiliary engine speed sensor
00723 EBS_5 Auxiliary engine speed sensor
00723 EBS_K1 Auxiliary engine speed sensor
00723 ECAM Auxiliary engine speed sensor
00723 ECAS_4X2 Auxiliary engine speed sensor
00723 ECAS2_GBV Auxiliary engine speed sensor
00723 ECAS2_GBW Auxiliary engine speed sensor
00723 ECO2 Auxiliary engine speed sensor
00723 EDC Auxiliary engine speed sensor
00723 EDC_7 Auxiliary engine speed sensor
00723 EDC_7_M Auxiliary engine speed sensor
00723 EDC_7_MASTER Auxiliary engine speed sensor
00723 EDC_7_S Auxiliary engine speed sensor
00723 EDC_7_SLAVE Auxiliary engine speed sensor
00723 EDC6 Auxiliary engine speed sensor
00723 EDC64 Auxiliary engine speed sensor
00723 EDC7 Auxiliary engine speed sensor
00723 EDC7_6 Auxiliary engine speed sensor
00723 EDC7C32 Auxiliary engine speed sensor
00723 EDC7C32_6 Auxiliary engine speed sensor
SD 812a en-online 05.2007 Page 100 of 276
SPN Control unit/System Fault message
00723 EDC7C32_M Auxiliary engine speed sensor
00723 EDC7C32_S Auxiliary engine speed sensor
00723 EDC7C32M_10 Auxiliary engine speed sensor
00723 EDC7C32M_12 Auxiliary engine speed sensor
00723 EDC7C32S_10 Auxiliary engine speed sensor
00723 EDC7C32S_12 Auxiliary engine speed sensor
00723 EDC7M_10 Auxiliary engine speed sensor
00723 EDC7M_12 Auxiliary engine speed sensor
00723 EDC7S_10 Auxiliary engine speed sensor
00723 EDC7S_12 Auxiliary engine speed sensor
00723 EHLA Auxiliary engine speed sensor
00723 EMOS Auxiliary engine speed sensor
00723 FFR Auxiliary engine speed sensor
00723 GKR Auxiliary engine speed sensor
00723 HDS Auxiliary engine speed sensor
00723 HEITZ Auxiliary engine speed sensor
00723 HVA Auxiliary engine speed sensor
00723 HYD Auxiliary engine speed sensor
00723 INST Auxiliary engine speed sensor
00723 INT Auxiliary engine speed sensor
00723 KR49X Auxiliary engine speed sensor
00723 KSM Auxiliary engine speed sensor
00723 LGS Auxiliary engine speed sensor
00723 MTS Auxiliary engine speed sensor
00723 OBDU Auxiliary engine speed sensor
00723 OUZBRO Auxiliary engine speed sensor
00723 OUZBRO_R Auxiliary engine speed sensor
00723 PTM Auxiliary engine speed sensor
00723 RAS Auxiliary engine speed sensor
00723 RET Auxiliary engine speed sensor
00723 SFFR Auxiliary engine speed sensor
00723 SKG Auxiliary engine speed sensor
00723 STON Auxiliary engine speed sensor
00723 T509C Auxiliary engine speed sensor
00723 TBM Auxiliary engine speed sensor
00723 Test1Module Auxiliary engine speed sensor
00723 Test2Module Auxiliary engine speed sensor
00723 TPM Auxiliary engine speed sensor
00723 TRON Auxiliary engine speed sensor
00723 TRW Auxiliary engine speed sensor
00723 TUER_DR Auxiliary engine speed sensor
00723 TUER_PA Auxiliary engine speed sensor
00723 UHV Auxiliary engine speed sensor
00723 VRET Auxiliary engine speed sensor
00723 VSM Auxiliary engine speed sensor
00723 WSK Auxiliary engine speed sensor
00723 ZBR2 Auxiliary engine speed sensor
00723 ZBRO Auxiliary engine speed sensor
00723 ZBRO_R Auxiliary engine speed sensor
00723 ZFR Auxiliary engine speed sensor
00723 ZH_AT3500_1580 Auxiliary engine speed sensor
00723 ZH_AT3500_ST Auxiliary engine speed sensor
00723 ZH_D5W_SC Auxiliary engine speed sensor
00723 ZHZG_9a Auxiliary engine speed sensor
00723 ZHZG_9c Auxiliary engine speed sensor
00731 CNG_ME7 Knock sensor 1
00734 AB Solenoid valve circuit 1
00734 ACC Solenoid valve circuit 1
00734 AST Solenoid valve circuit 1
00734 ASTMID Solenoid valve circuit 1
SD 812a en-online 05.2007 Page 101 of 276
SPN Control unit/System Fault message
00734 BHTC Solenoid valve circuit 1
00734 CNG_ME7 Solenoid valve circuit 1
00734 CRT Solenoid valve circuit 1
00734 DIW5 Solenoid valve circuit 1
00734 EBS Solenoid valve circuit 1
00734 EBS_5 Solenoid valve circuit 1
00734 EBS_K1 Solenoid valve circuit 1
00734 ECAM Solenoid valve circuit 1
00734 ECAS_4X2 Solenoid valve circuit 1
00734 ECAS2_GBV Solenoid valve circuit 1
00734 ECAS2_GBW Solenoid valve circuit 1
00734 ECO2 Solenoid valve circuit 1
00734 EDC Solenoid valve circuit 1
00734 EDC_7 Solenoid valve circuit 1
00734 EDC_7_M Solenoid valve circuit 1
00734 EDC_7_MASTER Solenoid valve circuit 1
00734 EDC_7_S Solenoid valve circuit 1
00734 EDC_7_SLAVE Solenoid valve circuit 1
00734 EDC6 Solenoid valve circuit 1
00734 EDC64 Solenoid valve circuit 1
00734 EDC7 Solenoid valve circuit 1
00734 EDC7_6 Solenoid valve circuit 1
00734 EDC7C32 Solenoid valve circuit 1
00734 EDC7C32_6 Solenoid valve circuit 1
00734 EDC7C32_M Solenoid valve circuit 1
00734 EDC7C32_S Solenoid valve circuit 1
00734 EDC7C32M_10 Solenoid valve circuit 1
00734 EDC7C32M_12 Solenoid valve circuit 1
00734 EDC7C32S_10 Solenoid valve circuit 1
00734 EDC7C32S_12 Solenoid valve circuit 1
00734 EDC7M_10 Solenoid valve circuit 1
00734 EDC7M_12 Solenoid valve circuit 1
00734 EDC7S_10 Solenoid valve circuit 1
00734 EDC7S_12 Solenoid valve circuit 1
00734 EHLA Solenoid valve circuit 1
00734 EMOS Solenoid valve circuit 1
00734 FFR Solenoid valve circuit 1
00734 GKR Solenoid valve circuit 1
00734 HDS Solenoid valve circuit 1
00734 HEITZ Solenoid valve circuit 1
00734 HVA Solenoid valve circuit 1
00734 HYD Solenoid valve circuit 1
00734 INST Solenoid valve circuit 1
00734 INT Solenoid valve circuit 1
00734 KR49X Solenoid valve circuit 1
00734 KSM Solenoid valve circuit 1
00734 LGS Solenoid valve circuit 1
00734 MTS Solenoid valve circuit 1
00734 OBDU Solenoid valve circuit 1
00734 OUZBRO Solenoid valve circuit 1
00734 OUZBRO_R Solenoid valve circuit 1
00734 PTM Solenoid valve circuit 1
00734 RAS Solenoid valve circuit 1
00734 RET Solenoid valve circuit 1
00734 SFFR Solenoid valve circuit 1
00734 SKG Solenoid valve circuit 1
00734 STON Solenoid valve circuit 1
00734 T509C Solenoid valve circuit 1
00734 TBM Solenoid valve circuit 1
00734 Test1Module Solenoid valve circuit 1
SD 812a en-online 05.2007 Page 102 of 276
SPN Control unit/System Fault message
00734 Test2Module Solenoid valve circuit 1
00734 TPM Solenoid valve circuit 1
00734 TRON Solenoid valve circuit 1
00734 TRW Solenoid valve circuit 1
00734 TUER_DR Solenoid valve circuit 1
00734 TUER_PA Solenoid valve circuit 1
00734 UHV Solenoid valve circuit 1
00734 VRET Solenoid valve circuit 1
00734 VSM Solenoid valve circuit 1
00734 WSK Solenoid valve circuit 1
00734 ZBR2 Solenoid valve circuit 1
00734 ZBRO Solenoid valve circuit 1
00734 ZBRO_R Solenoid valve circuit 1
00734 ZFR Solenoid valve circuit 1
00734 ZH_AT3500_1580 Solenoid valve circuit 1
00734 ZH_AT3500_ST Solenoid valve circuit 1
00734 ZH_D5W_SC Solenoid valve circuit 1
00734 ZHZG_9a Solenoid valve circuit 1
00734 ZHZG_9c Solenoid valve circuit 1
00735 AB Solenoid valve circuit 2
00735 ACC Solenoid valve circuit 2
00735 AST Solenoid valve circuit 2
00735 ASTMID Solenoid valve circuit 2
00735 BHTC Solenoid valve circuit 2
00735 CNG_ME7 Solenoid valve circuit 2
00735 CRT Solenoid valve circuit 2
00735 DIW5 Solenoid valve circuit 2
00735 EBS Solenoid valve circuit 2
00735 EBS_5 Solenoid valve circuit 2
00735 EBS_K1 Solenoid valve circuit 2
00735 ECAM Solenoid valve circuit 2
00735 ECAS_4X2 Solenoid valve circuit 2
00735 ECAS2_GBV Solenoid valve circuit 2
00735 ECAS2_GBW Solenoid valve circuit 2
00735 ECO2 Solenoid valve circuit 2
00735 EDC Solenoid valve circuit 2
00735 EDC_7 Solenoid valve circuit 2
00735 EDC_7_M Solenoid valve circuit 2
00735 EDC_7_MASTER Solenoid valve circuit 2
00735 EDC_7_S Solenoid valve circuit 2
00735 EDC_7_SLAVE Solenoid valve circuit 2
00735 EDC6 Solenoid valve circuit 2
00735 EDC64 Solenoid valve circuit 2
00735 EDC7 Solenoid valve circuit 2
00735 EDC7_6 Solenoid valve circuit 2
00735 EDC7C32 Solenoid valve circuit 2
00735 EDC7C32_6 Solenoid valve circuit 2
00735 EDC7C32_M Solenoid valve circuit 2
00735 EDC7C32_S Solenoid valve circuit 2
00735 EDC7C32M_10 Solenoid valve circuit 2
00735 EDC7C32M_12 Solenoid valve circuit 2
00735 EDC7C32S_10 Solenoid valve circuit 2
00735 EDC7C32S_12 Solenoid valve circuit 2
00735 EDC7M_10 Solenoid valve circuit 2
00735 EDC7M_12 Solenoid valve circuit 2
00735 EDC7S_10 Solenoid valve circuit 2
00735 EDC7S_12 Solenoid valve circuit 2
00735 EHLA Solenoid valve circuit 2
00735 EMOS Solenoid valve circuit 2
00735 FFR Solenoid valve circuit 2
SD 812a en-online 05.2007 Page 103 of 276
SPN Control unit/System Fault message
00735 GKR Solenoid valve circuit 2
00735 HDS Solenoid valve circuit 2
00735 HEITZ Solenoid valve circuit 2
00735 HVA Solenoid valve circuit 2
00735 HYD Solenoid valve circuit 2
00735 INST Solenoid valve circuit 2
00735 INT Solenoid valve circuit 2
00735 KR49X Solenoid valve circuit 2
00735 KSM Solenoid valve circuit 2
00735 LGS Solenoid valve circuit 2
00735 MTS Solenoid valve circuit 2
00735 OBDU Solenoid valve circuit 2
00735 OUZBRO Solenoid valve circuit 2
00735 OUZBRO_R Solenoid valve circuit 2
00735 PTM Solenoid valve circuit 2
00735 RAS Solenoid valve circuit 2
00735 RET Solenoid valve circuit 2
00735 SFFR Solenoid valve circuit 2
00735 SKG Solenoid valve circuit 2
00735 STON Solenoid valve circuit 2
00735 T509C Solenoid valve circuit 2
00735 TBM Solenoid valve circuit 2
00735 Test1Module Solenoid valve circuit 2
00735 Test2Module Solenoid valve circuit 2
00735 TPM Solenoid valve circuit 2
00735 TRON Solenoid valve circuit 2
00735 TRW Solenoid valve circuit 2
00735 TUER_DR Solenoid valve circuit 2
00735 TUER_PA Solenoid valve circuit 2
00735 UHV Solenoid valve circuit 2
00735 VRET Solenoid valve circuit 2
00735 VSM Solenoid valve circuit 2
00735 WSK Solenoid valve circuit 2
00735 ZBR2 Solenoid valve circuit 2
00735 ZBRO Solenoid valve circuit 2
00735 ZBRO_R Solenoid valve circuit 2
00735 ZFR Solenoid valve circuit 2
00735 ZH_AT3500_1580 Solenoid valve circuit 2
00735 ZH_AT3500_ST Solenoid valve circuit 2
00735 ZH_D5W_SC Solenoid valve circuit 2
00735 ZHZG_9a Solenoid valve circuit 2
00735 ZHZG_9c Solenoid valve circuit 2
00736 AB Solenoid valve circuit 3
00736 ACC Solenoid valve circuit 3
00736 AST Solenoid valve circuit 3
00736 ASTMID Solenoid valve circuit 3
00736 BHTC Solenoid valve circuit 3
00736 CNG_ME7 Solenoid valve circuit 3
00736 CRT Solenoid valve circuit 3
00736 DIW5 Solenoid valve circuit 3
00736 EBS Solenoid valve circuit 3
00736 EBS_5 Solenoid valve circuit 3
00736 EBS_K1 Solenoid valve circuit 3
00736 ECAM Solenoid valve circuit 3
00736 ECAS_4X2 Solenoid valve circuit 3
00736 ECAS2_GBV Solenoid valve circuit 3
00736 ECAS2_GBW Solenoid valve circuit 3
00736 ECO2 Solenoid valve circuit 3
00736 EDC Solenoid valve circuit 3
00736 EDC_7 Solenoid valve circuit 3
SD 812a en-online 05.2007 Page 104 of 276
SPN Control unit/System Fault message
00736 EDC_7_M Solenoid valve circuit 3
00736 EDC_7_MASTER Solenoid valve circuit 3
00736 EDC_7_S Solenoid valve circuit 3
00736 EDC_7_SLAVE Solenoid valve circuit 3
00736 EDC6 Solenoid valve circuit 3
00736 EDC64 Solenoid valve circuit 3
00736 EDC7 Solenoid valve circuit 3
00736 EDC7_6 Solenoid valve circuit 3
00736 EDC7C32 Solenoid valve circuit 3
00736 EDC7C32_6 Solenoid valve circuit 3
00736 EDC7C32_M Solenoid valve circuit 3
00736 EDC7C32_S Solenoid valve circuit 3
00736 EDC7C32M_10 Solenoid valve circuit 3
00736 EDC7C32M_12 Solenoid valve circuit 3
00736 EDC7C32S_10 Solenoid valve circuit 3
00736 EDC7C32S_12 Solenoid valve circuit 3
00736 EDC7M_10 Solenoid valve circuit 3
00736 EDC7M_12 Solenoid valve circuit 3
00736 EDC7S_10 Solenoid valve circuit 3
00736 EDC7S_12 Solenoid valve circuit 3
00736 EHLA Solenoid valve circuit 3
00736 EMOS Solenoid valve circuit 3
00736 FFR Solenoid valve circuit 3
00736 GKR Solenoid valve circuit 3
00736 HDS Solenoid valve circuit 3
00736 HEITZ Solenoid valve circuit 3
00736 HVA Solenoid valve circuit 3
00736 HYD Solenoid valve circuit 3
00736 INST Solenoid valve circuit 3
00736 INT Solenoid valve circuit 3
00736 KR49X Solenoid valve circuit 3
00736 KSM Solenoid valve circuit 3
00736 LGS Solenoid valve circuit 3
00736 MTS Solenoid valve circuit 3
00736 OBDU Solenoid valve circuit 3
00736 OUZBRO Solenoid valve circuit 3
00736 OUZBRO_R Solenoid valve circuit 3
00736 PTM Solenoid valve circuit 3
00736 RAS Solenoid valve circuit 3
00736 RET Solenoid valve circuit 3
00736 SFFR Solenoid valve circuit 3
00736 SKG Solenoid valve circuit 3
00736 STON Solenoid valve circuit 3
00736 T509C Solenoid valve circuit 3
00736 TBM Solenoid valve circuit 3
00736 Test1Module Solenoid valve circuit 3
00736 Test2Module Solenoid valve circuit 3
00736 TPM Solenoid valve circuit 3
00736 TRON Solenoid valve circuit 3
00736 TRW Solenoid valve circuit 3
00736 TUER_DR Solenoid valve circuit 3
00736 TUER_PA Solenoid valve circuit 3
00736 UHV Solenoid valve circuit 3
00736 VRET Solenoid valve circuit 3
00736 VSM Solenoid valve circuit 3
00736 WSK Solenoid valve circuit 3
00736 ZBR2 Solenoid valve circuit 3
00736 ZBRO Solenoid valve circuit 3
00736 ZBRO_R Solenoid valve circuit 3
00736 ZFR Solenoid valve circuit 3
SD 812a en-online 05.2007 Page 105 of 276
SPN Control unit/System Fault message
00736 ZH_AT3500_1580 Solenoid valve circuit 3
00736 ZH_AT3500_ST Solenoid valve circuit 3
00736 ZH_D5W_SC Solenoid valve circuit 3
00736 ZHZG_9a Solenoid valve circuit 3
00736 ZHZG_9c Solenoid valve circuit 3
00737 AB Solenoid valve circuit 4
00737 ACC Solenoid valve circuit 4
00737 AST Solenoid valve circuit 4
00737 ASTMID Solenoid valve circuit 4
00737 BHTC Solenoid valve circuit 4
00737 CNG_ME7 Solenoid valve circuit 4
00737 CRT Solenoid valve circuit 4
00737 DIW5 Solenoid valve circuit 4
00737 EBS Solenoid valve circuit 4
00737 EBS_5 Solenoid valve circuit 4
00737 EBS_K1 Solenoid valve circuit 4
00737 ECAM Solenoid valve circuit 4
00737 ECAS_4X2 Solenoid valve circuit 4
00737 ECAS2_GBV Solenoid valve circuit 4
00737 ECAS2_GBW Solenoid valve circuit 4
00737 ECO2 Solenoid valve circuit 4
00737 EDC Solenoid valve circuit 4
00737 EDC_7 Solenoid valve circuit 4
00737 EDC_7_M Solenoid valve circuit 4
00737 EDC_7_MASTER Solenoid valve circuit 4
00737 EDC_7_S Solenoid valve circuit 4
00737 EDC_7_SLAVE Solenoid valve circuit 4
00737 EDC6 Solenoid valve circuit 4
00737 EDC64 Solenoid valve circuit 4
00737 EDC7 Solenoid valve circuit 4
00737 EDC7_6 Solenoid valve circuit 4
00737 EDC7C32 Solenoid valve circuit 4
00737 EDC7C32_6 Solenoid valve circuit 4
00737 EDC7C32_M Solenoid valve circuit 4
00737 EDC7C32_S Solenoid valve circuit 4
00737 EDC7C32M_10 Solenoid valve circuit 4
00737 EDC7C32M_12 Solenoid valve circuit 4
00737 EDC7C32S_10 Solenoid valve circuit 4
00737 EDC7C32S_12 Solenoid valve circuit 4
00737 EDC7M_10 Solenoid valve circuit 4
00737 EDC7M_12 Solenoid valve circuit 4
00737 EDC7S_10 Solenoid valve circuit 4
00737 EDC7S_12 Solenoid valve circuit 4
00737 EHLA Solenoid valve circuit 4
00737 EMOS Solenoid valve circuit 4
00737 FFR Solenoid valve circuit 4
00737 GKR Solenoid valve circuit 4
00737 HDS Solenoid valve circuit 4
00737 HEITZ Solenoid valve circuit 4
00737 HVA Solenoid valve circuit 4
00737 HYD Solenoid valve circuit 4
00737 INST Solenoid valve circuit 4
00737 INT Solenoid valve circuit 4
00737 KR49X Solenoid valve circuit 4
00737 KSM Solenoid valve circuit 4
00737 LGS Solenoid valve circuit 4
00737 MTS Solenoid valve circuit 4
00737 OBDU Solenoid valve circuit 4
00737 OUZBRO Solenoid valve circuit 4
00737 OUZBRO_R Solenoid valve circuit 4
SD 812a en-online 05.2007 Page 106 of 276
SPN Control unit/System Fault message
00737 PTM Solenoid valve circuit 4
00737 RAS Solenoid valve circuit 4
00737 RET Solenoid valve circuit 4
00737 SFFR Solenoid valve circuit 4
00737 SKG Solenoid valve circuit 4
00737 STON Solenoid valve circuit 4
00737 T509C Solenoid valve circuit 4
00737 TBM Solenoid valve circuit 4
00737 Test1Module Solenoid valve circuit 4
00737 Test2Module Solenoid valve circuit 4
00737 TPM Solenoid valve circuit 4
00737 TRON Solenoid valve circuit 4
00737 TRW Solenoid valve circuit 4
00737 TUER_DR Solenoid valve circuit 4
00737 TUER_PA Solenoid valve circuit 4
00737 UHV Solenoid valve circuit 4
00737 VRET Solenoid valve circuit 4
00737 VSM Solenoid valve circuit 4
00737 WSK Solenoid valve circuit 4
00737 ZBR2 Solenoid valve circuit 4
00737 ZBRO Solenoid valve circuit 4
00737 ZBRO_R Solenoid valve circuit 4
00737 ZFR Solenoid valve circuit 4
00737 ZH_AT3500_1580 Solenoid valve circuit 4
00737 ZH_AT3500_ST Solenoid valve circuit 4
00737 ZH_D5W_SC Solenoid valve circuit 4
00737 ZHZG_9a Solenoid valve circuit 4
00737 ZHZG_9c Solenoid valve circuit 4
00738 AB Solenoid valve pressure regulator
00738 ACC Solenoid valve pressure regulator
00738 AST Solenoid valve pressure regulator
00738 ASTMID Solenoid valve pressure regulator
00738 BHTC Solenoid valve pressure regulator
00738 CNG_ME7 Solenoid valve pressure regulator
00738 CRT Solenoid valve pressure regulator
00738 DIW5 Solenoid valve pressure regulator
00738 EBS Solenoid valve pressure regulator
00738 EBS_5 Solenoid valve pressure regulator
00738 EBS_K1 Solenoid valve pressure regulator
00738 ECAM Solenoid valve pressure regulator
00738 ECAS_4X2 Solenoid valve pressure regulator
00738 ECAS2_GBV Solenoid valve pressure regulator
00738 ECAS2_GBW Solenoid valve pressure regulator
00738 ECO2 Solenoid valve pressure regulator
00738 EDC Solenoid valve pressure regulator
00738 EDC_7 Solenoid valve pressure regulator
00738 EDC_7_M Solenoid valve pressure regulator
00738 EDC_7_MASTER Solenoid valve pressure regulator
00738 EDC_7_S Solenoid valve pressure regulator
00738 EDC_7_SLAVE Solenoid valve pressure regulator
00738 EDC6 Solenoid valve pressure regulator
00738 EDC64 Solenoid valve pressure regulator
00738 EDC7 Solenoid valve pressure regulator
00738 EDC7_6 Solenoid valve pressure regulator
00738 EDC7C32 Solenoid valve pressure regulator
00738 EDC7C32_6 Solenoid valve pressure regulator
00738 EDC7C32_M Solenoid valve pressure regulator
00738 EDC7C32_S Solenoid valve pressure regulator
00738 EDC7C32M_10 Solenoid valve pressure regulator
00738 EDC7C32M_12 Solenoid valve pressure regulator
SD 812a en-online 05.2007 Page 107 of 276
SPN Control unit/System Fault message
00738 EDC7C32S_10 Solenoid valve pressure regulator
00738 EDC7C32S_12 Solenoid valve pressure regulator
00738 EDC7M_10 Solenoid valve pressure regulator
00738 EDC7M_12 Solenoid valve pressure regulator
00738 EDC7S_10 Solenoid valve pressure regulator
00738 EDC7S_12 Solenoid valve pressure regulator
00738 EHLA Solenoid valve pressure regulator
00738 EMOS Solenoid valve pressure regulator
00738 FFR Solenoid valve pressure regulator
00738 GKR Solenoid valve pressure regulator
00738 HDS Solenoid valve pressure regulator
00738 HEITZ Solenoid valve pressure regulator
00738 HVA Solenoid valve pressure regulator
00738 HYD Solenoid valve pressure regulator
00738 INST Solenoid valve pressure regulator
00738 INT Solenoid valve pressure regulator
00738 KR49X Solenoid valve pressure regulator
00738 KSM Solenoid valve pressure regulator
00738 LGS Solenoid valve pressure regulator
00738 MTS Solenoid valve pressure regulator
00738 OBDU Solenoid valve pressure regulator
00738 OUZBRO Solenoid valve pressure regulator
00738 OUZBRO_R Solenoid valve pressure regulator
00738 PTM Solenoid valve pressure regulator
00738 RAS Solenoid valve pressure regulator
00738 RET Solenoid valve pressure regulator
00738 SFFR Solenoid valve pressure regulator
00738 SKG Solenoid valve pressure regulator
00738 STON Solenoid valve pressure regulator
00738 T509C Solenoid valve pressure regulator
00738 TBM Solenoid valve pressure regulator
00738 Test1Module Solenoid valve pressure regulator
00738 Test2Module Solenoid valve pressure regulator
00738 TPM Solenoid valve pressure regulator
00738 TRON Solenoid valve pressure regulator
00738 TRW Solenoid valve pressure regulator
00738 TUER_DR Solenoid valve pressure regulator
00738 TUER_PA Solenoid valve pressure regulator
00738 UHV Solenoid valve pressure regulator
00738 VRET Solenoid valve pressure regulator
00738 VSM Solenoid valve pressure regulator
00738 WSK Solenoid valve pressure regulator
00738 ZBR2 Solenoid valve pressure regulator
00738 ZBRO Solenoid valve pressure regulator
00738 ZBRO_R Solenoid valve pressure regulator
00738 ZFR Solenoid valve pressure regulator
00738 ZH_AT3500_1580 Solenoid valve pressure regulator
00738 ZH_AT3500_ST Solenoid valve pressure regulator
00738 ZH_D5W_SC Solenoid valve pressure regulator
00738 ZHZG_9a Solenoid valve pressure regulator
00738 ZHZG_9c Solenoid valve pressure regulator
00739 AB Solenoid valve regeneration
00739 ACC Solenoid valve regeneration
00739 AST Solenoid valve regeneration
00739 ASTMID Solenoid valve regeneration
00739 BHTC Solenoid valve regeneration
00739 CNG_ME7 Solenoid valve regeneration
00739 CRT Solenoid valve regeneration
00739 DIW5 Solenoid valve regeneration
00739 EBS Solenoid valve regeneration
SD 812a en-online 05.2007 Page 108 of 276
SPN Control unit/System Fault message
00739 EBS_5 Solenoid valve regeneration
00739 EBS_K1 Solenoid valve regeneration
00739 ECAM Solenoid valve regeneration
00739 ECAS_4X2 Solenoid valve regeneration
00739 ECAS2_GBV Solenoid valve regeneration
00739 ECAS2_GBW Solenoid valve regeneration
00739 ECO2 Solenoid valve regeneration
00739 EDC Solenoid valve regeneration
00739 EDC_7 Solenoid valve regeneration
00739 EDC_7_M Solenoid valve regeneration
00739 EDC_7_MASTER Solenoid valve regeneration
00739 EDC_7_S Solenoid valve regeneration
00739 EDC_7_SLAVE Solenoid valve regeneration
00739 EDC6 Solenoid valve regeneration
00739 EDC64 Solenoid valve regeneration
00739 EDC7 Solenoid valve regeneration
00739 EDC7_6 Solenoid valve regeneration
00739 EDC7C32 Solenoid valve regeneration
00739 EDC7C32_6 Solenoid valve regeneration
00739 EDC7C32_M Solenoid valve regeneration
00739 EDC7C32_S Solenoid valve regeneration
00739 EDC7C32M_10 Solenoid valve regeneration
00739 EDC7C32M_12 Solenoid valve regeneration
00739 EDC7C32S_10 Solenoid valve regeneration
00739 EDC7C32S_12 Solenoid valve regeneration
00739 EDC7M_10 Solenoid valve regeneration
00739 EDC7M_12 Solenoid valve regeneration
00739 EDC7S_10 Solenoid valve regeneration
00739 EDC7S_12 Solenoid valve regeneration
00739 EHLA Solenoid valve regeneration
00739 EMOS Solenoid valve regeneration
00739 FFR Solenoid valve regeneration
00739 GKR Solenoid valve regeneration
00739 HDS Solenoid valve regeneration
00739 HEITZ Solenoid valve regeneration
00739 HVA Solenoid valve regeneration
00739 HYD Solenoid valve regeneration
00739 INST Solenoid valve regeneration
00739 INT Solenoid valve regeneration
00739 KR49X Solenoid valve regeneration
00739 KSM Solenoid valve regeneration
00739 LGS Solenoid valve regeneration
00739 MTS Solenoid valve regeneration
00739 OBDU Solenoid valve regeneration
00739 OUZBRO Solenoid valve regeneration
00739 OUZBRO_R Solenoid valve regeneration
00739 PTM Solenoid valve regeneration
00739 RAS Solenoid valve regeneration
00739 RET Solenoid valve regeneration
00739 SFFR Solenoid valve regeneration
00739 SKG Solenoid valve regeneration
00739 STON Solenoid valve regeneration
00739 T509C Solenoid valve regeneration
00739 TBM Solenoid valve regeneration
00739 Test1Module Solenoid valve regeneration
00739 Test2Module Solenoid valve regeneration
00739 TPM Solenoid valve regeneration
00739 TRON Solenoid valve regeneration
00739 TRW Solenoid valve regeneration
00739 TUER_DR Solenoid valve regeneration
SD 812a en-online 05.2007 Page 109 of 276
SPN Control unit/System Fault message
00739 TUER_PA Solenoid valve regeneration
00739 UHV Solenoid valve regeneration
00739 VRET Solenoid valve regeneration
00739 VSM Solenoid valve regeneration
00739 WSK Solenoid valve regeneration
00739 ZBR2 Solenoid valve regeneration
00739 ZBRO Solenoid valve regeneration
00739 ZBRO_R Solenoid valve regeneration
00739 ZFR Solenoid valve regeneration
00739 ZH_AT3500_1580 Solenoid valve regeneration
00739 ZH_AT3500_ST Solenoid valve regeneration
00739 ZH_D5W_SC Solenoid valve regeneration
00739 ZHZG_9a Solenoid valve regeneration
00739 ZHZG_9c Solenoid valve regeneration
00743 RET On/off valve
00743 VRET On/off valve
00744 RET Proportional valve
00744 VRET Proportional valve
00746 EBS_5 Differential lock valve (differential lock switch)
00748 AB Retarder actuated
00748 ACC Retarder actuated
00748 AST Retarder actuated
00748 ASTMID Retarder actuated
00748 BHTC Retarder actuated
00748 CNG_ME7 Retarder actuated
00748 CRT Retarder actuated
00748 DIW5 Retarder actuated
00748 EBS Retarder actuated
00748 EBS_5 Retarder actuated
00748 EBS_K1 Retarder actuated
00748 ECAM Retarder actuated
00748 ECAS_4X2 Retarder actuated
00748 ECAS2_GBV Retarder actuated
00748 ECAS2_GBW Retarder actuated
00748 ECO2 Retarder actuated
00748 EDC Retarder actuated
00748 EDC_7 Retarder actuated
00748 EDC_7_M Retarder actuated
00748 EDC_7_MASTER Retarder actuated
00748 EDC_7_S Retarder actuated
00748 EDC_7_SLAVE Retarder actuated
00748 EDC6 Retarder actuated
00748 EDC64 Retarder actuated
00748 EDC7 Retarder actuated
00748 EDC7_6 Retarder actuated
00748 EDC7C32 Retarder actuated
00748 EDC7C32_6 Retarder actuated
00748 EDC7C32_M Retarder actuated
00748 EDC7C32_S Retarder actuated
00748 EDC7C32M_10 Retarder actuated
00748 EDC7C32M_12 Retarder actuated
00748 EDC7C32S_10 Retarder actuated
00748 EDC7C32S_12 Retarder actuated
00748 EDC7M_10 Retarder actuated
00748 EDC7M_12 Retarder actuated
00748 EDC7S_10 Retarder actuated
00748 EDC7S_12 Retarder actuated
00748 EHLA Retarder actuated
00748 EMOS Retarder actuated
00748 FFR Retarder actuated
SD 812a en-online 05.2007 Page 110 of 276
SPN Control unit/System Fault message
00748 GKR Retarder actuated
00748 HDS Retarder actuated
00748 HEITZ Retarder actuated
00748 HVA Retarder actuated
00748 HYD Retarder actuated
00748 INST Retarder actuated
00748 INT Retarder actuated
00748 KR49X Retarder actuated
00748 KSM Retarder actuated
00748 LGS Retarder actuated
00748 MTS Retarder actuated
00748 OBDU Retarder actuated
00748 OUZBRO Retarder actuated
00748 OUZBRO_R Retarder actuated
00748 PTM Retarder actuated
00748 RAS Retarder actuated
00748 RET Retarder actuated
00748 SFFR Retarder actuated
00748 SKG Retarder actuated
00748 STON Retarder actuated
00748 T509C Retarder actuated
00748 TBM Retarder actuated
00748 Test1Module Retarder actuated
00748 Test2Module Retarder actuated
00748 TPM Retarder actuated
00748 TRON Retarder actuated
00748 TRW Retarder actuated
00748 TUER_DR Retarder actuated
00748 TUER_PA Retarder actuated
00748 UHV Retarder actuated
00748 VRET Retarder actuated
00748 VSM Retarder actuated
00748 WSK Retarder actuated
00748 ZBR2 Retarder actuated
00748 ZBRO Retarder actuated
00748 ZBRO_R Retarder actuated
00748 ZFR Retarder actuated
00748 ZH_AT3500_1580 Retarder actuated
00748 ZH_AT3500_ST Retarder actuated
00748 ZH_D5W_SC Retarder actuated
00748 ZHZG_9a Retarder actuated
00748 ZHZG_9c Retarder actuated
00764 RET Pressure sensor housing pressure
00767 AB Transmission Reverse Direction Switch
00767 ACC Transmission Reverse Direction Switch
00767 AST Transmission Reverse Direction Switch
00767 ASTMID Transmission Reverse Direction Switch
00767 BHTC Transmission Reverse Direction Switch
00767 CNG_ME7 Transmission Reverse Direction Switch
00767 CRT Transmission Reverse Direction Switch
00767 DIW5 Transmission Reverse Direction Switch
00767 EBS Transmission Reverse Direction Switch
00767 EBS_5 Transmission Reverse Direction Switch
00767 EBS_K1 Transmission Reverse Direction Switch
00767 ECAM Transmission Reverse Direction Switch
00767 ECAS_4X2 Transmission Reverse Direction Switch
00767 ECAS2_GBV Transmission Reverse Direction Switch
00767 ECAS2_GBW Transmission Reverse Direction Switch
00767 ECO2 Transmission Reverse Direction Switch
00767 EDC Transmission Reverse Direction Switch
SD 812a en-online 05.2007 Page 111 of 276
SPN Control unit/System Fault message
00767 EDC_7 Transmission Reverse Direction Switch
00767 EDC_7_M Transmission Reverse Direction Switch
00767 EDC_7_MASTER Transmission Reverse Direction Switch
00767 EDC_7_S Transmission Reverse Direction Switch
00767 EDC_7_SLAVE Transmission Reverse Direction Switch
00767 EDC6 Transmission Reverse Direction Switch
00767 EDC64 Transmission Reverse Direction Switch
00767 EDC7 Transmission Reverse Direction Switch
00767 EDC7_6 Transmission Reverse Direction Switch
00767 EDC7C32 Transmission Reverse Direction Switch
00767 EDC7C32_6 Transmission Reverse Direction Switch
00767 EDC7C32_M Transmission Reverse Direction Switch
00767 EDC7C32_S Transmission Reverse Direction Switch
00767 EDC7C32M_10 Transmission Reverse Direction Switch
00767 EDC7C32M_12 Transmission Reverse Direction Switch
00767 EDC7C32S_10 Transmission Reverse Direction Switch
00767 EDC7C32S_12 Transmission Reverse Direction Switch
00767 EDC7M_10 Transmission Reverse Direction Switch
00767 EDC7M_12 Transmission Reverse Direction Switch
00767 EDC7S_10 Transmission Reverse Direction Switch
00767 EDC7S_12 Transmission Reverse Direction Switch
00767 EHLA Transmission Reverse Direction Switch
00767 EMOS Transmission Reverse Direction Switch
00767 FFR Transmission Reverse Direction Switch
00767 GKR Transmission Reverse Direction Switch
00767 HDS Transmission Reverse Direction Switch
00767 HEITZ Transmission Reverse Direction Switch
00767 HVA Transmission Reverse Direction Switch
00767 HYD Transmission Reverse Direction Switch
00767 INST Transmission Reverse Direction Switch
00767 INT Transmission Reverse Direction Switch
00767 KR49X Transmission Reverse Direction Switch
00767 KSM Transmission Reverse Direction Switch
00767 LGS Transmission Reverse Direction Switch
00767 MTS Transmission Reverse Direction Switch
00767 OBDU Transmission Reverse Direction Switch
00767 OUZBRO Transmission Reverse Direction Switch
00767 OUZBRO_R Transmission Reverse Direction Switch
00767 PTM Transmission Reverse Direction Switch
00767 RAS Transmission Reverse Direction Switch
00767 RET Transmission Reverse Direction Switch
00767 SFFR Transmission Reverse Direction Switch
00767 SKG Transmission Reverse Direction Switch
00767 STON Transmission Reverse Direction Switch
00767 T509C Transmission Reverse Direction Switch
00767 TBM Transmission Reverse Direction Switch
00767 Test1Module Transmission Reverse Direction Switch
00767 Test2Module Transmission Reverse Direction Switch
00767 TPM Transmission Reverse Direction Switch
00767 TRON Transmission Reverse Direction Switch
00767 TRW Transmission Reverse Direction Switch
00767 TUER_DR Transmission Reverse Direction Switch
00767 TUER_PA Transmission Reverse Direction Switch
00767 UHV Transmission Reverse Direction Switch
00767 VRET Transmission Reverse Direction Switch
00767 VSM Transmission Reverse Direction Switch
00767 WSK Transmission Reverse Direction Switch
00767 ZBR2 Transmission Reverse Direction Switch
00767 ZBRO Transmission Reverse Direction Switch
00767 ZBRO_R Transmission Reverse Direction Switch
SD 812a en-online 05.2007 Page 112 of 276
SPN Control unit/System Fault message
00767 ZFR Transmission Reverse Direction Switch
00767 ZH_AT3500_1580 Transmission Reverse Direction Switch
00767 ZH_AT3500_ST Transmission Reverse Direction Switch
00767 ZH_D5W_SC Transmission Reverse Direction Switch
00767 ZHZG_9a Transmission Reverse Direction Switch
00767 ZHZG_9c Transmission Reverse Direction Switch
00770 AB Split H
00770 ACC Split H
00770 AST Split H
00770 ASTMID Split H
00770 BHTC Split H
00770 CNG_ME7 Split H
00770 CRT Split H
00770 DIW5 Split H
00770 EBS Split H
00770 EBS_5 Split H
00770 EBS_K1 Split H
00770 ECAM Split H
00770 ECAS_4X2 Split H
00770 ECAS2_GBV Split H
00770 ECAS2_GBW Split H
00770 ECO2 Split H
00770 EDC Split H
00770 EDC_7 Split H
00770 EDC_7_M Split H
00770 EDC_7_MASTER Split H
00770 EDC_7_S Split H
00770 EDC_7_SLAVE Split H
00770 EDC6 Split H
00770 EDC64 Split H
00770 EDC7 Split H
00770 EDC7_6 Split H
00770 EDC7C32 Split H
00770 EDC7C32_6 Split H
00770 EDC7C32_M Split H
00770 EDC7C32_S Split H
00770 EDC7C32M_10 Split H
00770 EDC7C32M_12 Split H
00770 EDC7C32S_10 Split H
00770 EDC7C32S_12 Split H
00770 EDC7M_10 Split H
00770 EDC7M_12 Split H
00770 EDC7S_10 Split H
00770 EDC7S_12 Split H
00770 EHLA Split H
00770 EMOS Split H
00770 FFR Split H
00770 GKR Split H
00770 HDS Split H
00770 HEITZ Split H
00770 HVA Split H
00770 HYD Split H
00770 INST Split H
00770 INT Split H
00770 KR49X Split H
00770 KSM Split H
00770 LGS Split H
00770 MTS Split H
00770 OBDU Split H
00770 OUZBRO Split H
SD 812a en-online 05.2007 Page 113 of 276
SPN Control unit/System Fault message
00770 OUZBRO_R Split H
00770 PTM Split H
00770 RAS Split H
00770 RET Split H
00770 SFFR Split H
00770 SKG Split H
00770 STON Split H
00770 T509C Split H
00770 TBM Split H
00770 Test1Module Split H
00770 Test2Module Split H
00770 TPM Split H
00770 TRON Split H
00770 TRW Split H
00770 TUER_DR Split H
00770 TUER_PA Split H
00770 UHV Split H
00770 VRET Split H
00770 VSM Split H
00770 WSK Split H
00770 ZBR2 Split H
00770 ZBRO Split H
00770 ZBRO_R Split H
00770 ZFR Split H
00770 ZH_AT3500_1580 Split H
00770 ZH_AT3500_ST Split H
00770 ZH_D5W_SC Split H
00770 ZHZG_9a Split H
00770 ZHZG_9c Split H
00771 AB Split L
00771 ACC Split L
00771 AST Split L
00771 ASTMID Split L
00771 BHTC Split L
00771 CNG_ME7 Split L
00771 CRT Split L
00771 DIW5 Split L
00771 EBS Split L
00771 EBS_5 Split L
00771 EBS_K1 Split L
00771 ECAM Split L
00771 ECAS_4X2 Split L
00771 ECAS2_GBV Split L
00771 ECAS2_GBW Split L
00771 ECO2 Split L
00771 EDC Split L
00771 EDC_7 Split L
00771 EDC_7_M Split L
00771 EDC_7_MASTER Split L
00771 EDC_7_S Split L
00771 EDC_7_SLAVE Split L
00771 EDC6 Split L
00771 EDC64 Split L
00771 EDC7 Split L
00771 EDC7_6 Split L
00771 EDC7C32 Split L
00771 EDC7C32_6 Split L
00771 EDC7C32_M Split L
00771 EDC7C32_S Split L
00771 EDC7C32M_10 Split L
SD 812a en-online 05.2007 Page 114 of 276
SPN Control unit/System Fault message
00771 EDC7C32M_12 Split L
00771 EDC7C32S_10 Split L
00771 EDC7C32S_12 Split L
00771 EDC7M_10 Split L
00771 EDC7M_12 Split L
00771 EDC7S_10 Split L
00771 EDC7S_12 Split L
00771 EHLA Split L
00771 EMOS Split L
00771 FFR Split L
00771 GKR Split L
00771 HDS Split L
00771 HEITZ Split L
00771 HVA Split L
00771 HYD Split L
00771 INST Split L
00771 INT Split L
00771 KR49X Split L
00771 KSM Split L
00771 LGS Split L
00771 MTS Split L
00771 OBDU Split L
00771 OUZBRO Split L
00771 OUZBRO_R Split L
00771 PTM Split L
00771 RAS Split L
00771 RET Split L
00771 SFFR Split L
00771 SKG Split L
00771 STON Split L
00771 T509C Split L
00771 TBM Split L
00771 Test1Module Split L
00771 Test2Module Split L
00771 TPM Split L
00771 TRON Split L
00771 TRW Split L
00771 TUER_DR Split L
00771 TUER_PA Split L
00771 UHV Split L
00771 VRET Split L
00771 VSM Split L
00771 WSK Split L
00771 ZBR2 Split L
00771 ZBRO Split L
00771 ZBRO_R Split L
00771 ZFR Split L
00771 ZH_AT3500_1580 Split L
00771 ZH_AT3500_ST Split L
00771 ZH_D5W_SC Split L
00771 ZHZG_9a Split L
00771 ZHZG_9c Split L
00773 AB DNR switch
00773 ACC DNR switch
00773 AST DNR switch
00773 ASTMID DNR switch
00773 BHTC DNR switch
00773 CNG_ME7 DNR switch
00773 CRT DNR switch
00773 DIW5 DNR switch
SD 812a en-online 05.2007 Page 115 of 276
SPN Control unit/System Fault message
00773 EBS DNR switch
00773 EBS_5 DNR switch
00773 EBS_K1 DNR switch
00773 ECAM DNR switch
00773 ECAS_4X2 DNR switch
00773 ECAS2_GBV DNR switch
00773 ECAS2_GBW DNR switch
00773 ECO2 DNR switch
00773 EDC DNR switch
00773 EDC_7 DNR switch
00773 EDC_7_M DNR switch
00773 EDC_7_MASTER DNR switch
00773 EDC_7_S DNR switch
00773 EDC_7_SLAVE DNR switch
00773 EDC6 DNR switch
00773 EDC64 DNR switch
00773 EDC7 DNR switch
00773 EDC7_6 DNR switch
00773 EDC7C32 DNR switch
00773 EDC7C32_6 DNR switch
00773 EDC7C32_M DNR switch
00773 EDC7C32_S DNR switch
00773 EDC7C32M_10 DNR switch
00773 EDC7C32M_12 DNR switch
00773 EDC7C32S_10 DNR switch
00773 EDC7C32S_12 DNR switch
00773 EDC7M_10 DNR switch
00773 EDC7M_12 DNR switch
00773 EDC7S_10 DNR switch
00773 EDC7S_12 DNR switch
00773 EHLA DNR switch
00773 EMOS DNR switch
00773 FFR DNR switch
00773 GKR DNR switch
00773 HDS DNR switch
00773 HEITZ DNR switch
00773 HVA DNR switch
00773 HYD DNR switch
00773 INST DNR switch
00773 INT DNR switch
00773 KR49X DNR switch
00773 KSM DNR switch
00773 LGS DNR switch
00773 MTS DNR switch
00773 OBDU DNR switch
00773 OUZBRO DNR switch
00773 OUZBRO_R DNR switch
00773 PTM DNR switch
00773 RAS DNR switch
00773 RET DNR switch
00773 SFFR DNR switch
00773 SKG DNR switch
00773 STON DNR switch
00773 T509C DNR switch
00773 TBM DNR switch
00773 Test1Module DNR switch
00773 Test2Module DNR switch
00773 TPM DNR switch
00773 TRON DNR switch
00773 TRW DNR switch
SD 812a en-online 05.2007 Page 116 of 276
SPN Control unit/System Fault message
00773 TUER_DR DNR switch
00773 TUER_PA DNR switch
00773 UHV DNR switch
00773 VRET DNR switch
00773 VSM DNR switch
00773 WSK DNR switch
00773 ZBR2 DNR switch
00773 ZBRO DNR switch
00773 ZBRO_R DNR switch
00773 ZFR DNR switch
00773 ZH_AT3500_1580 DNR switch
00773 ZH_AT3500_ST DNR switch
00773 ZH_D5W_SC DNR switch
00773 ZHZG_9a DNR switch
00773 ZHZG_9c DNR switch
00780 AB Gearbox neutral indicator
00780 ACC Gearbox neutral indicator
00780 AST Gearbox neutral indicator
00780 ASTMID Gearbox neutral indicator
00780 BHTC Gearbox neutral indicator
00780 CNG_ME7 Gearbox neutral indicator
00780 CRT Gearbox neutral indicator
00780 DIW5 Gearbox neutral indicator
00780 EBS Gearbox neutral indicator
00780 EBS_5 Gearbox neutral indicator
00780 EBS_K1 Gearbox neutral indicator
00780 ECAM Gearbox neutral indicator
00780 ECAS_4X2 Gearbox neutral indicator
00780 ECAS2_GBV Gearbox neutral indicator
00780 ECAS2_GBW Gearbox neutral indicator
00780 ECO2 Gearbox neutral indicator
00780 EDC Gearbox neutral indicator
00780 EDC_7 Gearbox neutral indicator
00780 EDC_7_M Gearbox neutral indicator
00780 EDC_7_MASTER Gearbox neutral indicator
00780 EDC_7_S Gearbox neutral indicator
00780 EDC_7_SLAVE Gearbox neutral indicator
00780 EDC6 Gearbox neutral indicator
00780 EDC64 Gearbox neutral indicator
00780 EDC7 Gearbox neutral indicator
00780 EDC7_6 Gearbox neutral indicator
00780 EDC7C32 Gearbox neutral indicator
00780 EDC7C32_6 Gearbox neutral indicator
00780 EDC7C32_M Gearbox neutral indicator
00780 EDC7C32_S Gearbox neutral indicator
00780 EDC7C32M_10 Gearbox neutral indicator
00780 EDC7C32M_12 Gearbox neutral indicator
00780 EDC7C32S_10 Gearbox neutral indicator
00780 EDC7C32S_12 Gearbox neutral indicator
00780 EDC7M_10 Gearbox neutral indicator
00780 EDC7M_12 Gearbox neutral indicator
00780 EDC7S_10 Gearbox neutral indicator
00780 EDC7S_12 Gearbox neutral indicator
00780 EHLA Gearbox neutral indicator
00780 EMOS Gearbox neutral indicator
00780 FFR Gearbox neutral indicator
00780 GKR Gearbox neutral indicator
00780 HDS Gearbox neutral indicator
00780 HEITZ Gearbox neutral indicator
00780 HVA Gearbox neutral indicator
SD 812a en-online 05.2007 Page 117 of 276
SPN Control unit/System Fault message
00780 HYD Gearbox neutral indicator
00780 INST Gearbox neutral indicator
00780 INT Gearbox neutral indicator
00780 KR49X Gearbox neutral indicator
00780 KSM Gearbox neutral indicator
00780 LGS Gearbox neutral indicator
00780 MTS Gearbox neutral indicator
00780 OBDU Gearbox neutral indicator
00780 OUZBRO Gearbox neutral indicator
00780 OUZBRO_R Gearbox neutral indicator
00780 PTM Gearbox neutral indicator
00780 RAS Gearbox neutral indicator
00780 RET Gearbox neutral indicator
00780 SFFR Gearbox neutral indicator
00780 SKG Gearbox neutral indicator
00780 STON Gearbox neutral indicator
00780 T509C Gearbox neutral indicator
00780 TBM Gearbox neutral indicator
00780 Test1Module Gearbox neutral indicator
00780 Test2Module Gearbox neutral indicator
00780 TPM Gearbox neutral indicator
00780 TRON Gearbox neutral indicator
00780 TRW Gearbox neutral indicator
00780 TUER_DR Gearbox neutral indicator
00780 TUER_PA Gearbox neutral indicator
00780 UHV Gearbox neutral indicator
00780 VRET Gearbox neutral indicator
00780 VSM Gearbox neutral indicator
00780 WSK Gearbox neutral indicator
00780 ZBR2 Gearbox neutral indicator
00780 ZBRO Gearbox neutral indicator
00780 ZBRO_R Gearbox neutral indicator
00780 ZFR Gearbox neutral indicator
00780 ZH_AT3500_1580 Gearbox neutral indicator
00780 ZH_AT3500_ST Gearbox neutral indicator
00780 ZH_D5W_SC Gearbox neutral indicator
00780 ZHZG_9a Gearbox neutral indicator
00780 ZHZG_9c Gearbox neutral indicator
00789 EBS_5 (!) Wheel sensor wheel 1
00790 EBS_5 (!) Wheel sensor wheel 2
00791 EBS_5 (!) Wheel sensor wheel 3
00792 EBS_5 (!) Wheel sensor wheel 4
00793 EBS_5 (!) Wheel sensor wheel 5
00794 EBS_5 (!) Wheel sensor wheel 6
00833 AB Fuel Rack Position Sensor
00833 ACC Fuel Rack Position Sensor
00833 AST Fuel Rack Position Sensor
00833 ASTMID Fuel Rack Position Sensor
00833 BHTC Fuel Rack Position Sensor
00833 CNG_ME7 Fuel Rack Position Sensor
00833 CRT Fuel Rack Position Sensor
00833 DIW5 Fuel Rack Position Sensor
00833 EBS Fuel Rack Position Sensor
00833 EBS_5 Fuel Rack Position Sensor
00833 EBS_K1 Fuel Rack Position Sensor
00833 ECAM Fuel Rack Position Sensor
00833 ECAS_4X2 Fuel Rack Position Sensor
00833 ECAS2_GBV Fuel Rack Position Sensor
00833 ECAS2_GBW Fuel Rack Position Sensor
00833 ECO2 Fuel Rack Position Sensor
SD 812a en-online 05.2007 Page 118 of 276
SPN Control unit/System Fault message
00833 EDC Fuel Rack Position Sensor
00833 EDC_7 Fuel Rack Position Sensor
00833 EDC_7_M Fuel Rack Position Sensor
00833 EDC_7_MASTER Fuel Rack Position Sensor
00833 EDC_7_S Fuel Rack Position Sensor
00833 EDC_7_SLAVE Fuel Rack Position Sensor
00833 EDC6 Control path
00833 EDC64 Fuel Rack Position Sensor
00833 EDC7 Fuel Rack Position Sensor
00833 EDC7_6 Fuel Rack Position Sensor
00833 EDC7C32 Fuel Rack Position Sensor
00833 EDC7C32_6 Fuel Rack Position Sensor
00833 EDC7C32_M Fuel Rack Position Sensor
00833 EDC7C32_S Fuel Rack Position Sensor
00833 EDC7C32M_10 Fuel Rack Position Sensor
00833 EDC7C32M_12 Fuel Rack Position Sensor
00833 EDC7C32S_10 Fuel Rack Position Sensor
00833 EDC7C32S_12 Fuel Rack Position Sensor
00833 EDC7M_10 Fuel Rack Position Sensor
00833 EDC7M_12 Fuel Rack Position Sensor
00833 EDC7S_10 Fuel Rack Position Sensor
00833 EDC7S_12 Fuel Rack Position Sensor
00833 EHLA Fuel Rack Position Sensor
00833 EMOS Fuel Rack Position Sensor
00833 FFR Fuel Rack Position Sensor
00833 GKR Fuel Rack Position Sensor
00833 HDS Fuel Rack Position Sensor
00833 HEITZ Fuel Rack Position Sensor
00833 HVA Fuel Rack Position Sensor
00833 HYD Fuel Rack Position Sensor
00833 INST Fuel Rack Position Sensor
00833 INT Fuel Rack Position Sensor
00833 KR49X Fuel Rack Position Sensor
00833 KSM Fuel Rack Position Sensor
00833 LGS Fuel Rack Position Sensor
00833 MTS Fuel Rack Position Sensor
00833 OBDU Fuel Rack Position Sensor
00833 OUZBRO Fuel Rack Position Sensor
00833 OUZBRO_R Fuel Rack Position Sensor
00833 PTM Fuel Rack Position Sensor
00833 RAS Fuel Rack Position Sensor
00833 RET Fuel Rack Position Sensor
00833 SFFR Fuel Rack Position Sensor
00833 SKG Fuel Rack Position Sensor
00833 STON Fuel Rack Position Sensor
00833 T509C Fuel Rack Position Sensor
00833 TBM Fuel Rack Position Sensor
00833 Test1Module Fuel Rack Position Sensor
00833 Test2Module Fuel Rack Position Sensor
00833 TPM Fuel Rack Position Sensor
00833 TRON Fuel Rack Position Sensor
00833 TRW Fuel Rack Position Sensor
00833 TUER_DR Fuel Rack Position Sensor
00833 TUER_PA Fuel Rack Position Sensor
00833 UHV Fuel Rack Position Sensor
00833 VRET Fuel Rack Position Sensor
00833 VSM Fuel Rack Position Sensor
00833 WSK Fuel Rack Position Sensor
00833 ZBR2 Fuel Rack Position Sensor
00833 ZBRO Fuel Rack Position Sensor
SD 812a en-online 05.2007 Page 119 of 276
SPN Control unit/System Fault message
00833 ZBRO_R Fuel Rack Position Sensor
00833 ZFR Fuel Rack Position Sensor
00833 ZH_AT3500_1580 Fuel Rack Position Sensor
00833 ZH_AT3500_ST Fuel Rack Position Sensor
00833 ZH_D5W_SC Fuel Rack Position Sensor
00833 ZHZG_9a Fuel Rack Position Sensor
00833 ZHZG_9c Fuel Rack Position Sensor
00835 RAS Oil level signal
00876 GKR Compressor coupling
00877 GKR Evaporator temperature sensor
00898 AB Maximum speed limiter switch
00898 ACC Maximum speed limiter switch
00898 AST Maximum speed limiter switch
00898 ASTMID Maximum speed limiter switch
00898 BHTC Maximum speed limiter switch
00898 CNG_ME7 Maximum speed limiter switch
00898 CRT Maximum speed limiter switch
00898 DIW5 Maximum speed limiter switch
00898 EBS Maximum speed limiter switch
00898 EBS_5 Maximum speed limiter switch
00898 EBS_K1 Maximum speed limiter switch
00898 ECAM Maximum speed limiter switch
00898 ECAS_4X2 Maximum speed limiter switch
00898 ECAS2_GBV Maximum speed limiter switch
00898 ECAS2_GBW Maximum speed limiter switch
00898 ECO2 Maximum speed limiter switch
00898 EDC Maximum speed limiter switch
00898 EDC_7 Maximum speed limiter switch
00898 EDC_7_M Maximum speed limiter switch
00898 EDC_7_MASTER Maximum speed limiter switch
00898 EDC_7_S Maximum speed limiter switch
00898 EDC_7_SLAVE Maximum speed limiter switch
00898 EDC6 Maximum speed limiter switch
00898 EDC64 Maximum speed limiter switch
00898 EDC7 Maximum speed limiter switch
00898 EDC7_6 Maximum speed limiter switch
00898 EDC7C32 Maximum speed limiter switch
00898 EDC7C32_6 Maximum speed limiter switch
00898 EDC7C32_M Maximum speed limiter switch
00898 EDC7C32_S Maximum speed limiter switch
00898 EDC7C32M_10 Maximum speed limiter switch
00898 EDC7C32M_12 Maximum speed limiter switch
00898 EDC7C32S_10 Maximum speed limiter switch
00898 EDC7C32S_12 Maximum speed limiter switch
00898 EDC7M_10 Maximum speed limiter switch
00898 EDC7M_12 Maximum speed limiter switch
00898 EDC7S_10 Maximum speed limiter switch
00898 EDC7S_12 Maximum speed limiter switch
00898 EHLA Maximum speed limiter switch
00898 EMOS Maximum speed limiter switch
00898 FFR Maximum speed limiter switch
00898 GKR Maximum speed limiter switch
00898 HDS Maximum speed limiter switch
00898 HEITZ Maximum speed limiter switch
00898 HVA Maximum speed limiter switch
00898 HYD Maximum speed limiter switch
00898 INST Maximum speed limiter switch
00898 INT Maximum speed limiter switch
00898 KR49X Maximum speed limiter switch
00898 KSM Maximum speed limiter switch
SD 812a en-online 05.2007 Page 120 of 276
SPN Control unit/System Fault message
00898 LGS Maximum speed limiter switch
00898 MTS Maximum speed limiter switch
00898 OBDU Maximum speed limiter switch
00898 OUZBRO Maximum speed limiter switch
00898 OUZBRO_R Maximum speed limiter switch
00898 PTM Maximum speed limiter switch
00898 RAS Maximum speed limiter switch
00898 RET Maximum speed limiter switch
00898 SFFR Maximum speed limiter switch
00898 SKG Maximum speed limiter switch
00898 STON Maximum speed limiter switch
00898 T509C Maximum speed limiter switch
00898 TBM Maximum speed limiter switch
00898 Test1Module Maximum speed limiter switch
00898 Test2Module Maximum speed limiter switch
00898 TPM Maximum speed limiter switch
00898 TRON Maximum speed limiter switch
00898 TRW Maximum speed limiter switch
00898 TUER_DR Maximum speed limiter switch
00898 TUER_PA Maximum speed limiter switch
00898 UHV Maximum speed limiter switch
00898 VRET Maximum speed limiter switch
00898 VSM Maximum speed limiter switch
00898 WSK Maximum speed limiter switch
00898 ZBR2 Maximum speed limiter switch
00898 ZBRO Maximum speed limiter switch
00898 ZBRO_R Maximum speed limiter switch
00898 ZFR Maximum speed limiter switch
00898 ZH_AT3500_1580 Maximum speed limiter switch
00898 ZH_AT3500_ST Maximum speed limiter switch
00898 ZH_D5W_SC Maximum speed limiter switch
00898 ZHZG_9a Maximum speed limiter switch
00898 ZHZG_9c Maximum speed limiter switch
00904 AB Front axle speed
00904 ACC Front axle speed
00904 AST Front axle speed
00904 ASTMID Front axle speed
00904 BHTC Front axle speed
00904 CNG_ME7 Front axle speed
00904 CRT Front axle speed
00904 DIW5 Front axle speed
00904 EBS Front axle speed
00904 EBS_5 Front axle speed
00904 EBS_K1 Front axle speed
00904 ECAM Front axle speed
00904 ECAS_4X2 Front axle speed
00904 ECAS2_GBV Front axle speed
00904 ECAS2_GBW Front axle speed
00904 ECO2 Front axle speed
00904 EDC Front axle speed
00904 EDC_7 Front axle speed
00904 EDC_7_M Front axle speed
00904 EDC_7_MASTER Front axle speed
00904 EDC_7_S Front axle speed
00904 EDC_7_SLAVE Front axle speed
00904 EDC6 Front axle speed
00904 EDC64 Front axle speed
00904 EDC7 Front axle speed
00904 EDC7_6 Front axle speed
00904 EDC7C32 Front axle speed
SD 812a en-online 05.2007 Page 121 of 276
SPN Control unit/System Fault message
00904 EDC7C32_6 Front axle speed
00904 EDC7C32_M Front axle speed
00904 EDC7C32_S Front axle speed
00904 EDC7C32M_10 Front axle speed
00904 EDC7C32M_12 Front axle speed
00904 EDC7C32S_10 Front axle speed
00904 EDC7C32S_12 Front axle speed
00904 EDC7M_10 Front axle speed
00904 EDC7M_12 Front axle speed
00904 EDC7S_10 Front axle speed
00904 EDC7S_12 Front axle speed
00904 EHLA Front axle speed
00904 EMOS Front axle speed
00904 FFR Front axle speed
00904 GKR Front axle speed
00904 HDS Front axle speed
00904 HEITZ Front axle speed
00904 HVA Front axle speed
00904 HYD Front axle speed
00904 INST Front axle speed
00904 INT Front axle speed
00904 KR49X Front axle speed
00904 KSM Front axle speed
00904 LGS Front axle speed
00904 MTS Front axle speed
00904 OBDU Front axle speed
00904 OUZBRO Front axle speed
00904 OUZBRO_R Front axle speed
00904 PTM Front axle speed
00904 RAS Front axle speed
00904 RET Front axle speed
00904 SFFR Front axle speed
00904 SKG Front axle speed
00904 STON Front axle speed
00904 T509C Front axle speed
00904 TBM Front axle speed
00904 Test1Module Front axle speed
00904 Test2Module Front axle speed
00904 TPM Front axle speed
00904 TRON Front axle speed
00904 TRW Front axle speed
00904 TUER_DR Front axle speed
00904 TUER_PA Front axle speed
00904 UHV Front axle speed
00904 VRET Front axle speed
00904 VSM Front axle speed
00904 WSK Front axle speed
00904 ZBR2 Front axle speed
00904 ZBRO Front axle speed
00904 ZBRO_R Front axle speed
00904 ZFR Front axle speed
00904 ZH_AT3500_1580 Front axle speed
00904 ZH_AT3500_ST Front axle speed
00904 ZH_D5W_SC Front axle speed
00904 ZHZG_9a Front axle speed
00904 ZHZG_9c Front axle speed
00905 EMOS Differential speed left front wheel
00906 EMOS Differential speed right front wheel
00907 EMOS Differential speed left rear wheel
00908 EMOS Differential speed right rear wheel
SD 812a en-online 05.2007 Page 122 of 276
SPN Control unit/System Fault message
00929 TPM Tyre data
00932 EBS_5 Pressure regulating valve left intake valve
00933 EBS_5 Pressure regulating valve right intake valve
00938 EBS_5 Pressure regulating valve left exhaust valve
00939 EBS_5 Pressure regulating valve right exhaust valve
00944 AB Driver’s airbag (loop 1)
00946 AB left BT (loop 2)
00948 AB SRS lamp
00959 AB Seconds
00959 ACC Seconds
00959 AST Seconds
00959 ASTMID Seconds
00959 BHTC Seconds
00959 CNG_ME7 Seconds
00959 CRT Seconds
00959 DIW5 CAN message: Time/date, signal: Seconds
00959 EBS Seconds
00959 EBS_5 Seconds
00959 EBS_K1 Seconds
00959 ECAM Seconds
00959 ECAS_4X2 Seconds
00959 ECAS2_GBV Seconds
00959 ECAS2_GBW Seconds
00959 ECO2 Seconds
00959 EDC Seconds
00959 EDC_7 Seconds
00959 EDC_7_M Seconds
00959 EDC_7_MASTER Seconds
00959 EDC_7_S Seconds
00959 EDC_7_SLAVE Seconds
00959 EDC6 TIME/DATE: Seconds invalid
00959 EDC64 Seconds
00959 EDC7 Seconds
00959 EDC7_6 Seconds
00959 EDC7C32 Seconds
00959 EDC7C32_6 Seconds
00959 EDC7C32_M Seconds
00959 EDC7C32_S Seconds
00959 EDC7C32M_10 Seconds
00959 EDC7C32M_12 Seconds
00959 EDC7C32S_10 Seconds
00959 EDC7C32S_12 Seconds
00959 EDC7M_10 Seconds
00959 EDC7M_12 Seconds
00959 EDC7S_10 Seconds
00959 EDC7S_12 Seconds
00959 EHLA Seconds
00959 EMOS Seconds
00959 FFR Seconds
00959 GKR Seconds
00959 HDS Seconds
00959 HEITZ Seconds
00959 HVA Seconds
00959 HYD Seconds
00959 INST Seconds
00959 INT Seconds
00959 KR49X Seconds
00959 KSM Seconds
00959 LGS Seconds
00959 MTS Seconds
SD 812a en-online 05.2007 Page 123 of 276
SPN Control unit/System Fault message
00959 OBDU Seconds
00959 OUZBRO Seconds
00959 OUZBRO_R Seconds
00959 PTM Seconds
00959 RAS Seconds
00959 RET Seconds
00959 SFFR Seconds
00959 SKG Seconds
00959 STON Seconds
00959 T509C Seconds
00959 TBM Seconds
00959 Test1Module Seconds
00959 Test2Module Seconds
00959 TPM Seconds
00959 TRON Seconds
00959 TRW Seconds
00959 TUER_DR Seconds
00959 TUER_PA Seconds
00959 UHV Seconds
00959 VRET Seconds
00959 VSM Seconds
00959 WSK Seconds
00959 ZBR2 Seconds
00959 ZBRO Seconds
00959 ZBRO_R Seconds
00959 ZFR Seconds
00959 ZH_AT3500_1580 Seconds
00959 ZH_AT3500_ST Seconds
00959 ZH_D5W_SC Seconds
00959 ZHZG_9a Seconds
00959 ZHZG_9c Seconds
00960 AB Minutes
00960 ACC Minutes
00960 AST Minutes
00960 ASTMID Minutes
00960 BHTC Minutes
00960 CNG_ME7 Minutes
00960 CRT Minutes
00960 DIW5 CAN message: Time/date, signal: Minutes
00960 EBS Minutes
00960 EBS_5 Minutes
00960 EBS_K1 Minutes
00960 ECAM Minutes
00960 ECAS_4X2 Minutes
00960 ECAS2_GBV Minutes
00960 ECAS2_GBW Minutes
00960 ECO2 Minutes
00960 EDC Minutes
00960 EDC_7 Minutes
00960 EDC_7_M Minutes
00960 EDC_7_MASTER Minutes
00960 EDC_7_S Minutes
00960 EDC_7_SLAVE Minutes
00960 EDC6 TIME/DATE: Minutes invalid
00960 EDC64 Minutes
00960 EDC7 Minutes
00960 EDC7_6 Minutes
00960 EDC7C32 Minutes
00960 EDC7C32_6 Minutes
00960 EDC7C32_M Minutes
SD 812a en-online 05.2007 Page 124 of 276
SPN Control unit/System Fault message
00960 EDC7C32_S Minutes
00960 EDC7C32M_10 Minutes
00960 EDC7C32M_12 Minutes
00960 EDC7C32S_10 Minutes
00960 EDC7C32S_12 Minutes
00960 EDC7M_10 Minutes
00960 EDC7M_12 Minutes
00960 EDC7S_10 Minutes
00960 EDC7S_12 Minutes
00960 EHLA Minutes
00960 EMOS Minutes
00960 FFR Minutes
00960 GKR Minutes
00960 HDS Minutes
00960 HEITZ Minutes
00960 HVA Minutes
00960 HYD Minutes
00960 INST Minutes
00960 INT Minutes
00960 KR49X Minutes
00960 KSM Minutes
00960 LGS Minutes
00960 MTS Minutes
00960 OBDU Minutes
00960 OUZBRO Minutes
00960 OUZBRO_R Minutes
00960 PTM Minutes
00960 RAS Minutes
00960 RET Minutes
00960 SFFR Minutes
00960 SKG Minutes
00960 STON Minutes
00960 T509C Minutes
00960 TBM Minutes
00960 Test1Module Minutes
00960 Test2Module Minutes
00960 TPM Minutes
00960 TRON Minutes
00960 TRW Minutes
00960 TUER_DR Minutes
00960 TUER_PA Minutes
00960 UHV Minutes
00960 VRET Minutes
00960 VSM Minutes
00960 WSK Minutes
00960 ZBR2 Minutes
00960 ZBRO Minutes
00960 ZBRO_R Minutes
00960 ZFR Minutes
00960 ZH_AT3500_1580 Minutes
00960 ZH_AT3500_ST Minutes
00960 ZH_D5W_SC Minutes
00960 ZHZG_9a Minutes
00960 ZHZG_9c Minutes
00961 AB Hours
00961 ACC Hours
00961 AST Hours
00961 ASTMID Hours
00961 BHTC Hours
00961 CNG_ME7 Hours
SD 812a en-online 05.2007 Page 125 of 276
SPN Control unit/System Fault message
00961 CRT Hours
00961 DIW5 CAN message: Time/date, signal: Hours
00961 EBS Hours
00961 EBS_5 Hours
00961 EBS_K1 Hours
00961 ECAM Hours
00961 ECAS_4X2 Hours
00961 ECAS2_GBV Hours
00961 ECAS2_GBW Hours
00961 ECO2 Hours
00961 EDC Hours
00961 EDC_7 Hours
00961 EDC_7_M Hours
00961 EDC_7_MASTER Hours
00961 EDC_7_S Hours
00961 EDC_7_SLAVE Hours
00961 EDC6 TIME/DATE: Hours invalid
00961 EDC64 Hours
00961 EDC7 Hours
00961 EDC7_6 Hours
00961 EDC7C32 Hours
00961 EDC7C32_6 Hours
00961 EDC7C32_M Hours
00961 EDC7C32_S Hours
00961 EDC7C32M_10 Hours
00961 EDC7C32M_12 Hours
00961 EDC7C32S_10 Hours
00961 EDC7C32S_12 Hours
00961 EDC7M_10 Hours
00961 EDC7M_12 Hours
00961 EDC7S_10 Hours
00961 EDC7S_12 Hours
00961 EHLA Hours
00961 EMOS Hours
00961 FFR Hours
00961 GKR Hours
00961 HDS Hours
00961 HEITZ Hours
00961 HVA Hours
00961 HYD Hours
00961 INST Hours
00961 INT Hours
00961 KR49X Hours
00961 KSM Hours
00961 LGS Hours
00961 MTS Hours
00961 OBDU Hours
00961 OUZBRO Hours
00961 OUZBRO_R Hours
00961 PTM Hours
00961 RAS Hours
00961 RET Hours
00961 SFFR Hours
00961 SKG Hours
00961 STON Hours
00961 T509C Hours
00961 TBM Hours
00961 Test1Module Hours
00961 Test2Module Hours
00961 TPM Hours
SD 812a en-online 05.2007 Page 126 of 276
SPN Control unit/System Fault message
00961 TRON Hours
00961 TRW Hours
00961 TUER_DR Hours
00961 TUER_PA Hours
00961 UHV Hours
00961 VRET Hours
00961 VSM Hours
00961 WSK Hours
00961 ZBR2 Hours
00961 ZBRO Hours
00961 ZBRO_R Hours
00961 ZFR Hours
00961 ZH_AT3500_1580 Hours
00961 ZH_AT3500_ST Hours
00961 ZH_D5W_SC Hours
00961 ZHZG_9a Hours
00961 ZHZG_9c Hours
00962 AB Day
00962 ACC Day
00962 AST Day
00962 ASTMID Day
00962 BHTC Day
00962 CNG_ME7 Day
00962 CRT Day
00962 DIW5 CAN message: Time/date, signal: Day
00962 EBS Day
00962 EBS_5 Day
00962 EBS_K1 Day
00962 ECAM Day
00962 ECAS_4X2 Day
00962 ECAS2_GBV Day
00962 ECAS2_GBW Day
00962 ECO2 Day
00962 EDC Day
00962 EDC_7 Day
00962 EDC_7_M Day
00962 EDC_7_MASTER Day
00962 EDC_7_S Day
00962 EDC_7_SLAVE Day
00962 EDC6 TIME/DATE: Days invalid
00962 EDC64 Day
00962 EDC7 Day
00962 EDC7_6 Day
00962 EDC7C32 Day
00962 EDC7C32_6 Day
00962 EDC7C32_M Day
00962 EDC7C32_S Day
00962 EDC7C32M_10 Day
00962 EDC7C32M_12 Day
00962 EDC7C32S_10 Day
00962 EDC7C32S_12 Day
00962 EDC7M_10 Day
00962 EDC7M_12 Day
00962 EDC7S_10 Day
00962 EDC7S_12 Day
00962 EHLA Day
00962 EMOS Day
00962 FFR Day
00962 GKR Day
00962 HDS Day
SD 812a en-online 05.2007 Page 127 of 276
SPN Control unit/System Fault message
00962 HEITZ Day
00962 HVA Day
00962 HYD Day
00962 INST Day
00962 INT Day
00962 KR49X Day
00962 KSM Day
00962 LGS Day
00962 MTS Day
00962 OBDU Day
00962 OUZBRO Day
00962 OUZBRO_R Day
00962 PTM Day
00962 RAS Day
00962 RET Day
00962 SFFR Day
00962 SKG Day
00962 STON Day
00962 T509C Day
00962 TBM Day
00962 Test1Module Day
00962 Test2Module Day
00962 TPM Day
00962 TRON Day
00962 TRW Day
00962 TUER_DR Day
00962 TUER_PA Day
00962 UHV Day
00962 VRET Day
00962 VSM Day
00962 WSK Day
00962 ZBR2 Day
00962 ZBRO Day
00962 ZBRO_R Day
00962 ZFR Day
00962 ZH_AT3500_1580 Day
00962 ZH_AT3500_ST Day
00962 ZH_D5W_SC Day
00962 ZHZG_9a Day
00962 ZHZG_9c Day
00963 AB Month
00963 ACC Month
00963 AST Month
00963 ASTMID Month
00963 BHTC Month
00963 CNG_ME7 Month
00963 CRT Month
00963 DIW5 CAN message: Time/date, signal: Month
00963 EBS Month
00963 EBS_5 Month
00963 EBS_K1 Month
00963 ECAM Month
00963 ECAS_4X2 Month
00963 ECAS2_GBV Month
00963 ECAS2_GBW Month
00963 ECO2 Month
00963 EDC Month
00963 EDC_7 Month
00963 EDC_7_M Month
00963 EDC_7_MASTER Month
SD 812a en-online 05.2007 Page 128 of 276
SPN Control unit/System Fault message
00963 EDC_7_S Month
00963 EDC_7_SLAVE Month
00963 EDC6 TIME/DATE: Months invalid
00963 EDC64 Month
00963 EDC7 Month
00963 EDC7_6 Month
00963 EDC7C32 Month
00963 EDC7C32_6 Month
00963 EDC7C32_M Month
00963 EDC7C32_S Month
00963 EDC7C32M_10 Month
00963 EDC7C32M_12 Month
00963 EDC7C32S_10 Month
00963 EDC7C32S_12 Month
00963 EDC7M_10 Month
00963 EDC7M_12 Month
00963 EDC7S_10 Month
00963 EDC7S_12 Month
00963 EHLA Month
00963 EMOS Month
00963 FFR Month
00963 GKR Month
00963 HDS Month
00963 HEITZ Month
00963 HVA Month
00963 HYD Month
00963 INST Month
00963 INT Month
00963 KR49X Month
00963 KSM Month
00963 LGS Month
00963 MTS Month
00963 OBDU Month
00963 OUZBRO Month
00963 OUZBRO_R Month
00963 PTM Month
00963 RAS Month
00963 RET Month
00963 SFFR Month
00963 SKG Month
00963 STON Month
00963 T509C Month
00963 TBM Month
00963 Test1Module Month
00963 Test2Module Month
00963 TPM Month
00963 TRON Month
00963 TRW Month
00963 TUER_DR Month
00963 TUER_PA Month
00963 UHV Month
00963 VRET Month
00963 VSM Month
00963 WSK Month
00963 ZBR2 Month
00963 ZBRO Month
00963 ZBRO_R Month
00963 ZFR Month
00963 ZH_AT3500_1580 Month
00963 ZH_AT3500_ST Month
SD 812a en-online 05.2007 Page 129 of 276
SPN Control unit/System Fault message
00963 ZH_D5W_SC Month
00963 ZHZG_9a Month
00963 ZHZG_9c Month
00964 AB Year
00964 ACC Year
00964 AST Year
00964 ASTMID Year
00964 BHTC Year
00964 CNG_ME7 Year
00964 CRT Year
00964 DIW5 CAN message: Time/date, signal: Year
00964 EBS Year
00964 EBS_5 Year
00964 EBS_K1 Year
00964 ECAM Year
00964 ECAS_4X2 Year
00964 ECAS2_GBV Year
00964 ECAS2_GBW Year
00964 ECO2 Year
00964 EDC Year
00964 EDC_7 Year
00964 EDC_7_M Year
00964 EDC_7_MASTER Year
00964 EDC_7_S Year
00964 EDC_7_SLAVE Year
00964 EDC6 TIME/DATE: Year invalid
00964 EDC64 Year
00964 EDC7 Year
00964 EDC7_6 Year
00964 EDC7C32 Year
00964 EDC7C32_6 Year
00964 EDC7C32_M Year
00964 EDC7C32_S Year
00964 EDC7C32M_10 Year
00964 EDC7C32M_12 Year
00964 EDC7C32S_10 Year
00964 EDC7C32S_12 Year
00964 EDC7M_10 Year
00964 EDC7M_12 Year
00964 EDC7S_10 Year
00964 EDC7S_12 Year
00964 EHLA Year
00964 EMOS Year
00964 FFR Year
00964 GKR Year
00964 HDS Year
00964 HEITZ Year
00964 HVA Year
00964 HYD Year
00964 INST Year
00964 INT Year
00964 KR49X Year
00964 KSM Year
00964 LGS Year
00964 MTS Year
00964 OBDU Year
00964 OUZBRO Year
00964 OUZBRO_R Year
00964 PTM Year
00964 RAS Year
SD 812a en-online 05.2007 Page 130 of 276
SPN Control unit/System Fault message
00964 RET Year
00964 SFFR Year
00964 SKG Year
00964 STON Year
00964 T509C Year
00964 TBM Year
00964 Test1Module Year
00964 Test2Module Year
00964 TPM Year
00964 TRON Year
00964 TRW Year
00964 TUER_DR Year
00964 TUER_PA Year
00964 UHV Year
00964 VRET Year
00964 VSM Year
00964 WSK Year
00964 ZBR2 Year
00964 ZBRO Year
00964 ZBRO_R Year
00964 ZFR Year
00964 ZH_AT3500_1580 Year
00964 ZH_AT3500_ST Year
00964 ZH_D5W_SC Year
00964 ZHZG_9a Year
00964 ZHZG_9c Year
00974 KSM Pedal value sensor
00976 KSM Ready output
01007 ZBR2 Trip Drive Fuel Used (Natural Gas)
01031 ZBR2 Trip Average Fuel Rate (Natural Gas)
01042 EBS_5 ISO 11992 (trailer CAN): Data bus switched off
01043 ECAS_4X2 Supply voltage for peripherals
01045 AB Gate interlock (auxiliary engines also brake lamp output stage)
01045 ACC Gate interlock (auxiliary engines also brake lamp output stage)
01045 AST Gate interlock (auxiliary engines also brake lamp output stage)
01045 ASTMID Gate interlock (auxiliary engines also brake lamp output stage)
01045 BHTC Gate interlock (auxiliary engines also brake lamp output stage)
01045 CNG_ME7 Gate interlock (auxiliary engines also brake lamp output stage)
01045 CRT Gate interlock (auxiliary engines also brake lamp output stage)
01045 DIW5 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EBS Gate interlock (auxiliary engines also brake lamp output stage)
01045 EBS_5 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EBS_K1 Gate interlock (auxiliary engines also brake lamp output stage)
01045 ECAM Gate interlock (auxiliary engines also brake lamp output stage)
01045 ECAS_4X2 Gate interlock (auxiliary engines also brake lamp output stage)
01045 ECAS2_GBV Gate interlock (auxiliary engines also brake lamp output stage)
SD 812a en-online 05.2007 Page 131 of 276
SPN Control unit/System Fault message
01045 ECAS2_GBW Gate interlock (auxiliary engines also brake lamp output stage)
01045 ECO2 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC_7 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC_7_M Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC_7_MASTER Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC_7_S Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC_7_SLAVE Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC6 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC64 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7_6 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7C32 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7C32_6 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7C32_M Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7C32_S Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7C32M_10 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7C32M_12 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7C32S_10 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7C32S_12 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7M_10 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7M_12 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7S_10 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EDC7S_12 Gate interlock (auxiliary engines also brake lamp output stage)
01045 EHLA Gate interlock (auxiliary engines also brake lamp output stage)
01045 EMOS Gate interlock (auxiliary engines also brake lamp output stage)
01045 FFR Gate interlock (auxiliary engines also brake lamp output stage)
01045 GKR Gate interlock (auxiliary engines also brake lamp output stage)
01045 HDS Gate interlock (auxiliary engines also brake lamp output stage)
01045 HEITZ Gate interlock (auxiliary engines also brake lamp output stage)
SD 812a en-online 05.2007 Page 132 of 276
SPN Control unit/System Fault message
01045 HVA Gate interlock (auxiliary engines also brake lamp output stage)
01045 HYD Gate interlock (auxiliary engines also brake lamp output stage)
01045 INST Gate interlock (auxiliary engines also brake lamp output stage)
01045 INT Gate interlock (auxiliary engines also brake lamp output stage)
01045 KR49X Gate interlock (auxiliary engines also brake lamp output stage)
01045 KSM Gate interlock (auxiliary engines also brake lamp output stage)
01045 LGS Gate interlock (auxiliary engines also brake lamp output stage)
01045 MTS Gate interlock (auxiliary engines also brake lamp output stage)
01045 OBDU Gate interlock (auxiliary engines also brake lamp output stage)
01045 OUZBRO Gate interlock (auxiliary engines also brake lamp output stage)
01045 OUZBRO_R Gate interlock (auxiliary engines also brake lamp output stage)
01045 PTM Gate interlock (auxiliary engines also brake lamp output stage)
01045 RAS Gate interlock (auxiliary engines also brake lamp output stage)
01045 RET Gate interlock (auxiliary engines also brake lamp output stage)
01045 SFFR Gate interlock (auxiliary engines also brake lamp output stage)
01045 SKG Gate interlock (auxiliary engines also brake lamp output stage)
01045 STON Gate interlock (auxiliary engines also brake lamp output stage)
01045 T509C Gate interlock (auxiliary engines also brake lamp output stage)
01045 TBM Gate interlock (auxiliary engines also brake lamp output stage)
01045 Test1Module Gate interlock (auxiliary engines also brake lamp output stage)
01045 Test2Module Gate interlock (auxiliary engines also brake lamp output stage)
01045 TPM Gate interlock (auxiliary engines also brake lamp output stage)
01045 TRON Gate interlock (auxiliary engines also brake lamp output stage)
01045 TRW Gate interlock (auxiliary engines also brake lamp output stage)
01045 TUER_DR Gate interlock (auxiliary engines also brake lamp output stage)
01045 TUER_PA Gate interlock (auxiliary engines also brake lamp output stage)
01045 UHV Gate interlock (auxiliary engines also brake lamp output stage)
01045 VRET Gate interlock (auxiliary engines also brake lamp output stage)
01045 VSM Gate interlock (auxiliary engines also brake lamp output stage)
01045 WSK Gate interlock (auxiliary engines also brake lamp output stage)
SD 812a en-online 05.2007 Page 133 of 276
SPN Control unit/System Fault message
01045 ZBR2 Gate interlock (auxiliary engines also brake lamp output stage)
01045 ZBRO Gate interlock (auxiliary engines also brake lamp output stage)
01045 ZBRO_R Gate interlock (auxiliary engines also brake lamp output stage)
01045 ZFR Gate interlock (auxiliary engines also brake lamp output stage)
01045 ZH_AT3500_1580 Gate interlock (auxiliary engines also brake lamp output stage)
01045 ZH_AT3500_ST Gate interlock (auxiliary engines also brake lamp output stage)
01045 ZH_D5W_SC Gate interlock (auxiliary engines also brake lamp output stage)
01045 ZHZG_9a Gate interlock (auxiliary engines also brake lamp output stage)
01045 ZHZG_9c Gate interlock (auxiliary engines also brake lamp output stage)
01056 EBS_5 (!) Trailer control module pressure control, maximum pressure
03011 EBS Control unit defective; error in service brake valve characteristic
03011 ECAS_4X2 Control unit (checksum parameter)
03011 ECAS2_GBV Control unit (checksum parameter)
03011 EDC6 Angle of injection start
03011 EDC7 Angle of injection start
SD 812a en-online 05.2007 Page 156 of 276
SPN Control unit/System Fault message
03011 EHLA Signature EOL parameter
03011 FFR EVB pressure sensor
03011 KR49X Valve driver heating/cooling
CAN data bus: Time overrun when receiving CBR message
03011 KSM Aux_Stat_Zbr1.
03011 LGS Left loudspeaker
03011 TBM GPS aerial current
03011 TPM Pressure in left outer tyre, axle 1
03011 TUER_DR Central locking does not lock
03012 BHTC Stepper motor recirculated air
Control unit defective; incompatibility in data record version
03012 EBS number
03012 EBS_K1 EEPROM parameters
03012 ECAS_4X2 Control unit (checksum calibration data travel sensors)
03012 ECAS2_GBV Control unit (checksum calibration data travel sensors)
03012 EDC6 CAN module
03012 EDC7 CAN module
03012 EHLA Value range EOL parameter
03012 KR49X Valve convector
CAN data bus: Time overrun when receiving CBR message
03012 KSM Time_Date.
03012 LGS Right loudspeaker
03012 RET Pressure from cooler valve (brake lamp)
03012 TPM Pressure in left inner tyre, axle 1
03013 BHTC Stepper motor air distribution
03027 SFFR Engine CAN: Time overrun when receiving EDC message EDC1
CAN data bus retarder check from secondary retarder,
03028 AST ERC1_RD (current retarder torque)
Brake pad wear: Incorrect tendency between the wheels of axle
03028 EBS 4
03028 EBS_K1 Dynamic pad trend fault additional axle
03028 EDC6 FFR2: Nominal torque value too low
03028 EDC7 FFR2: Nominal torque value too low
03028 EHLA Cab position, swivelling is taking too long
CAN data bus: Time overrun when receiving vehicle
03028 KSM management computer message ERC1_RX.
03028 SFFR Engine CAN: Time overrun when receiving EDC message EDC2
03029 SFFR Engine CAN: Time overrun when receiving EDC message EDC3
CAN data bus retarder configuration from secondary retarder,
03030 AST Ret_Conf driveline retarder configuration
03030 BHTC Stepper motor valve C
Faulty brake pad wear and retarder relay output stage
03030 EBS checkback
03030 EDC6 FFR2: Bit error, idling speed governing parameter ID
03030 EDC7 FFR2: Bit error, idling speed governing parameter ID
03030 EHLA Emergency steering pump
CAN data bus: Time overrun when receiving tachograph
03030 KSM message P_MTCO_VIN.
03030 SFFR Engine CAN: Time overrun when receiving EDC message EDC4
Severe leakage: Severe pressure loss at min. one tyre approx.
03030 TPM 200 mbar/h
CAN data bus retarder check from vehicle management
computer engine brake torque 'ERC1_ REX retarder percent
03031 AST torque'
03031 EBS Faulty retarder relay output stage checkback
03031 EDC6 FFR2: nominal idling speed governing value too high
03031 EDC7 FFR2: nominal idling speed governing value too high
03031 EHLA Pressure build-up in pressure accumulator too short
SD 812a en-online 05.2007 Page 160 of 276
SPN Control unit/System Fault message
03031 HDS AdBlue tank temperature
Adjustment lever angle reduction input (throttle butterfly
03031 KSM reduction request)
03031 SFFR Engine CAN: Time overrun when receiving EDC message EDC5
03031 TPM Pressure in left outer tyre, axle 3
CAN data bus engine brake configuration, 'engine retarder
03032 AST configuration'
03032 EBS Faulty brake pad wear output stage checkback
03032 EDC6 FFR2: Bit error, stand alone request
03032 EDC7 FFR2: Bit error, stand alone request
03032 EHLA Centring circuit warning
Signal frequency at adjustment lever angle reduction input
03032 KSM (throttle butterfly reduction request)
Engine CAN: Time overrun when receiving EDC message
03032 SFFR EngineConfig
03032 TPM Pressure in left inner tyre, axle 3
CAN data bus engine brake configuration, 'engine retarder
03033 AST configuration'
03033 EBS Invalid checkback signal for the yellow warning light
03033 EDC6 FFR2: Bit error, start request
03033 EDC7 FFR2: Bit error, start request
03033 EHLA Centring circuit
CAN data bus: Time overrun when receiving body CAN
03033 KSM message KSM2_A.
MMDS CAN: Time overrun when receiving MMDS message
03033 SFFR TSC1-FME.
03033 TPM Pressure in right inner tyre, axle 3
03034 EBS Invalid checkback signal for the red warning light
03034 EDC6 FFR2: Bit error, engine stop request
03034 EDC7 FFR2: Bit error, engine stop request
03098 EBS_K1 CAN data bus driveline, 'Steering axle status' in message ESC1
03098 EDC6 Control path: Loose contact
03098 EDC7 Control path: Loose contact
03098 EHLA System deviation on steering axle 3
CAN databus: Time overrun when receiving message
03098 FFR ERC1_RE.
03098 ZH_AT3500_ST Incorrect application / impermissible air blockage
03099 AST Output speed 1
03099 EBS No valid fault definition
CAN data bus driveline, 'Percentage clutch slip' in message
03099 EBS_K1 ETC1
03099 EDC6 Fuel pressure sensor
03099 EDC7 Fuel pressure sensor (rail pressure)
03099 EHLA Large system deviation on steering axle 3
CAN data bus: Time overrun when receiving ECAM message
03099 FFR ECAM1.
03099 ZH_AT3500_ST Incorrect overheating sensor position (OHS degree too low)
03100 BHTC Main pump
03100 CRT Exhaust differential pressure via the CRT filter
03100 EBS Pressure control module, left front axle, no fault
03100 EDC6 Fuel supply pressure sensor
03100 EDC7 Fuel supply pressure sensor
03100 EHLA Inverse movement on steering axle 4
03100 FFR CAN data bus: EDC message EDC1, byte 1
03100 ZH_AT3500_ST Heater interlock
03101 AST Output speeds 1+ 2
03101 CRT Exhaust temperature in front of the CRT filter
Pressure control module, left front axle, interruption, short-circuit
03101 EBS wheel sensor A
03101 EBS_K1 (!) Wheel sensor left front axle
03101 ECAS_4X2 Travel sensor left REAR AXLE
03101 ECAS2_GBV Height sensor FRONT AXLE left
03101 EHLA System deviation on steering axle 4
03101 EMOS Gearbox output signal
03101 FFR CAN data bus: EDC message EDC1, byte 2
03101 ZH_AT3500_ST Heater interlock permanent
03102 AST Gearbox input and output speeds
03102 CNG_ME7 Exhaust gas recirculation valve output stage
03102 CRT Current engine torque
SD 812a en-online 05.2007 Page 171 of 276
SPN Control unit/System Fault message
Pressure control module, left front axle, wheel sensor A: Delay
03102 EBS too long
03102 ECAS_4X2 Travel sensor right REAR AXLE
03102 ECAS2_GBV Height sensor, FRONT AXLE right
03102 EDC6 Exhaust gas recirculation system output stage
03102 EDC7 Exhaust gas recirculation system output stage
03102 EHLA Large system deviation on steering axle 4
03102 FFR CAN data bus: EDC message EDC1, byte 3
03102 ZBR2 ZBR power supply
03102 ZH_D5W_SC Burner motor EMK outside permitted range
03103 AST CAN data bus vehicle speed from EDC
03103 CNG_ME7 Lambda probe before catalytic converter (bank 1)
03103 CRT Status of the regeneration logic
Pressure control module, left front axle, wheel sensor A: Moving
03103 EBS off fault
03103 ECAS_4X2 Travel sensor FRONT AXLE
03103 ECAS2_GBV CENTRE AXLE height sensor
03103 EHLA Calibration mode when vehicle moving
03103 FFR CAN data bus: EDC message EDC1, bytes 4 and 5
03103 OBDU Tension V-belt
03103 ZBR2 Analog ground
03103 ZH_D5W_SC Burner motor interruption
03104 CNG_ME7 Lambda probe heating before catalytic converter (bank 1)
Pressure control module, left front axle, wheel sensor A:
03104 EBS Clearance too great
03104 ECAS_4X2 Travel sensor, front axle
03104 EHLA Calibration data steering axle 1
03104 FFR CAN data bus: EDC message EDC1, bytes 6 and 7
03104 HYD Burner motor stage 1 does not turn (low)
03104 ZBR2 Analog ground
03104 ZH_D5W_SC Burner motor short circuit
03105 CNG_ME7 Lambda control adaptation multi (bank 1)
Pressure control module, left front axle, perpetual control wheel
03105 EBS sensor A
03105 EHLA Calibration data steering axle 2
03105 FFR CAN data bus: EDC message EDC1, byte 8
03105 HYD Burner motor stage 2 does not turn (high)
03105 OBDU Water pump V-belt torn
03105 ZHZG_9c Burner motor not turning
03106 CNG_ME7 Idling speed control, nominal speed
Pressure control module, left front axle, long instability wheel
03106 EBS sensor A
03106 EHLA Calibration data steering axle 3
03106 FFR CAN data bus: EDC message EDC2, bytes 1 and 2
03106 OBDU Cooling defective: Water temperature gradient too steep
03107 AST Voltage (clutch sensor)
03107 CNG_ME7 Total exhaust-relevant errors (ASE)
Pressure control module, left front axle, pulse ring fault wheel
03107 EBS sensor A
03107 EBS_K1 (!) Impulse wheel fault left front axle
03107 EHLA Calibration data steering axle 4
03107 FFR CAN data bus: EDC message EDC2, bytes 3 and 4
03107 ZBR2 Ignition ON (relay tl. 15)
03108 CNG_ME7 Gas system pressure
Pressure control module, left front axle, fault on lifting axle wheel
03108 EBS sensor A
03108 EHLA Calibration data front axle
03108 FFR CAN data bus: EDC message EDC2, bytes 5 and 6
03108 ZBR2 Electrical battery master switch/parking brake sensor
03109 EBS Pressure control module, left front axle, no valid fault definition
03109 EBS_K1 (!) Brake/impulse wheel/sensor combination left front axle
03109 EHLA Calibration data joystick
03109 FFR CAN data bus: EDC message EDC2, bytes 7 and 8
03109 HYD Water pump malfunction or fuse blown
03109 ZBRO Ignition lock radio position
03110 BHTC Recirculating pump
03110 CNG_ME7 Engine speed sensor crankshaft toothed disc
03110 EBS Pressure control module, left front axle, no valid fault definition
03110 EHLA Number of CAN objects
03110 FFR CAN data bus: EDC message EDC3, bytes 1 and 2
03110 HYD Vehicle blower control discontinuity
03110 ZBRO Ignition lock ignition on
03110 ZH_D5W_SC Vehicle blower relay interruption
CAN data bus message timeout time/date information from
03111 AST central on-board computer ZBR2, TIME/DATE
03111 CNG_ME7 Reference mark sensor
Pressure control module, left front axle, interruption, short-circuit
03111 EBS wheel sensor B
03111 EHLA CAN bus off
03111 EMOS Timeout of Time_Date message
03111 FFR CAN data bus: EDC message EDC3, bytes 3 and 4
03111 HYD Vehicle blower control short circuit
03111 TPM Slight leakage from left outer tyre, axle 1
03111 ZBR2 Ignition lock starter tl. 50
03111 ZH_D5W_SC Vehicle blower relay short-circuit
CAN data bus signal error time/date information from central on-
03112 AST board computer ZBR2, TIME/DATE
03112 CNG_ME7 Phase sensor
Pressure control module, left front axle, wheel sensor B: Delay
03112 EBS too long
03112 EHLA CAN data has been falsified
03112 FFR CAN data bus: EDC message EDC3, byte 5
03112 TPM Slight leakage from left inner tyre, axle 1
03112 ZBRO Ignition lock ignition off
CAN data bus message timeout retarder configuration,
03113 AST Ret_Conf (driveline retarder configuration)
Pressure control module, left front axle, wheel sensor B: Moving
03113 EBS off fault
03113 EHLA CAN bus off
03113 FFR CAN data bus: EDC message EDC3, byte 6
03113 TPM Slight leakage from right inner tyre, axle 1
03113 ZBRO Battery undervoltage
03113 ZH_D5W_SC Water pump interruption
Pressure control module, left front axle, wheel sensor B:
03114 EBS Clearance too great
03114 EHLA Steering wheel sensor - not used
03114 FFR CAN data bus: EDC message EDC3, byte 7
03114 TPM Slight leakage from right outer tyre, axle 1
03114 ZBRO Battery master switch
03114 ZH_D5W_SC Water pump short-circuit
Pressure control module, left front axle, perpetual control wheel
03115 EBS sensor B
03115 EHLA Steering wheel sensor - operating
03115 FFR CAN data bus: EDC message EDC3, byte 8
03115 ZBRO Battery main relay
Pressure control module, left front axle, long instability wheel
03116 EBS sensor B
SD 812a en-online 05.2007 Page 173 of 276
SPN Control unit/System Fault message
03116 FFR CAN data bus: EDC message EDC4, byte 1
03116 HYD Water pump relay coil discontinuity
03116 ZBRO Ignition on
03117 AST Clutch self-adjustment faulty
Pressure control module, left front axle, pulse ring fault wheel
03117 EBS sensor B
03117 FFR CAN data bus: EDC message EDC4, byte 2
03117 HYD Water pump relay coil short circuit
03117 ZBRO Ignition on
03118 AST Clutch does not open
Pressure control module, left front axle, fault on lifting axle wheel
03118 EBS sensor B
Clutch regulator switched on but no clutch opening valve
03118 EMOS available for opening clutch
03118 FFR CAN data bus: EDC message EDC4, byte 3
03118 HYD Solenoid valve discontinuity
03118 ZBRO Ignition on check
03119 AST Clutch does not close / does not transmit torque
03119 CNG_ME7 Altitude sensor
03119 EBS Pressure control module, left front axle, no valid fault definition
Clutch regulator switched on but no clutch closing valve
03119 EMOS available for closing clutch
03119 FFR CAN data bus: EDC message EDC4, byte 4
03119 HYD Solenoid valve short circuit
03119 ZBRO Battery master switch 1
03119 ZH_D5W_SC Metering pump short-circuit
03119 ZHZG_9c Metering pump short-circuit or overload
03120 AST Mechanical fault (small valve for opening the clutch)
03120 BHTC LIN bus
Pressure control module, left front axle, electrical power supply
03120 EBS fault, pad wear sensor
Electrical power supply pad wear sensor (front axle left or front
03120 EBS_K1 axle)
03120 EHLA Joystick
03120 FFR CAN data bus: EDC message EDC4, bytes 5 and 6
03120 HYD Jet carrier preheater relay coil discontinuity
03120 ZBRO Battery master switch 3
03120 ZH_D5W_SC Metering pump interruption
03120 ZHZG_9c Metering pump interruption
03121 AST Mechanical fault (small valve for closing the clutch)
03121 CNG_ME7 Ignition output stage cylinder 1
Pressure control module, left front axle, pad wear sensor A
03121 EBS outside permitted value range
03121 EBS_K1 Pad wear sensor A (front axle left) outside valid range
03121 EHLA Joystick both sides
03121 FFR CAN data bus: EDC message EDC4, byte 7
03121 HYD Jet carrier preheater relay coil short circuit
03121 TPM Slight leakage from left outer tyre, axle 2
03121 ZBRO Battery master switch 4
03122 AST Mechanical fault (large valve for opening the clutch)
03122 CNG_ME7 Ignition output stage cylinder 2
Pressure control module, left front axle, pad wear sensor B
03122 EBS outside permitted value range
03122 EHLA Joystick, sustained operation
03122 FFR CAN data bus: EDC message EDC4, byte 8
03122 HYD Too many unsuccessful start attempts
03122 TPM Slight leakage from left inner tyre, axle 2
03122 ZBRO Starting assistance
03122 ZH_D5W_SC Operation interlock safety time 1
SD 812a en-online 05.2007 Page 174 of 276
SPN Control unit/System Fault message
03122 ZHZG_9c Too many unsuccessful start attempts
03123 AST Mechanical fault (large valve for closing the clutch)
03123 CNG_ME7 Ignition output stage cylinder 3
Pressure control module, left front axle, pressure sensor outside
03123 EBS permitted value range
(!) Pressure sensor (left front axle or front axle) outside valid
03123 EBS_K1 range
03123 FFR CAN data bus: EDC message EDC5, byte 1
03123 HYD Flame sensor: 'Flame before fuel'
03123 TPM Slight leakage from right inner tyre, axle 2
03123 ZBRO Starting assistance check
03123 ZH_D5W_SC Cold blowing time exceeded
03123 ZHZG_9c Flame present during switch-on
03124 AST Clutch travel fault
03124 CNG_ME7 Ignition output stage cylinder 4
Pressure control module, left front axle, time for 'Current
03124 EBS pressure' inquiry too long
03124 EHLA Configuration of axle count
03124 EMOS Clutch travel sensor signal
03124 FFR CAN data bus: EDC message EDC5, byte 2
03124 HYD No start – safety time exceeded
03124 TPM Slight leakage from right outer tyre, axle 2
03124 ZBRO Ignition on switched off
03124 ZH_D5W_SC Safety time exceeded
03124 ZHZG_9c No start – safety time exceeded
03125 AST Pressure limiting valve fault
03125 CNG_ME7 Ignition output stage cylinder 5
03125 EBS Pressure control module, left front axle, poor ventilation
03125 EHLA Locking monitoring steering axle 1
03125 FFR CAN data bus: EDC message EDC5, bytes 3 and 4
03125 ZHZG_9c Flame failure from start power
03126 AST Pressure signal faulty
03126 CNG_ME7 Ignition output stage cylinder 6
Pressure control module, left front axle, excessive pressure
03126 EBS during pulse test
03126 EHLA Steering axle 1 has moved out of locking position
03126 FFR CAN data bus: EDC message EDC5, byte 5
03126 HYD too many flame cut-outs / time
03126 ZH_D5W_SC Flame failure from governor stage 'HIGH'
03126 ZHZG_9c Flame failure from high power
03127 AST ECU temperature fault
Pressure control module, left front axle, residual pressure after
03127 EBS braking
03127 EHLA Locking monitoring steering axle 2
03127 EMOS 'Temperature sensor next to processor' signal
03127 FFR CAN data bus: EDC message EDC5, bytes 6 and 7
03127 ZHZG_9c Flame failure from medium power
03128 AST Oil temperature signal fault
Pressure control module, left front axle, pressure sensor fault
03128 EBS without braking
03128 EHLA Steering axle 2 has moved out of locking position
03128 FFR CAN data bus: EDC message EDC5, byte 8
03128 ZH_D5W_SC Flame failure from governor stage 'LOW'
03128 ZHZG_9c Flame failure from low power
03129 AST No signal from shift transmitter main gearbox
03129 EBS Pressure control module, left front axle, no valid fault definition
03129 EHLA Locking monitoring steering axle 3
CAN data bus: EDC message engine configuration, bytes 0 and
03129 FFR 1
SD 812a en-online 05.2007 Page 175 of 276
SPN Control unit/System Fault message
03130 BHTC Refrigerant pressure
Pressure control module, left front axle, wheel sensor IC
03130 EBS defective
03130 EHLA Steering axle 3 has moved out of locking position
03130 FFR CAN data bus: EDC message engine configuration, byte 2
03130 HYD Flame not extinguished in post-operation
Pressure control module, left front axle, faulty backup valve
03131 EBS checkback
03131 EBS_K1 Backup valve checkback (front axle left or front axle)
03131 EHLA Locking monitoring steering axle 4
CAN data bus: EDC message engine configuration, bytes 3 and
03131 FFR 4
03131 TPM Slight leakage from left outer tyre, axle 3
03132 AST Shift transmitter self-adjustment fault
Pressure control module, left front axle, faulty intake valve
03132 EBS checkback
03132 EBS_K1 Intake valve checkback (ABS valve front axle left)
03132 EHLA Steering axle 4 has moved out of locking position
03132 FFR CAN data bus: EDC message engine configuration, byte 5
03132 HYD Temperature governor sensor discontinuity
03132 TPM Slight leakage from left inner tyre, axle 3
03132 ZH_D5W_SC Interruption governor sensor
03132 ZHZG_9c External temperature governor sensor interruption
03133 AST Gate selection transmitter signal
Pressure control module, left front axle, faulty intake and backup
03133 EBS valve checkback
03133 EHLA Actuator test steering axle 1
CAN data bus: EDC message engine configuration, bytes 6 and
03133 FFR 7
03133 HYD Temperature governor sensor short circuit
03133 TPM Slight leakage from right inner tyre, axle 3
03133 ZH_D5W_SC Short-circuit governor sensor
03133 ZHZG_9c External temperature governor sensor short-circuit
Pressure control module, left front axle, faulty outlet valve
03134 EBS checkback
03134 EBS_K1 Exhaust valve checkback (ABS valve front axle left)
03134 EHLA Actuator test steering axle 2
03134 FFR CAN data bus: EDC message engine configuration, byte 8
03134 TPM Slight leakage from right outer tyre, axle 3
03134 ZHZG_9c Setpoint sensor interruption
Pressure control module, left front axle, faulty outlet and backup
03135 EBS valve checkback
03135 EHLA Actuator test steering axle 3
CAN data bus: EDC message engine configuration, bytes 9 and
03135 FFR 10
03135 ZHZG_9c Setpoint sensor short-circuit
03136 AST Teach-in fault, gate selection transmitter signal
Pressure control module, left front axle, faulty outlet and intake
03136 EBS valve checkback
03136 EBS_K1 Exhaust and intake valve checkback (ABS valve front axle left)
03136 EHLA Actuator test steering axle 4
03136 FFR CAN data bus: EDC message engine configuration, byte 11
03136 ZH_D5W_SC Interruption flame sensor
03136 ZHZG_9c Flame sensor interruption
03137 AST Range-change group travel sensor signal
Pressure control module, left front axle, faulty outlet and intake
03137 EBS and backup valve checkback
03137 EHLA Digital input parameters
03138 EBS Pressure control module, left front axle, no valid fault definition
03138 EBS_K1 Proportional valve (front axle left or front axle)
03138 EHLA Digital input parameters
03138 FFR CAN data bus: EDC message engine configuration, byte 14
03139 EBS Pressure control module, left front axle, no valid fault definition
03139 EBS_K1 ABS valves (front axle)
03139 EHLA Analog inputs
CAN data bus: EDC message engine configuration, bytes 15
03139 FFR and 16
03140 AST Teach-in fault, range-change group travel sensor
03140 BHTC Calibration
Pressure control module, left front axle, no CAN reception from
03140 EBS module
CAN data bus: EDC message engine configuration, bytes 17
03140 FFR and 18
03141 AST No travel sensor signal from splitter
03149 EBS Pressure control module, left front axle, no valid fault definition
03149 EBS_K1 (!) Pneumatic redundant path front axle
03149 EHLA Prop. valve steering axle 3, deviation
03150 AST Splitter group does not engage
03150 BHTC Different variant control unit control element
03150 EBS Pressure control module, right front axle, no fault
03150 EHLA Prop. valve steering axle 4, incorrect movement direction
03150 FFR CAN data bus: EBS message EBC1, byte 1
03151 AST Selector cylinder does not open
Pressure control module, right front axle, interruption, short-
03151 EBS circuit wheel sensor A
03151 EBS_K1 (!) Wheel sensor right front axle
03151 ECAS_4X2 Pressure sensor left REAR AXLE
03151 ECAS2_GBV Pressure sensor FRONT AXLE left
03151 EHLA Prop. valve steering axle 4, deviation
03151 FFR CAN data bus: EBS message EBC1, byte 2
03151 TPM Slight leakage from left outer tyre, axle 5
03152 AST Gate shift fault
Pressure control module, right front axle, wheel sensor A: Delay
03152 EBS too long
03152 ECAS_4X2 Pressure sensor right REAR AXLE
03152 ECAS2_GBV Pressure sensor FRONT AXLE right
03152 FFR CAN data bus: EBS message EBC1, byte 3
03152 HYD Combustion display discontinuity
03152 TPM Slight leakage from left inner tyre, axle 5
03153 AST Selector cylinder does not close
Pressure control module, right front axle, wheel sensor A:
03153 EBS Moving off fault
03153 ECAS_4X2 Pressure sensor FRONT AXLE
03153 ECAS2_GBV Pressure sensor CENTRE AXLE
03153 FFR CAN data bus: EBS message EBC1, byte 4
03153 HYD Combustion display short circuit
03153 TPM Slight leakage from right inner tyre, axle 5
03154 AST Main gearbox gear does not disengage
Pressure control module, right front axle, wheel sensor A:
03154 EBS Clearance too great
03154 ECAS_4X2 Pressure sensor front axle
03154 FFR CAN data bus: EBS message EBC1, byte 5
03154 HYD Malfunction display discontinuity
SD 812a en-online 05.2007 Page 178 of 276
SPN Control unit/System Fault message
03154 TPM Slight leakage from right outer tyre, axle 5
03155 AST Main gearbox gear does not engage
Pressure control module, right front axle, perpetual control wheel
03155 EBS sensor A
03155 ECAS_4X2 Pressure sensor 2nd right REAR AXLE
03155 FFR CAN data bus: EBS message EBC2, bytes 1 and 2
03155 HYD Malfunction display short circuit
03156 AST Wrong gear selected in main gearbox
Pressure control module, right front axle, long instability wheel
03156 EBS sensor A
03156 ECAS_4X2 Pressure sensor 2nd left REAR AXLE
03156 FFR CAN data bus: EBS message EBC2, byte 3
Pressure control module, right front axle, pulse ring fault wheel
03157 EBS sensor A
03157 EBS_K1 (!) Impulse wheel fault right front axle
03157 ECAS_4X2 Pressure sensor, brake
03157 ECAS2_GBV Pressure sensor, brake
03157 FFR CAN data bus: EBS message EBC2, byte 4
03158 AST Shift sensor signal continuously active
Pressure control module, right front axle, fault on lifting axle
03158 EBS wheel sensor A
03158 ECAS_4X2 Pressure sensor lifting axle
03158 ECAS2_GBV Pressure sensor lifting axle
03158 FFR CAN data bus: EBS message EBC2, byte 5
03159 AST Range-change group shift sensor signal continuously active
03159 EBS Pressure control module, right front axle, no valid fault definition
03159 EBS_K1 (!) Brake/impulse wheel/sensor combination right front axle
03159 FFR CAN data bus: EBS message EBC2, byte 6
03160 AST Splitter shift sensor signal continuously active
03160 BHTC Control element tl30 voltage
03160 EBS Pressure control module, right front axle, no valid fault definition
03160 FFR CAN data bus: EBS message EBC2, byte 7
Pressure control module, right front axle, interruption, short-
03161 EBS circuit wheel sensor B
03161 EHLA Recirculating/centring valve
03161 FFR CAN data bus: EBS message EBC2, byte 8
Pressure control module, right front axle, wheel sensor B: Delay
03162 EBS too long
03162 EHLA Digital output 2
03162 FFR CAN data bus: EBS message EBC3, byte 0
03163 AST Engine does not react to torque specification
Pressure control module, right front axle, wheel sensor B:
03163 EBS Moving off fault
03163 EHLA Digital output 3
03163 FFR CAN data bus: EBS message EBC3, byte 1
03163 HYD Control unit reset
CAN data bus electronic engine governor 1 from EDC, EEC1
(accelerator pedal position, drivers demand engine percent
03164 AST torque)
Pressure control module, right front axle, wheel sensor B:
03164 EBS Clearance too great
03164 EHLA Digital output 4
03164 FFR CAN data bus: EBS message EBC3, byte 2
03164 HYD Control unit failure (ROM fault)
03164 ZH_D5W_SC ROM fault
03164 ZHZG_9c Control unit failure (ROM fault)
Pressure control module, right front axle, perpetual control wheel
03165 EBS sensor B
SD 812a en-online 05.2007 Page 179 of 276
SPN Control unit/System Fault message
03165 EHLA Digital output 5
03165 FFR CAN data bus: EBS message EBC3, byte 3
03165 HYD Control unit failure (RAM fault)
03165 ZH_D5W_SC RAM fault
03165 ZHZG_9c Control unit failure (RAM fault)
03166 AST Permanent idling speed signal
Pressure control module, right front axle, long instability wheel
03166 EBS sensor B
03166 EHLA Digital output 6
03166 FFR CAN data bus: EBS message EBC3, byte 4
03166 HYD Control unit failure (EEPROM fault)
03166 ZHZG_9c Control unit failure (EEPROM fault)
Pressure control module, right front axle, pulse ring fault wheel
03167 EBS sensor A
03167 EHLA Digital output 7
03167 FFR CAN data bus: EBS message EBC3, byte 5
Pressure control module, right front axle, fault on lifting axle
03168 EBS wheel sensor B
03168 EHLA Digital output 8
03168 FFR CAN data bus: EBS message EBC3, byte 6
03168 ZHZG_9c Internal temperature governor sensor defective
03169 AST Shut-off relay in ECU does not switch off
03169 EBS Pressure control module, right front axle, no valid fault definition
03169 EHLA Digital output 9
03169 FFR CAN data bus: EBS message EBC3, byte 7
03169 HYD Control unit: general fault
No electrical power supply at terminal 30 or shut-off relay in ECU
03170 AST does not switch on
Pressure control module, right front axle, electrical power supply
03170 EBS fault, pad wear sensor
03170 ECAS_4X2 Steering angle sensor
03170 ECAS2_GBV Steering angle sensor
03170 EHLA Digital output 10
03170 FFR CAN data bus: EBS message EBC4, byte 1
CAN data bus electronic engine governor 1 from EDC, EEC1
03171 AST (engine torque, actual engine percent torque)
03171 CNG_ME7 Charge pressure control valve
Pressure control module, right front axle, pad wear sensor A
03171 EBS outside permitted value range
03171 EBS_K1 Pad wear sensor A (front axle right) outside valid range
03171 EDC6 Boost pressure switch output stage
03171 EDC7 Boost pressure switch output stage
03171 EHLA Digital output 11
03171 FFR CAN data bus: EBS message EBC4, byte 2
03171 ZH_D5W_SC EEPROM checksum error
03171 ZHZG_9c GK output stage transistor failed
Pressure control module, right front axle, pad wear sensor B
03172 EBS outside permitted value range
03172 EHLA Digital output 12
03172 FFR CAN data bus: EBS message EBC4, byte 3
03172 ZH_D5W_SC EEPROM timeout error
Pressure control module, right front axle, pressure sensor
03173 EBS outside permitted value range
03173 EHLA Digital output 13
03173 FFR CAN data bus: EBS message EBC4, byte 4
Pressure control module, right front axle, time for 'Current
03174 EBS pressure' inquiry too long
03174 EHLA Digital output 14
03174 FFR CAN data bus: EBS message EBC4, byte 5
SD 812a en-online 05.2007 Page 180 of 276
SPN Control unit/System Fault message
03175 AST Ignition lock signal fault (terminal 15)
03175 EBS Pressure control module, right front axle, poor ventilation
03175 EHLA Digital output 15
03175 EMOS Drop-out of ignition signal
03175 FFR CAN data bus: EBS message EBC4, byte 6
Pressure control module, right front axle, excessive pressure
03176 EBS during pulse test
03176 FFR CAN data bus: EBS message EBC4, byte 7
03177 AST CAN data bus driveline
Pressure control module, right front axle, residual pressure after
03177 EBS braking
03177 EMOS BUSOFF vehicle CAN
03177 FFR CAN data bus: EBS message EBC4, byte 8
03178 AST CAN data bus error warning
Pressure control module, right front axle, pressure sensor fault
03178 EBS without braking
03178 FFR CAN data bus: EBS message Veh_weight, byte 1
03179 AST CAN data bus input buffer overrun
03179 EBS Pressure control module, right front axle, no valid fault definition
03179 FFR CAN data bus: EBS message Veh_weight, bytes 2 and 3
03180 AST CAN data bus electronic engine governor 1 from EDC, EEC1
Pressure control module, right front axle, wheel sensor IC
03180 EBS defective
03180 EMOS Timeout of EEC1 message
03180 FFR CAN data bus: EBS message Veh_weight, byte 4
03181 AST CAN data bus electronic engine governor 2 from EDC, EEC2
Total exhaust-relevant errors (ASE) cylinder 1, damaging to
03181 CNG_ME7 catalytic converter
Pressure control module, right front axle, faulty backup valve
03181 EBS checkback
03181 EHLA CAN signal 'Position Of Doors'
03181 EMOS Timeout of EEC2 message
03181 FFR CAN data bus: Retarder message RET_Conf, byte 1
03182 AST CAN data bus cruise control/speed from EDC, CCVS
Total exhaust-relevant errors (ASE) cylinder 2, damaging to
03182 CNG_ME7 catalytic converter
Pressure control module, right front axle, faulty intake valve
03182 EBS checkback
03182 EBS_K1 Intake valve checkback (ABS valve front axle right)
03182 EHLA CAN signal 'Seconds' in 'Time/Date' message
03182 EMOS Timeout CcVeh speed message
03182 FFR CAN data bus: Retarder message RET_Conf, byte 2
CAN data bus engine brake from vehicle management
03183 AST computer, ERC1_REX
Total exhaust-relevant errors (ASE) cylinder 3, damaging to
03183 CNG_ME7 catalytic converter
Pressure control module, right front axle, faulty intake and
03183 EBS backup valve checkback
03183 EHLA CAN signal 'Minutes' in 'Time/Date' message
03183 FFR CAN data bus: Retarder message RET_Conf, bytes 3 and 4
03184 AST CAN data bus retarder from secondary retarder, ERC1_RD
Total exhaust-relevant errors (ASE) cylinder 4, damaging to
03184 CNG_ME7 catalytic converter
Pressure control module, right front axle, faulty outlet valve
03184 EBS checkback
03184 EBS_K1 Exhaust valve checkback (ABS valve front axle right)
03184 EHLA CAN signal 'Hours' in 'Time/Date' message
03184 FFR CAN data bus: Retarder message RET_Conf, byte 5
03185 AST CAN data bus primary retarder WSK, ERC1_RE
SD 812a en-online 05.2007 Page 181 of 276
SPN Control unit/System Fault message
Total exhaust-relevant errors (ASE) cylinder 5, damaging to
03185 CNG_ME7 catalytic converter
Pressure control module, right front axle, faulty outlet and
03185 EBS backup valve checkback
03185 EHLA CAN signal 'Day' in 'Time/Date' message
03185 FFR CAN data bus: Retarder message RET_Conf, bytes 6 and 7
03186 AST CAN data bus primary retarder WSK, ERC1_WSK
Total exhaust-relevant errors (ASE) cylinder 6, damaging to
03186 CNG_ME7 catalytic converter
Pressure control module, right front axle, faulty outlet and intake
03186 EBS valve checkback
03186 EBS_K1 Exhaust and intake valve checkback (ABS valve front axle right)
03186 EHLA CAN signal 'Month' in 'Time/Date' message
03186 FFR CAN data bus: Retarder message RET_Conf, byte 8
03187 AST CAN data bus primary retarder configuration information
Total exhaust-relevant errors (ASE), total, damaging to catalytic
03187 CNG_ME7 converter
Pressure control module, right front axle, faulty outlet and intake
03187 EBS and backup valve checkback
03187 EHLA CAN signal 'Year' in 'Time/Date' message
03187 FFR CAN data bus: Retarder message RET_Conf, bytes 9 and 10
03188 AST Control unit fault, incorrect interrupt
03188 CNG_ME7 Input parameters filling acquisition
03188 EBS Pressure control module, right front axle, no valid fault definition
03188 EHLA CAN signal 'Engine Speed'
03188 FFR CAN data bus: Retarder message RET_Conf, byte 11
03189 AST Control unit fault, stack watch
03189 EBS Pressure control module, right front axle, no valid fault definition
03189 EHLA CAN signal 'Front Axle Speed'
03189 FFR CAN data bus: Retarder message RET_Conf, bytes 12 and 13
03190 AST EOL EEPROM parameter outside valid range
Pressure control module, right front axle, no CAN reception from
03190 EBS module
03190 EHLA CAN signal 'Tachograph Vehicle Speed'
03190 FFR CAN data bus: Retarder message RET_Conf, byte 14
03191 AST EOL EEPROM: checksum error
03191 FFR CAN data bus: Retarder message RET_Conf, bytes 15 and 16
03192 AST Control unit fault – EEPROM access fault
03192 FFR CAN data bus: Retarder message RET_Conf, bytes 17 and 18
03193 AST ECU temperature too high
Pressure control module, right front axle, high cycle protection
03193 EBS intake valve active, pressure < 4 bar
03193 EHLA CAN signal 'Transmission Current Gear'
03193 EMOS Permitted temperature limit value exceeded
03193 FFR CAN data bus: Retarder message RET_Conf, byte 19
SD 812a en-online 05.2007 Page 182 of 276
SPN Control unit/System Fault message
03194 AST Failure of both signal sources for front axle speed
Pressure control module, right front axle, arithmetic test not
03194 EBS successful
03194 EHLA CAN signal 'ASR Engine Control Active Passive'
03194 FFR CAN data bus: Retarder message ERC1_RD, byte 1
Pressure control module, right front axle, wheel compensation
03195 EBS fault wheel sensor A
03195 EHLA CAN signal 'ASR Brake Control Active Passive'
03195 FFR CAN data bus: Retarder message ERC1_RD, byte 2
CAN data bus vehicle mileage from central on-board computer
03196 AST ZBR2, Veh_Dist
Pressure control module, right front axle, wheel compensation
03196 EBS fault wheel sensor B
03196 EHLA CAN signal 'Anti-Lock Braking (ABS) Active'
03196 EMOS Timeout of Veh_Dist message
03196 FFR CAN data bus: Retarder message ERC1_RD, byte 3
Pressure control module, right front axle, electrical power supply
03197 EBS fault, axle load sensor
03197 EHLA CAN signal 'Reverse engaged'
03197 FFR CAN data bus: Astronic message ETC1, byte 1
CAN data bus relative wheel speed from EBS, EBC2 (WSI)
03198 AST (relative wheel speed)
Pressure control module, right front axle, pressure differential on
03198 EBS pressure control module pair, front axle
03198 FFR CAN data bus: Astronic message ETC1, bytes 2 and 3
03199 AST CAN data bus wheel speed information from EBS, EBC2 (WSI)
03199 EBS Pressure control module, right front axle, no valid fault definition
03199 EMOS Timeout of EBC2 message
03199 FFR CAN data bus: Astronic message ETC1, byte 4
03200 EBS Pressure control module, left rear axle, no fault
03200 ECAS_4X2 Supply voltage / feedback, solenoid valves
03200 ECAS2_GBV Supply voltage / feedback, solenoid valves
03200 FFR CAN data bus: Astronic message ETC1, byte 5
Pressure control module, left rear axle, interruption, short-circuit
03201 EBS wheel sensor A
03201 EBS_K1 (!) Wheel sensor left rear axle
03201 ECAS_4X2 Solenoid valve 2/2 left REAR AXLE
03201 ECAS2_GBV Solenoid valve 2/2 FRONT AXLE left
03201 EHLA Valve output 1
03201 FFR CAN data bus: Astronic message ETC1, bytes 6 and 7
03201 OBDU Charge air pressure
03201 ZBR2 Low pressure in air filter
Pressure control module, left rear axle, wheel sensor A: Delay
03202 EBS too long
03202 ECAS_4X2 Solenoid valve 2/2 right REAR AXLE
03202 ECAS2_GBV Solenoid valve 2/2 FRONT AXLE right
03202 EHLA Valve output 2
03202 FFR CAN data bus: Astronic message ETC1, byte 8
Pressure control module, left rear axle, wheel sensor A: Moving
03203 EBS off fault
03203 ECAS_4X2 Solenoid valve 2/2 FRONT AXLE
03203 ECAS2_GBV Solenoid valve 2/2 CENTRE AXLE
03203 EHLA Valve output 3
03203 FFR CAN data bus: Astronic message ETC2, byte 1
03203 OBDU Leak in oil pump overflow valve
Pressure control module, left rear axle, wheel sensor A:
03204 EBS Clearance too great
03204 ECAS_4X2 Solenoid valve 3/3 lower/load lifting/trailing axle
SD 812a en-online 05.2007 Page 183 of 276
SPN Control unit/System Fault message
03204 ECAS2_GBV Solenoid valve 3/3 lower/load lifting/trailing axle
03204 EHLA Valve output 4
03204 FFR CAN data bus: Astronic message ETC2, bytes 2 and 3
03204 ZBRO EDC is active
Pressure control module, left rear axle, perpetual control wheel
03205 EBS sensor A
03205 ECAS_4X2 Solenoid valve 3/3 lift/unload lifting/trailing axle
03205 ECAS2_GBV Solenoid valve 3/3 lift/unload lifting/trailing axle
03205 EHLA Valve output 5
03205 FFR CAN data bus: Astronic message ETC2, byte 4
03205 ZBRO EDC brake lamp
Pressure control module, left rear axle, long instability wheel
03206 EBS sensor A
03206 ECAS_4X2 Solenoid valve 3/2 reservoir
03206 ECAS2_GBV Solenoid valve 3/2 reservoir
03206 EHLA Valve output 6
03206 FFR CAN data bus: Astronic message ETC2, byte 5
03206 ZBRO EDC overtravel relay
Pressure control module, left rear axle, pulse ring fault wheel
03207 EBS sensor A
03207 EBS_K1 (!) Impulse wheel fault left rear axle
03207 ECAS_4X2 Solenoid valve 3/3 lifting bellows
03207 ECAS2_GBV Solenoid valve 3/3 lifting bellows
03207 EHLA Valve output 7
03207 FFR CAN data bus: Astronic message ETC2, byte 6
03207 ZBRO EDC malfunction
Pressure control module, left rear axle, fault on lifting axle wheel
03208 EBS sensor A
03208 ECAS_4X2 Solenoid valve 2/2, 3rd AXLE RIGHT
03208 ECAS2_GBV Solenoid valve 2/2, 3rd AXLE RIGHT
03208 EHLA Valve output 8
03208 FFR CAN data bus: Astronic message ETC2, byte 7
03208 ZBRO EDC malfunction
03209 AST Emergency off button pressed or ECU de-energised
03209 EBS Pressure control module, left rear axle, no valid fault definition
03209 EBS_K1 (!) Brake/impulse wheel/sensor combination left rear axle
03209 ECAS_4X2 Solenoid valve 2/2, 3rd AXLE LEFT
03209 ECAS2_GBV Solenoid valve 2/2, 3rd AXLE LEFT
03209 FFR CAN data bus: Astronic message ETC2, byte 8
03209 ZBRO EDC ignition on
CAN data bus tachograph from central on-board computer
03210 AST ZBR2, TCO1
03210 EBS Pressure control module, left rear axle, no valid fault definition
03210 ECAS_4X2 Solenoid valve 2/2 FRONT AXLE
03210 EMOS Timeout of TCO1 message
CAN data bus: Central on-board computer message TCO1, byte
03210 FFR 1
03210 OBDU Air filter vacuum
CAN data bus gearbox check from vehicle management
03211 AST computer FFR, TC1_FT
03211 CNG_ME7 Knock sensor 2
Pressure control module, left rear axle, interruption, short-circuit
03211 EBS wheel sensor B
03211 EMOS Timeout of TC1_FT message
CAN data bus: Central on-board computer message TCO1, byte
03211 FFR 2
03211 KSM Oil pressure.
03211 OBDU Engine oil pressure too low
SD 812a en-online 05.2007 Page 184 of 276
SPN Control unit/System Fault message
03211 TPM Medium leakage from left outer tyre, axle 1
03211 ZBRO Engine oil pressure too low
CAN data bus gearbox check from vehicle management
03212 AST computer FFR, TC1_FT (requested gear)
Pressure control module, left rear axle, wheel sensor B: Delay
03212 EBS too long
03212 ECAS_4X2 Solenoid valve transverse throttle
03212 ECAS2_GBV Solenoid valve transverse throttle
CAN data bus: Central on-board computer message TCO1, byte
03212 FFR 3
03212 OBDU Oil pressure too high
03212 TPM Medium leakage from left inner tyre, axle 1
CAN data bus gearbox check from vehicle management
03213 AST computer FFR, TC1_FT (requested range)
Pressure control module, left rear axle, wheel sensor B: Moving
03213 EBS off fault
CAN data bus: Central on-board computer message TCO1, byte
03213 FFR 4
03213 TPM Medium leakage from right inner tyre, axle 1
CAN data bus gearbox check from vehicle management
03214 AST computer FFR, TC1_FT (PTO request)
Pressure control module, left rear axle, wheel sensor B:
03214 EBS Clearance too great
CAN data bus: Central on-board computer message TCO1,
03214 FFR bytes 5 and 6
03214 TPM Medium leakage from right outer tyre, axle 1
03214 ZBRO FFR malfunction
CAN data bus information from central on-board computer
03215 AST (aux_stat_zbr#1), timeout
Pressure control module, left rear axle, perpetual control wheel
03215 EBS sensor B
CAN data bus: Central on-board computer message TCO1,
03215 FFR bytes 7 and 8
03215 ZBRO FFR malfunction
Pressure control module, left rear axle, long instability wheel
03216 EBS sensor B
03216 ECAS_4X2 Solenoid valve 3/3, lift/unload 2nd lifting/trailing axle
03216 ECAS2_GBV Solenoid valve 3/3, lift/unload 2nd lifting/trailing axle
CAN data bus: Central on-board computer message VEH_DIST,
03216 FFR bytes 1 to 4
03216 ZBRO Accelerator pedal not pressed (T-CAN)
Pressure control module, left rear axle, pulse ring fault wheel
03217 EBS sensor B
03217 ECAS_4X2 Solenoid valve 3/3, lower/load 2nd lifting/trailing axle
03217 ECAS2_GBV Solenoid valve 3/3, lower/load 2nd lifting/trailing axle
CAN data bus: Central on-board computer message VEH_DIST,
03217 FFR bytes 5 to 8
03217 ZBRO Accelerator pedal pressed
Pressure control module, left rear axle, fault on lifting axle wheel
03218 EBS sensor B
CAN data bus: Central on-board computer message
03218 FFR TIME/DATE, byte 1
03218 ZBRO Accelerator pedal kickdown (T-CAN)
03219 EBS Pressure control module, left rear axle, no valid fault definition
CAN data bus: Central on-board computer message
03219 FFR TIME/DATE, byte 2
03219 ZBRO Accelerator pedal position (0...250)
03220 CNG_ME7 Knock control zero test
03229 EBS Pressure control module, left rear axle, no valid fault definition
03229 FFR CAN data bus: Retarder message RD_FLUIDS, byte 2
Pressure control module, left rear axle, wheel sensor IC
03230 EBS defective
03230 ECAS_4X2 Setpoint level control
03230 ECAS2_GBV Setpoint level control
03230 EHLA Signature ECU lids (LID 0x86-0x9F) - advance warning
03230 FFR CAN data bus: Retarder message RD_FLUIDS, byte 3
03231 CNG_ME7 Charge air pressure governing system
Pressure control module, left rear axle, faulty backup valve
03231 EBS checkback
03231 EBS_K1 Backup valve checkback (rear axle left or rear axle)
03231 ECAS_4X2 Leakage
03231 ECAS2_GBV Leakage
03231 EHLA Signature ECU lids (LID 0x86-0x9F) - error
03231 FFR CAN data bus: Astronic message TSC1_TE, byte 1
03231 TPM Medium leakage from left outer tyre, axle 3
03231 ZBRO Oil replenishment float switch
Pressure control module, left rear axle, faulty intake valve
03232 EBS checkback
Signature variable priority lids (LID 0x40-0x47) - advance
03232 EHLA warning
03232 FFR CAN data bus: Astronic message TSC1_TE, bytes 2 and 3
03232 TPM Medium leakage from left inner tyre, axle 3
03232 ZBRO Oil replenishment valve
Pressure control module, left rear axle, faulty intake and backup
03233 EBS valve checkback
03233 EHLA Signature variable priority lids (LID 0x40-0x47) - error
03233 FFR CAN data bus: Astronic message TSC1_TE, byte 4
03233 TPM Medium leakage from right inner tyre, axle 3
03233 ZBRO Engine oil level (T-CAN)
Pressure control module, left rear axle, faulty outlet valve
03234 EBS checkback
03234 FFR CAN data bus: Astronic message TSC1_TE, byte 5
03234 TPM Medium leakage from right outer tyre, axle 3
03234 ZBRO Economy circ. headl. (oil pressure+v<3)
Pressure control module, left rear axle, faulty outlet and backup
03235 EBS valve checkback
03235 FFR CAN data bus: EBS message TSC1_AE, byte 1
03235 ZBRO DeltecCNG malfunction
Pressure control module, left rear axle, faulty outlet and intake
03236 EBS valve checkback
03236 EBS_K1 Exhaust and intake valve checkback (rear axle left or rear axle)
03236 FFR CAN data bus: EBS message TSC1_AE, bytes 2 and 3
03236 ZBRO DeltecCNG malfunction
Pressure control module, left rear axle, faulty outlet and intake
03237 EBS and backup valve checkback
03237 FFR CAN data bus: EBS message TSC1_AE, byte 4
03237 ZBRO EMS3.3 malfunction
03238 EBS Pressure control module, left rear axle, no valid fault definition
03238 EHLA Air pressure switch
03238 FFR CAN data bus: EBS message TSC1_AE, byte 5
03238 ZBRO EMS3.3 malfunction
03239 EBS Pressure control module, left rear axle, no valid fault definition
03239 EHLA Actuator test when vehicle moving cancelled
03249 EBS Pressure control module, left rear axle, no valid fault definition
03249 EBS_K1 (!) Redundant pressure rear axle
03249 EHLA Second non-volatile memory, inconsistent
03249 ZBRO EDC malfunction (engine running)
03250 EBS Pressure control module, right rear axle, no fault
03250 EHLA Geometry parameters
03250 FFR Comfort Shift inputs (CS1 and CS2)
03250 ZBRO EDC malfunction (starting not possible)
Pressure control module, right rear axle, interruption, short-
03251 EBS circuit wheel sensor A
03251 EBS_K1 (!) Wheel sensor right rear axle
03251 EHLA Axle movement parameters
03251 FFR RSG/RSL switch
03251 TPM Medium leakage from left outer tyre, axle 5
03251 ZBRO Hydro fan oil level too low
Pressure control module, right rear axle, wheel sensor A: Delay
03252 EBS too long
03252 EHLA Steering reduction parameters
03252 FFR Splitter switch
03252 TPM Medium leakage from left inner tyre, axle 5
03252 ZBRO FFR check
Pressure control module, right rear axle, wheel sensor A:
03253 EBS Moving off fault
03253 EHLA Steering suppression parameters
03253 FFR Int. coupling
03253 TPM Medium leakage from right inner tyre, axle 5
03253 ZBRO FFR warning
Pressure control module, right rear axle, wheel sensor A:
03254 EBS Clearance too great
03254 EHLA Axle configuration parameters
03254 FFR Anf_EH
03254 TPM Medium leakage from right outer tyre, axle 5
03254 ZBRO Cool.w.lev.probe too low or probe n.c.
Pressure control module, right rear axle, perpetual control wheel
03255 EBS sensor A
03255 EHLA Internal monitoring of software runtime
03255 FFR Input ZDR1
03255 ZBRO Back pressure CRT filter too high
Pressure control module, right rear axle, long instability wheel
03256 EBS sensor A
03256 FFR Input ZDR2
Pressure control module, right rear axle, pulse ring fault wheel
03257 EBS sensor A
03257 EBS_K1 (!) Impulse wheel fault right rear axle
03257 FFR Input ZDR3
Pressure control module, right rear axle, fault on lifting axle
03258 EBS wheel sensor A
03258 FFR Input request power take-off 1
03259 EBS Pressure control module, right rear axle, no valid fault definition
03259 EBS_K1 (!) Brake/impulse wheel/sensor combination right rear axle
03259 FFR Input request power take-off 2
03260 EBS Pressure control module, right rear axle, no valid fault definition
03260 ECAS_4X2 Supply voltage / feedback, damper valve
03260 ECAS2_GBV Supply voltage / feedback, damper valve
03260 FFR Input ECO / Power
SD 812a en-online 05.2007 Page 189 of 276
SPN Control unit/System Fault message
Pressure control module, right rear axle, interruption, short-
03261 EBS circuit wheel sensor B
03261 ECAS_4X2 Damper valve, front axle
03261 EHLA Function computer, computer unit
03261 FFR Input checkback power take-off 1
Pressure control module, right rear axle, wheel sensor B: Delay
03262 EBS too long
03262 ECAS_4X2 Damper valve, 1st rear axle
03262 EHLA Function computer, computer unit
03262 FFR Input checkback power take-off 2
Pressure control module, right rear axle, wheel sensor B:
03263 EBS Moving off fault
03263 ECAS_4X2 Damper valve, 2nd rear axle
03263 EHLA Function computer, computer unit
03263 FFR Input gearbox neutral checkback
Pressure control module, right rear axle, wheel sensor B:
03264 EBS Clearance too great
03264 EHLA Function computer, computer unit
03264 FFR Input parking brake
Pressure control module, right rear axle, perpetual control wheel
03265 EBS sensor B
03265 EHLA Function computer, parameter area
03265 FFR Input checkback single H (does not exist)
Pressure control module, right rear axle, long instability wheel
03266 EBS sensor B
03266 EHLA Function computer, internal program memory
03266 FFR Input request engine start / tl. 50
Pressure control module, right rear axle, pulse ring fault wheel
03267 EBS sensor B
03267 EHLA Function computer, time measurement
03267 FFR Input request engine stop
Pressure control module, right rear axle, fault on lifting axle
03268 EBS wheel sensor B
03268 EHLA Function computer, monitoring modules
03269 EBS Pressure control module, right rear axle, no valid fault definition
03269 EHLA Function computer, monitoring modules
03269 FFR Plausibility message 'Start engine' – input request engine start
Pressure control module, right rear axle, electrical power supply
03270 EBS fault, pad wear sensor
03270 EHLA Function computer, monitoring modules
03270 FFR CAN message 'Start engine' although engine is running
Pressure control module, right rear axle, pad wear sensor A
03271 EBS outside permitted value range
03271 EBS_K1 Pad wear sensor A (rear axle right) outside valid range
03271 EHLA Function computer, monitoring modules
03271 FFR CAN message 'Start engine' although v > 0
Pressure control module, right rear axle, pad wear sensor B
03272 EBS outside permitted value range
03272 EBS_K1 Pad wear sensor B (rear axle right) outside valid range
03272 EHLA Function computer, monitoring modules
CAN message 'Start engine' although input gearbox neutral
03272 FFR open
Pressure control module, right rear axle, pressure sensor
03273 EBS outside permitted value range
03273 EHLA Function computer, monitoring modules
03273 FFR CAN message 'Stop engine' although still v > 0
Pressure control module, right rear axle, time for 'Current
03274 EBS pressure' inquiry too long
SD 812a en-online 05.2007 Page 190 of 276
SPN Control unit/System Fault message
03274 EHLA Function computer, monitoring modules
Gearbox input speed to gearbox output speed with gearbox in
03274 FFR neutral
03275 EBS Pressure control module, right rear axle, poor ventilation
03275 EHLA Function computer, monitoring modules
Pressure control module, right rear axle, excessive pressure
03276 EBS during pulse test
03276 EHLA Function computer, monitoring modules
Pressure control module, right rear axle, residual pressure after
03277 EBS braking
03277 EHLA Function computer, monitoring modules
03277 FFR No engine CAN
Pressure control module, right rear axle, pressure sensor fault
03278 EBS without braking
03278 EHLA Function computer, monitoring modules
03278 FFR Input speed
03279 EBS Pressure control module, right rear axle, no valid fault definition
03279 EHLA Function computer, safety switch
03279 FFR No speed signal (torque and engine speed limiting initiated)
Pressure control module, right rear axle, wheel sensor IC
03280 EBS defective
03280 EHLA Function computer, monitoring modules
03280 FFR Vehicle management computer cannot be switched off
Pressure control module, right rear axle, faulty backup valve
03281 EBS checkback
03281 EHLA Function computer: Digital output 1, switch-on test
03281 FFR Input request single H lever (group change switch)
Pressure control module, right rear axle, faulty intake valve
03282 EBS checkback
03282 EHLA Function computer, digital outputs 2 – 6, switch-on test
Pressure control module, right rear axle, faulty intake and
03283 EBS backup valve checkback
03283 EHLA Function computer, digital outputs 2 – 6, switch-on test
03283 FFR Gate switch gearbox
Pressure control module, right rear axle, faulty outlet valve
03284 EBS checkback
03284 EHLA Function computer, digital outputs 2 – 6, switch-on test
Shifting in split gears not completed (no change or no
03284 FFR powerflow) or clutch slip detected
Pressure control module, right rear axle, faulty outlet and backup
03285 EBS valve checkback
03285 EHLA Function computer, digital outputs 2 – 6, switch-on test
03285 FFR Check clutch for wear
Pressure control module, right rear axle, faulty outlet and intake
03286 EBS valve checkback
03286 EHLA Function computer, digital outputs 2 – 6, switch-on test
03286 FFR Brake pedal switch
Pressure control module, right rear axle, faulty outlet and intake
03287 EBS and backup valve checkback
03287 FFR CAN data bus: Time overrun when receiving VSM message TCI
03288 EBS Pressure control module, right rear axle, no valid fault definition
03289 EBS Pressure control module, right rear axle, no valid fault definition
Pressure control module, right rear axle, no CAN reception from
03290 EBS module
03290 FFR Control unit (register test)
03299 EBS Pressure control module, right rear axle, no valid fault definition
03300 EBS Pressure control module E, no fault
03300 FFR Control unit or cable line (engine brake output stage)
03300 OBDU Alternator speed
03300 ZBR2 Alternator / starter
03300 ZBRO Engine revs
Pressure control module E, interruption, short-circuit wheel
03301 EBS sensor A
03301 EBS_K1 (!) Wheel sensor left auxiliary axle
03301 FFR Control unit or peripherals (output stage, clutch servo)
03301 OBDU Engine oil temperature too high
03301 ZBR2 Alternator tl. L
03302 EBS Pressure control module E, wheel sensor A: Delay too long
03302 FFR Control unit or cable line (power take-off 1 output stage)
03302 ZBR2 Alternator B+ sense
03303 EBS Pressure control module E, wheel sensor A: Moving off fault
03303 FFR Control unit or cable line (power take-off 2 output stage)
03303 ZBR2 Engine running (= signal D+)
03303 ZBRO Engine running
03304 EBS Pressure control module E, wheel sensor A: Clearance too great
03304 FFR Control unit or cable line (thermostat heater output stage)
03304 OBDU EDC boiling protection
03308 EBS Pressure control module E, fault on lifting axle wheel sensor A
03308 FFR Control unit or cable line (earth group output stage)
03309 EBS Pressure control module E, no valid fault definition
03314 EBS Pressure control module E, wheel sensor B: Clearance too great
03314 TPM Severe leakage from right outer tyre, axle 1
03314 ZBRO Economy circuit workshop jumper
03318 EBS Pressure control module E, fault on lifting axle wheel sensor B
03318 ZBRO Roller-type sw. 2 start interr. (closed)
03319 CNG_ME7 Throttle butterfly actuator minimum stop
03319 EBS Pressure control module E, no valid fault definition
03319 ZBRO Alternator LIMA1 not charging
Pressure control module E, electrical power supply fault, pad
03320 EBS wear sensor
Electrical power supply pad wear sensor (additional axle left or
03320 EBS_K1 additional axle)
03320 ZBRO Charge check alternator LIMA2
Pressure control module E, pad wear sensor A outside
03321 EBS permitted value range
03321 EBS_K1 Pad wear sensor A additional axle left outside valid range
03321 TPM Severe leakage from left outer tyre, axle 2
03321 ZBRO Alternator LIMA2 not charging
03322 CNG_ME7 Crankshaft to camshaft signal
Pressure control module E, pad wear sensor B outside
03322 EBS permitted value range
03322 EBS_K1 Pad wear sensor B additional axle left outside valid range
03322 TPM Severe leakage from left inner tyre, axle 2
03322 ZBRO Engine start in rear
Pressure control module E, pressure sensor outside permitted
03323 EBS value range
(!) Pressure sensor (left additional axle or additional axle)
03323 EBS_K1 outside valid range
03323 TPM Severe leakage from right inner tyre, axle 2
03323 ZBRO Engine stop in rear
03326 EBS Pressure control module E, excessive pressure during pulse test
03326 ZBRO Engine compartment flap open
03327 EBS Pressure control module E, residual pressure after braking
03327 ZBRO Gearb. n. neutral (starting impossible)
Pressure control module E, pressure sensor fault without
03328 EBS braking
03328 ZBRO Start interruption via fuel tank flap
03329 CNG_ME7 Suction pipe pressure sensor
03329 EBS Pressure control module E, no valid fault definition
03329 ZBRO Engine start front
03330 EBS Pressure control module E, wheel sensor IC defective
03330 ZBRO Engine stop front
03331 EBS Pressure control module E, faulty backup valve checkback
03331 TPM Severe leakage from left outer tyre, axle 3
03331 ZBRO Roller-type sw. 3 start interr. (open)
03332 EBS Pressure control module E, faulty intake valve checkback
03332 TPM Severe leakage from left inner tyre, axle 3
03332 ZBRO Roller-type sw. 4 start interr. (closed)
Pressure control module E, faulty intake and backup valve
03333 EBS checkback
03333 TPM Severe leakage from right inner tyre, axle 3
03333 ZBRO Central front flap open
03334 EBS Pressure control module E, faulty outlet valve checkback
03334 TPM Severe leakage from right outer tyre, axle 3
03334 ZBRO Roller-type sw. start interr. fault fr.
Pressure control module E, faulty outlet and backup valve
03335 EBS checkback
03335 ZBR2 Voltage specification not possible (alternator / starter)
Pressure control module E, faulty outlet and intake valve
03336 EBS checkback
Exhaust and intake valve checkback (additional axle left or
03336 EBS_K1 additional axle)
03336 ZBRO Supply compartment open
Pressure control module E, faulty outlet and intake and backup
03337 EBS valve checkback
03337 ZBRO Roller-type sw. start interr. fault fr.
03338 EBS Pressure control module E, no valid fault definition
03338 ZBRO Start interrupted
03339 EBS Pressure control module E, no valid fault definition
03339 ZBRO Flap 1 left open
03340 EBS Pressure control module E, no CAN reception from module
03340 ZBRO Flap 2 left open
Pressure control module E, software incompatibility between
03341 EBS control unit and pressure control module
Software statuses of control unit and pressure-control module
03341 EBS_K1 (additional axle left or additional axle) do not match
03341 TPM Severe leakage from left outer tyre, axle 4
03341 ZBRO Flap 2 right open
Pressure control module E, 12/24 volt incompatibility between
03342 EBS control unit and pressure control module
03342 TPM Severe leakage from left inner tyre, axle 4
03342 ZBRO Flap 3 left open
SD 812a en-online 05.2007 Page 194 of 276
SPN Control unit/System Fault message
Pressure control module E, high cycle protection intake valve
03343 EBS active, pressure < 4 bar
03343 TPM Severe leakage from right inner tyre, axle 4
03343 ZBRO Flap 4 left open
03344 EBS Pressure control module E, arithmetic test not successful
Pressure-control module (additional axle left or additional axle)
03344 EBS_K1 defective, arithmetic test unsuccessful
03344 TPM Severe leakage from right outer tyre, axle 4
03344 ZBRO Battery flap open
Pressure control module E, wheel compensation fault wheel
03345 EBS sensor A
03345 ZBRO Flap in rear flap open
Pressure control module E, wheel compensation fault wheel
03346 EBS sensor B
03346 ZBRO Engine stop in rear
Pressure control module E, electrical power supply fault, axle
03347 EBS load sensor
03347 ZBR2 Terminal L alternator 2
Pressure control module E, pressure differential on pressure
03348 EBS control module pair, rear axle
03349 EBS Pressure control module E, no valid fault definition
03350 EBS Pressure control module F, no fault
Pressure control module F, interruption, short-circuit wheel
03351 EBS sensor A
03351 EBS_K1 (!) Wheel sensor right additional axle
03351 TPM Severe leakage from left outer tyre, axle 5
03352 EBS Pressure control module F, wheel sensor A: Delay too long
03352 TPM Severe leakage from left inner tyre, axle 5
03353 CNG_ME7 Pressure sensor charge air pressure
03353 EBS Pressure control module F, wheel sensor A: Moving off fault
03353 TPM Severe leakage from right inner tyre, axle 5
03354 EBS Pressure control module F, wheel sensor A: Clearance too great
03354 TPM Severe leakage from right outer tyre, axle 5
03355 EBS Pressure control module F, perpetual control wheel sensor A
03355 TPM LID checksum error
03358 EBS Pressure control module F, fault on lifting axle wheel sensor A
03359 EBS Pressure control module F, no valid fault definition
03364 EBS Pressure control module F, wheel sensor B: Clearance too great
SD 812a en-online 05.2007 Page 195 of 276
SPN Control unit/System Fault message
03364 EHLA Function computer, monitoring modules
03365 EBS Pressure control module F, perpetual control wheel sensor B
03365 EHLA Function computer, monitoring modules
03366 EBS Pressure control module F, long instability wheel sensor B
03366 EHLA Function computer, overvoltage
03367 EBS Pressure control module F, pulse ring fault wheel sensor B
03367 EHLA Function computer, undervoltage
03368 EBS Pressure control module F, fault on lifting axle wheel sensor B
03368 EHLA Function computer, overtemperature
03369 EBS Pressure control module F, no valid fault definition
03369 EHLA Function computer, monitoring modules
Pressure control module F, electrical power supply fault, pad
03370 EBS wear sensor
03370 EHLA Function computer, monitoring modules
Pressure control module F, pad wear sensor A outside permitted
03371 EBS value range
03371 EBS_K1 Pad wear sensor A (additional axle right) outside valid range
03371 EHLA Function computer, monitoring modules
Pressure control module F, pad wear sensor B outside permitted
03372 EBS value range
03372 EBS_K1 Pad wear sensor B (additional axle right) outside valid range
03372 EHLA Function computer, monitoring modules
Pressure control module F, pressure sensor outside permitted
03373 EBS value range
03373 EHLA Function computer, monitoring modules
Pressure control module F, time for 'Current pressure' inquiry
03374 EBS too long
03374 EHLA Function computer, output voltage '5V ref'
03375 EBS Pressure control module F, poor ventilation
03375 EHLA Function computer, output voltage '5V ext'
03376 EBS Pressure control module F, excessive pressure during pulse test
03376 EHLA Function computer, monitoring modules
03377 EBS Pressure control module F, residual pressure after braking
Pressure control module F, pressure sensor fault without
03378 EBS braking
03379 EBS Pressure control module F, no valid fault definition
03380 EBS Pressure control module F, wheel sensor IC defective
03381 EBS Pressure control module F, faulty backup valve checkback
03381 EHLA Function computer, digital output 1
03382 CNG_ME7 Circuit trailing throttle circulating air valve
03382 EBS Pressure control module F, faulty intake valve checkback
03382 EHLA Function computer, digital outputs 2 – 6, operation
Pressure control module F, faulty intake and backup valve
03383 EBS checkback
03383 EHLA Function computer, digital outputs 2 – 6, operation
03384 EBS Pressure control module F, faulty outlet valve checkback
03384 EHLA Function computer, digital outputs 2 – 6, operation
Pressure control module F, faulty outlet and backup valve
03385 EBS checkback
03385 EHLA Function computer, digital outputs 2 – 6, operation
Pressure control module F, faulty outlet and intake valve
03386 EBS checkback
03386 EHLA Function computer, digital outputs 2 – 6, operation
Pressure control module F, faulty outlet and intake and backup
03387 EBS valve checkback
03388 EBS Pressure control module F, no valid fault definition
03389 EBS Pressure control module F, no valid fault definition
03390 EBS Pressure control module F, no CAN reception from module
SD 812a en-online 05.2007 Page 196 of 276
SPN Control unit/System Fault message
Pressure control module F, software incompatibility between
03391 EBS control unit and pressure control module
Pressure control module F, 12/24 volt incompatibility between
03392 EBS control unit and pressure control module
Pressure control module F, high cycle protection intake valve
03393 EBS active, pressure < 4 bar
03394 EBS Pressure control module F, arithmetic test not successful
Pressure control module F, wheel compensation fault wheel
03395 EBS sensor A
Pressure control module F, wheel compensation fault wheel
03396 EBS sensor B
Pressure control module F, electrical power supply fault, axle
03397 EBS load sensor
Pressure control module F, pressure differential on pressure
03398 EBS control module pair, rear axle
03399 EBS Pressure control module F, no valid fault definition
03400 EBS Trailer control module, no fault
03400 ZBR2 Flame start solenoid valve
Trailer control module control electronics, unknown µC interrupt,
03401 EBS µC self-test, RAM or ROM test
03401 OBDU Engine oil level too high/low (static)
03401 ZBR2 Flame start relay
03402 CNG_ME7 Throttle butterfly position deviation
03402 EBS Trailer control module, no valid fault definition
03402 OBDU Engine oil level too high (dynamic)
03402 ZBR2 Flame glow plug current
03403 CNG_ME7 Throttle butterfly output stage switched off
Trailer control module control electronics, EEPROM, too many
03403 EBS write accesses
03403 OBDU Engine oil level too low (dynamic)
03403 ZBR2 Flame glow plug current
03404 CNG_ME7 Throttle butterfly controller in limit
Trailer control module control electronics, EEPROM, checksum
03404 EBS fault or EOL data invalid
03404 OBDU Cooling water level too low
03405 CNG_ME7 Monitoring computer; ROM
Trailer control module control electronics, EEPROM, too many
03405 EBS data repairs required
03406 CNG_ME7 Monitoring computer; RAM
Trailer control module control electronics, EEPROM, monitoring
03406 EBS time exceeded when writing data
03407 CNG_ME7 Monitoring computer; reset
03407 EBS Trailer control module, no valid fault definition
03407 OBDU Oil level in power steering 1 too low
03408 CNG_ME7 Monitoring function; torque comparison
Trailer control module control electronics, EEPROM, fault in
03408 EBS dynamic parameter setting
03408 OBDU Oil level in power steering 2 too low
03409 CNG_ME7 Monitoring function; safety fuel shut-off
Trailer control module control electronics, EEPROM, dynamic
03409 EBS parameters outside permitted value range
03410 CNG_ME7 Throttle butterfly error when checking limp-home air position
03410 EBS Trailer control module, no valid fault definition
03410 OBDU Clutch oil level too low
03411 CNG_ME7 Throttle butterfly error in booster balancing
03411 EBS Trailer control module, no valid fault definition
03411 FFR Gearbox output speed out of permitted range
03412 CNG_ME7 Throttle butterfly error in spring check 'Closing'
03412 EBS Trailer control module, no valid fault definition
03436 FFR Engine start requested although gearbox not in neutral position
03437 EBS Trailer control module, no valid fault definition
03437 FFR Engine start requested although vehicle speed > 0 km/h
03438 EBS Trailer control module, no valid fault definition
03439 EBS Trailer control module, no valid fault definition
Trailer control module, no CAN reception from trailer control
03440 EBS module
Trailer control module, software incompatibility between control
03441 EBS unit and trailer control module
Trailer control module, 12/24 volt incompatibility between control
03442 EBS unit and trailer control module
Trailer control module, high cycle protection intake valve active,
03443 EBS pressure < 4 bar
03444 EBS Trailer control module, arithmetic test not successful
03476 EBS ESP, steering angle sensor, defective CAN message content
03476 FFR CAN data bus: Message ECAM1, byte 3
03477 EBS ESP, steering angle sensor, gradient error
03477 FFR CAN data bus: Message ECAM1, byte 4
03478 EBS ESP, steering angle sensor, long-time alignment
03478 FFR CAN databus: Time overrun message KSM2
03479 EBS ESP, steering angle sensor, constant signal
03479 FFR CAN databus: Time overrun message ASC1_A
ESP, steering angle sensor incorrectly mounted, incorrect
03480 EBS steering angle sign
03480 FFR CAN databus: Time overrun message ASC1_B
ESP, steering angle sensor, plausibility monitoring between
03481 EBS steering angle and rotational speed
03482 EBS ESP, no valid error definition
03483 EBS ESP, rotational speed sensor, CAN timeout
03484 EBS ESP, rotational speed sensor signal out of permitted range
03485 EBS ESP, rotational speed sensor, defective CAN message content
03486 EBS ESP, rotational speed sensor, static BITE error
03487 EBS ESP, rotational speed sensor, dynamic BITE error
03488 EBS ESP, steering angle sensor, gradient error
03489 EBS ESP, no valid error definition
03490 EBS ESP, rotational speed sensor, fast alignment
03491 EBS ESP, rotational speed sensor, standstill alignment
03492 EBS ESP, rotational speed sensor, normal alignment
03493 EBS ESP, rotational speed sensor, sensitivity error
ESP, rotational speed sensor, plausibility monitoring valid for
03494 EBS model
ESP, rotational speed sensor, plausibility monitoring not valid for
03495 EBS model
ESP, rotational speed sensor incorrectly mounted, incorrect
03496 EBS steering angle sign
ESP, rotational speed sensor, plausibility monitoring between
03497 EBS rotational speed and steering angle
SD 812a en-online 05.2007 Page 200 of 276
SPN Control unit/System Fault message
03498 EBS ESP, no valid error definition
03499 EBS ESP, no valid error definition
03500 EBS ESP, no CAN communication with ESP
03500 FFR CAN databus: Time overrun message RET_CONF_RX_M
03500 KSM First faulty EOL LID
03500 ZBR2 Brake (ABS/ASR/ EBS)
03501 EBS ESP, software incompatible
03501 FFR CAN databus: Time overrun message ERC1_RX_M
03501 OBDU Alternator charge check failure
03501 ZBR2 Electrical power supply to trailer ABS
03502 EBS ESP, 12/24V incompatible with EBS
03502 FFR CAN databus: Time overrun message TANK_INFO
03502 OBDU Charging voltage too high
03502 ZBR2 Brake lamp, tractive unit
03502 ZBRO Brake lamp
03503 EBS ESP, no valid error definition
03503 FFR CAN databus: Time overrun message ENG_TEMP_M
03503 OBDU Vehicle system voltage often too low
03503 ZBR2 Brake lamp in trailer
03503 ZBRO Brake lamp trailer
03504 EBS ESP, ALU test failed
CAN databus: Time overrun message
03504 FFR ENG_TEMP_M_TIMEOUT_SPN
03504 OBDU Battery undervoltage after vehicle parked up
03505 EBS ESP, output stage defective
03505 FFR CAN databus: Time overrun message EFLP_M
03505 OBDU Charge voltage too low for long period when engine running
03506 EBS ESP, intervention not plausible
03506 FFR CAN databus: Time overrun message FUEL_ECO_M
Vehicle system voltage too low for long period when engine
03506 OBDU running
03506 ZBRO Battery undervoltage
03507 EBS OBD, no valid error definition
03507 ZBRO Starting interlock active
03508 EBS OBD, no valid error definition
03508 ZBRO Starting interlock active
03509 EBS OBD, no valid error definition
03509 ZBRO Starting interlock request
03510 EBS OBD, no valid error definition
03510 OBDU Retarder actuated
03510 ZBRO ASR button/switch
03511 EBS OBD, no valid error definition
03511 OBDU Engine brake operated
03511 ZBRO ASR button/switch
03512 EBS OBD, request, red warning lamp for diagnosis
03512 EBS_5 Diagnosis: Request red warning lamp
03512 EBS_K1 Diagnostic request 'Red warning'
03512 OBDU Brake pedal pressed
03512 ZBRO ASR control (INA)
03513 EBS OBD, request, yellow warning lamp for diagnosis
03513 EBS_5 Diagnosis: Request yellow warning lamp
03513 EBS_K1 Diagnostic request 'Yellow warning'
03513 ZBRO ASR check lamp
03514 EBS OBD, no valid error definition
03514 ZBRO ASR control (brake via T-CAN)
03515 EBS OBD, brake wear sensor signal
03515 EBS_5 Request warning lamp brake pad wear
03515 EBS_K1 Diagnostic request 'Pad wear warning'; brake pad wear
03515 ZBRO ASR control (engine via T-CAN)
03516 EBS OBD, trailer EBS has no errors
SD 812a en-online 05.2007 Page 201 of 276
SPN Control unit/System Fault message
03516 EBS_5 Request red warning light, ISO 11992 trailer interface
03516 EBS_K1 Request red warning light, ISO 11992 trailer interface
03516 ZBRO ASR check not connected
03517 EBS OBD, voltage too high or too low
03517 ZBRO ASR interface fault
03518 EBS OBD, trailer interface in single line mode
03518 ZBRO Brake pad wear indicator
03519 EBS OBD, wheel speed sensor, error during the last switch-on cycle
03519 EBS_K1 Engine speed sensor fault during most recent ignition on
03519 ZBRO Brake pressure brake circuit 1
03520 EBS OBD, limit gap speed, warning level, repeated every second
03520 FFR Steering column switch timeout (LIN)
03520 ZBRO Brake pressure brake circuit 2
03521 EBS OBD, frequent-stop brake active
03521 FFR Multifunctional steering wheel timeout (LIN)
03521 ZBRO Brake pressure rear axle left
03522 EBS OBD, chassis dynamometer mode active
03522 EBS_5 Diagnosis: Dynamometer test rig mode active
03522 EBS_K1 Diagnostic mode active
03522 FFR Instrumentation timeout (LIN)
03522 ZBRO Brake pressure rear axle right
03523 EBS OBD, no valid error definition
03523 FFR Multifunctional steering wheel left button side
03523 ZBRO Brake pressure centre axle left
03524 EBS OBD, no valid error definition
03524 FFR Multifunctional steering wheel right button side
03524 ZBRO Brake pressure centre axle right
03531 EBS_K1 Fault in redundant circuit during most recent ignition on cycle
03531 ZBRO Brake lamp trailer left
Incorrect tyre diameter during most recent ignition on cycle,
03532 EBS_K1 short-term tyre monitoring
03532 ZBRO Brake lamp trailer right
03533 ZBRO Brake pedal position (0...250)
03534 ZBRO EBS brake pad wear indicator
03535 ZBRO EBS brake pad wear indicator
03536 ZBRO EBS check yellow
03537 ZBRO EBS check yellow
03538 ZBRO EBS check yellow not connected
SD 812a en-online 05.2007 Page 202 of 276
SPN Control unit/System Fault message
03539 ZBRO EBS air gap too large
03540 ZBRO EBS check red
03541 ZBRO EBS check red not connected
03542 ZBRO EBS malfunction prio. 1
03543 ZBRO EBS reservoir pressure too low
03544 ZBRO Spring-loaded accumulator reservoir
03545 ZBRO Spring-loaded accumulator reservoir
03546 ZBRO Parking brake 1 5.8 bar (open)
03547 ZBRO Parking brake 2 0.8 bar (close)
03548 ZBRO Bus-stop brake
03549 ZBRO Bus-stop brake
03550 ZBRO Buzzer engage parking brake/door malfunction
03551 ZBRO ABS active (via T-CAN)
03552 ZBRO Malfunction ABS/ASR
03553 ZBRO Check malfunction ABS/ASR
03554 ZBRO EBS/ABS activation (T-CAN)
03555 ZBRO UDS accident data box brake lamp
03556 ZBRO Parking brake fault
03557 ZBRO EBS check yellow (via CAN)
03558 ZBRO EBS check red (via CAN)
03559 ZBRO ABS fully operational
03560 ZBRO Brake pad thickness, 1st axle right
03561 ZBRO Brake pad thickness, 1st axle left
03562 ZBRO Brake pad thickness, 2nd axle right
03563 ZBRO Brake pad thickness, 2nd axle left
03564 ZBRO Brake pad thickness, 3rd axle right
03565 ZBRO Brake pad thickness, 3rd axle left
03566 ZBRO Parking brake 1 forebody
03567 ZBRO Parking brake 1 for FFR
03568 OBDU Retarder actuated
03568 ZBR2 Retarder
03569 OBDU Engine brake operated
03569 ZBR2 Engine brake
03570 OBDU Brake pedal pressed
03570 ZBR2 Service brake
03571 ZBRO Bus stop brake switched off
03572 OBDU Charge check 2
03572 ZBR2 Bus-stop brake
03581 CNG_ME7 Diagnosis lambda probe before catalytic converter;
03582 CNG_ME7 Heating diagnosis lambda probe before catalytic converter
03583 CNG_ME7 Pressure sensor gas
03584 CNG_ME7 Coding; quality gas
03584 TRON Control unit error
03585 CNG_ME7 Temperature gas
03585 TRON No ignition – safety time exceeded
03586 TRON Flame failure from operation
03587 TRON Voltage
03588 TRON Flame present during switch-on, cold blowing timeout
03589 TRON Flame sensor
03590 TRON Actual value temperature control sensor
03591 TRON Metering pump
03592 TRON Burner motor
03593 CNG_ME7 Solenoid stop valve (gas LD) leaking
03593 TRON Glow plug
03594 CNG_ME7 Supply injection valves bank 1 output stage
03594 TRON Overheating
03595 CNG_ME7 Supply injection valves bank 2 output stage
03596 CNG_ME7 Stop valve gas 1 output stage (low pressure)
03596 TRON Setpoint
03597 CNG_ME7 Stop valve gas 2 output stage (high pressure)
SD 812a en-online 05.2007 Page 203 of 276
SPN Control unit/System Fault message
03597 TRON Overheating sensor
03598 CNG_ME7 Balancing in trailing throttle mode (measuring probe)
03598 TRON Warning short-circuit output fresh air signal
03599 CNG_ME7 Balancing in trailing throttle mode (diagnostic probe)
03599 TRON Warning short-circuit output theft alarm
03600 EBS_K1 System bus, general
No ignition - Too many unsuccessful start attempts (operation
03600 TRON interlock)
03600 ZBR2 Fill level, clutch fluid
03601 CNG_ME7 Output stage starter control
System bus, monitoring of the axle modulator drive axle
03601 EBS_K1 messages by central brake unit; CAN brake
03601 OBDU Front axle above technically permitted axle load
Overheating - Hardware threshold exceeded in control unit
03601 TRON (operation interlock)
System bus, monitoring of the axle modulator additional axle
03602 EBS_K1 messages by central brake unit; CAN brake
03602 OBDU Rear axle above technically permitted axle load
Overheating - Too many overheatings or hardware threshold
03602 TRON exceeded in control unit (operation interlock)
03602 ZBR2 Reversing light relay
System bus, monitoring of the vehicle dynamics control
03603 EBS_K1 messages by central brake unit
Overheating sensor - Permitted difference from flame sensor
03603 TRON exceeded (redundant overheating monitoring)
03603 ZBR2 Heating, Kongsberg circuit
System bus, monitoring of the steering angle sensor messages
03604 EBS_K1 by central brake unit
03604 ZBRO Clutch brake shut-off
03605 ZBRO Clutch brake shut-off
03606 ZBRO Clutch brake shut-off
03607 ZBRO Clutch brake shut-off check
03608 ZBRO Clutch brake direct
03609 ZBRO Clutch brake direct stage 1
System bus, monitoring of the central brake unit messages by
03610 EBS_K1 axle modulator drive axle; CAN brake
03610 ZBRO Clutch brake direct stage 2
03611 ZBRO Clutch brake direct stage 3
System bus, monitoring of the axle modulator additional axle
03612 EBS_K1 messages by axle modulator drive axle
03612 ZBRO Gearbox neutral
System bus, monitoring of the electronic stability program
03613 EBS_K1 messages by axle modulator drive axle
03613 ZBRO Current gear (T-CAN)
03614 ZBRO Gear engaged (T-CAN)
03615 ZBRO Selected gear
03616 ZBRO Gear oil too hot
03617 ZBRO Gear oil too hot
03618 ZBRO Reversing light
03619 ZBRO Reverse light left
System bus, monitoring of the central brake unit messages by
03620 EBS_K1 axle modulator additional axle
03620 ZBRO Reverse light right
System bus, monitoring of the axle modulator drive axle
03621 EBS_K1 messages by axle modulator additional axle
03621 ZBRO Gearbox activation (T-CAN)
03622 ZBRO EK shut-off Voith
System bus, monitoring of the vehicle dynamics control
03623 EBS_K1 messages by axle modulator additional axle
03623 ZBRO Neutral at standstill ZF
SD 812a en-online 05.2007 Page 204 of 276
SPN Control unit/System Fault message
03624 ZBRO UDS accident data box reversing light
03625 ZBR2 Off-road range
03626 ZBRO Reversing light buzzer
03627 ZBRO Gear enable Voith
03628 ZBRO Gearbox oil temperature
03629 ZBR2 Transfer case neutral
System bus, monitoring of the central brake unit messages by
03630 EBS_K1 vehicle dynamics control
System bus, monitoring of the axle modulator drive axle
03631 EBS_K1 messages by vehicle dynamics control
System bus, monitoring of the axle modulator additional axle
03632 EBS_K1 messages by vehicle dynamics control
System bus, monitoring of the steering angle sensor messages
03634 EBS_K1 by electronic stability program
03650 EBS_K1 CAN trailer interface
03651 EBS_K1 CAN trailer interface, CAN high
03652 EBS_K1 CAN trailer interface, CAN low
03667 EDC64 Atmospheric pressure pickup
03668 EDC64 Charge pressure pickup
03671 EDC7 Error when reading in EEPROM
03672 EDC7 Error when reading in the fault memory
03673 EDC7 CAN block 2
03674 EDC7 FFR1: Bank shut-off byte8/bit5-8
03675 EDC7 Faulty redundant shut-off device afterrun drive
03676 EDC7 Faulty redundant shut-off device afterrun test
03677 EDC6 Charge air low pressure sensor
03677 EDC7 Charge air low pressure sensor
03678 EDC6 Booster voltage bank 1
03678 EDC7 Booster voltage bank 1
03679 EDC6 Booster voltage bank 2
03679 EDC7 Booster voltage bank 2
03680 EDC6 Current high pressure pump CP3
03680 EDC7 Current high pressure pump CP3
03681 EDC6 Starter output stage
03681 EDC7 Starter output stage
03682 EDC6 Averaged control rod position
03682 EDC7 Averaged control rod position
03683 EDC6 Signalling of activation request for output stage
03683 EDC7 Signalling of activation request for output stage
03684 EDC6 Starter output stage monitoring
03684 EDC7 Starter output stage monitoring
03685 EDC6 Activation pulse duty ratio for exhaust gas recirculation valve
03685 EDC7 Activation pulse duty ratio for exhaust gas recirculation valve
03686 EDC6 Activation pulse duty ratio for boost pressure control
03686 EDC7 Activation pulse duty ratio for boost pressure control
03687 EDC6 Pressure relief valve
03687 EDC7 Pressure relief valve does not open
03688 EDC6 Pressure controller variable (pulse duty ratio)
03688 EDC7 Pressure controller variable (pulse duty ratio)
03689 EDC7 Rail pressure control differential
03690 EDC7 Synchronisation state
03691 EDC6 Current equivalent of the pulse duty ratio
03691 EDC7 Current equivalent of the pulse duty ratio
03692 EDC6 Recorded internal temperature EDC
03692 EDC7 Recorded internal temperature EDC
03693 EDC7 Booster voltage
03694 EDC7 Timeout message position 4
03700 ZBRO Retarder active
03701 EBS_K1 Vehicle dynamics control module
03701 ZBRO Retarder torque gearbox (T-CAN)
SD 812a en-online 05.2007 Page 205 of 276
SPN Control unit/System Fault message
03702 EDC6 CAN A block DPRAM error
03702 EDC7 CAN A block DPRAM error
03702 ZBRO Retarder torque engine control (T-CAN)
03703 EDC6 CAN A block error passive
03703 EDC7 CAN A block error passive
03703 ZBRO Retarder activation (T-CAN)
03704 ZBRO Retarder off (switch)
03748 EDC7 Highside output stage metering unit high-pressure pump CP3
03749 EDC7 Highside output stage engine air flow sensor flap
03750 EBS_5 ESP sensor gateway, ESP sensor voltage supply fault
03750 EDC7 Highside output stage RH 07
03751 EDC7 Highside output stage starter relay
03752 EDC7 Segment encoder (camshaft)
ESP sensor gateway, time overrun in communication with
03753 EBS_5 steering angle sensor
03753 EDC7 Incremental encoder (crankshaft)
ESP sensor gateway, time overrun in communication with yaw
03754 EBS_5 rate sensor
03754 EDC7 Monitoring error when system starts
03755 EDC7 Plausibility fuel supply pressure
03756 EBS_5 ESP sensor gateway, faulty steering angle sensor signal
Supply voltage exhaust gas recirculation system checkback,
03756 EDC7 exhaust differential pressure
03757 EBS_5 ESP sensor gateway, faulty yaw rate sensor signal
03758 EBS_5 ESP sensor gateway, faulty lateral acceleration sensor signal
03758 EDC7 Send error message slot 2 to partner EDC
03759 EBS_5 ESP sensor gateway, steering angle sensor not calibrated
03759 EDC7 Send error message slot 3 to partner EDC
03760 EDC7 Send error message slot 4 to partner EDC
03761 EDC7 Send error message slot 5 to partner EDC
03762 EDC7 Timeout of the CAMD_ANA message
03763 EDC7 Timeout of the CAMD_CMOL message
03764 EDC7 Timeout of the CAMD_CONTROL message
03765 EDC7 Timeout of the CAMD_FFR1 message
03766 EDC7 Timeout of the CAMD_FFR2 message
03767 EDC7 Timeout of the CAMD_FFR3 message
03768 EDC7 Fault status of the CAMD_INIT message
03769 EDC7 Timeout of the CAMD_Limit message
03771 EDC7 Master/slave CAN fault in partner control unit
03772 EDC7 Monitoring terminal 15 master/slave
03773 EDC7 Operating mode change error master/slave
03774 EDC7 Temporary CMOL mode of the partner EDC
SD 812a en-online 05.2007 Page 207 of 276
SPN Control unit/System Fault message
03775 EDC6 Rail pressure monitoring
03775 EDC7 Rail pressure monitoring
Excessive positive control differential (control system cannot
03776 EDC6 compensate for too low rail pressure)
Excessive positive control differential (control system cannot
03776 EDC7 compensate for too low rail pressure)
Excessive negative control differential (control system cannot
03777 EDC6 compensate for too high rail pressure)
Excessive negative control differential (control system cannot
03777 EDC7 compensate for too high rail pressure)
03778 EDC6 Rail pressure: Leakage in overrun conditions
03778 EDC7 Rail pressure: Leakage in overrun conditions
03779 EDC6 Rail pressure: Leakage due to quantity compensation
03779 EDC7 Rail pressure: Leakage due to quantity compensation
03780 EDC6 Rail pressure: High controller output when idling
03780 EDC7 Rail pressure: High controller output when idling
03781 EDC6 Pressure relief valve open (pressure too high)
03781 EDC7 Pressure relief valve open (pressure too high)
03782 EDC6 Fuel supply pressure dynamic
03782 EDC7 Fuel supply pressure dynamic
FFR (vehicle management computer) 2: Bit error max. permitted
03783 EDC6 engine acceleration
FFR (vehicle management computer) 2: Bit error max. permitted
03783 EDC7 engine acceleration
03784 EDC6 Bit error smoke ID
03784 EDC7 Bit error smoke ID
Monitoring particle filter/PM catalytic converter, differential
03785 EDC6 exhaust pressure too high or too low
Monitoring particle filter/PM catalytic converter, differential
03785 EDC7 exhaust pressure too high or too low
03786 EDC6 Particulate filter temperature limits
03786 EDC7 Particulate filter temperature limits
03787 EDC6 No particulate filter regeneration
03787 EDC7 No particulate filter regeneration
03788 EDC6 Exhaust gas differential or exhaust gas relative pressure
03788 EDC7 Exhaust gas differential or exhaust gas relative pressure
03789 EDC6 Exhaust gas differential or exhaust gas relative pressure sensor
03789 EDC7 Exhaust gas differential or exhaust gas relative pressure sensor
Exhaust gas differential or exhaust gas relative pressure
03790 EDC6 plausibility
Exhaust gas differential or exhaust gas relative pressure
03790 EDC7 plausibility
03791 EDC6 Exhaust temperature before exhaust post-treatment
03791 EDC7 Exhaust temperature before exhaust post-treatment
03792 EDC6 Exhaust temperature sensor before exhaust post-treatment
03792 EDC7 Exhaust temperature sensor before exhaust post-treatment
03793 EDC6 Exhaust temperature after exhaust post-treatment
03793 EDC7 Exhaust temperature after exhaust post-treatment
03794 EDC6 Exhaust temperature sensor after exhaust post-treatment
03794 EDC7 Exhaust temperature sensor after exhaust post-treatment
03795 EDC6 Exhaust gas recirculation throttle butterfly
03795 EDC7 Exhaust gas recirculation throttle butterfly
03796 EDC6 Highside output stage exhaust gas recirculation system 2
03796 EDC7 Highside output stage exhaust gas recirculation system 3
03797 EDC6 Highside output stage lambda probe
03797 EDC7 Highside output stage lambda probe
03798 EDC6 Output stage OBD lamp (MIL)
03798 EDC7 Output stage OBD lamp (MIL)
SD 812a en-online 05.2007 Page 208 of 276
SPN Control unit/System Fault message
03799 EDC6 Highside output stage reserve 01
03799 EDC7 Highside output stage reserve 01
03800 EDC6 Highside output stage reserve 02
03800 EDC7 Highside output stage reserve 02
03800 ZBR2 Air suspension/ECAS
03801 EDC6 Highside output stage reserve 03
03801 EDC7 Highside output stage reserve 03
03801 OBDU No engine start for at least 3 weeks
03802 EDC6 Highside output stage stop valve compressed air
03802 EDC7 Highside output stage stop valve compressed air
03802 OBDU No engine start for at least 10 weeks
Engine CAN transmit error, no message available in vehicle
03803 EDC6 management computer
Engine CAN transmit error, no message available in vehicle
03803 EDC7 management computer
Engine CAN receive error, not possible to receive a message
03804 EDC6 from vehicle management computer
Engine CAN receive error, not possible to receive a message
03804 EDC7 from vehicle management computer
03805 EDC6 Master/slave CAN communication disrupted, bus load too high
03805 EDC7 Master/slave CAN communication disrupted, bus load too high
03806 EDC6 Master/slave CAN communication disrupted, receive error
03806 EDC7 Master/slave CAN communication disrupted, receive error
03806 ZBRO Raise bus again
Vehicle management computer sends invalid value in FFR1
03807 EDC6 message
Vehicle management computer sends invalid value in FFR1
03807 EDC7 message
03807 ZBRO Raise bus again
Vehicle management computer sends invalid value in FFR2
03808 EDC6 message
Vehicle management computer sends invalid value in FFR2
03808 EDC7 message
Vehicle management computer sends invalid value in FFR3
03809 EDC6 message
Vehicle management computer sends invalid value in FFR3
03809 EDC7 message
03809 ZBRO ECAS malfunction
Vehicle management computer sends invalid numerical value,
03810 EDC6 date/time error
Vehicle management computer sends invalid numerical value,
03810 EDC7 date/time error
03810 ZBRO ECAS warning
03912 EDC7 Measured voltage of the exhaust gas recirculation flap position
03913 EDC7 Zero point voltage of the exhaust gas recirculation valve position
03913 OBDU ECAM in pneumatic backup, CAN OK
03914 EDC7 Unfiltered charge air temperature at cylinder inlet
03915 EDC7 Measured voltage of internal EDC temperature
03915 OBDU ASR engine governor failure
03929 EDC7 Monitoring of exhaust gas recirculation with lambda (MIL error)
03930 EDC7 Monitoring of exhaust gas recirculation with lambda (PR error)
03931 EDC7 Output stage PWM19
03932 EDC7 Output stage PWM30
03940 EDC7 Recovery type of the most recently saved recoveries
03941 EDC7 Recovery type of the most recently saved recoveries
04000 AST Foot off accelerator pedal
04000 EBS_5 (!) Central control unit - B-controller: Brake performance test
04000 EDC6 Communication fault to CRT control unit
04000 EDC7 Communication fault to CRT control unit
04000 TBM No response to DM4 request to control unit 0
04000 ZBR2 External lighting
04000 ZBRO Headlight low beam
04001 AST Low air pressure
Central control unit - A-controller: Checksum error in
04001 EBS_5 configuration RAM
Exhaust temperature too high or communication fault to CRT
04001 EDC6 control unit
Exhaust temperature too high or communication fault to CRT
04001 EDC7 control unit
04001 EMOS System pressure or switch-on duration of actuators
04001 INT Accumulator charge valve
04001 SFFR Selector lever position
04001 TBM No response to DM4 request to control unit 1
04001 ZBR2 Headlight low beam, left
04001 ZBRO Low beam left
04002 AST Clutch overload
04002 EBS_5 Central control unit - A-controller: Internal data memory
04002 EMOS Clutch overload
04002 INT Engine brake request
04002 SFFR Speed request ship vehicle management computer
04002 TBM No response to DM4 request to control unit 2
04002 ZBR2 Headlight low beam, right
04002 ZBRO Low beam right
04003 AST Clutch word
(!) Central control unit - B-controller: ESP intervention
04003 EBS_5 implausible
04003 INT Intarder check lamp
04003 SFFR Terminal 15
04003 TBM No response to DM4 request to control unit 3
04003 ZBR2 Right headlight adjustment
04004 AST Clutch wear
04004 EBS_5 ESP logic, incorrect configuration
SD 812a en-online 05.2007 Page 213 of 276
SPN Control unit/System Fault message
04004 HVA EEPROM error
04004 INT Display, temperature reduction
04004 SFFR Voltage selector lever
04004 TBM No response to DM4 request to control unit 4
04004 ZBR2 Left headlight adjustment
Central control unit - B-controller: Pressure regulating valves
04005 EBS_5 (ABS) are in an undefined status
04005 INT Brake lamp output
04005 SFFR Voltage pedal value sensor
04005 TBM No response to DM4 request to control unit 5
04005 ZBR2 Turn indicators, tractive unit, rear left
04005 ZBRO Turn indicator rear left bottom
(!) Central control unit - B-controller: Calculated ISC pressures in
04006 EBS_5 A and B-controller do not match
04006 INT Fault lamp output
04006 TBM No response to DM4 request to control unit 6
04006 ZBR2 Turn indicators, tractive unit, rear right
04006 ZBRO Turn indicator rear right bottom
(!) ABS logic, FMI 3 = Pressure plausibility / FMI 8 = Data record
04007 EBS_5 plausibility
04007 HVA Failure of CAN message CCVeh_Speed
04007 INT Cruise control shut-off
04007 TBM No response to DM4 request to control unit 7
04007 ZBR2 Turn indicator, tractive unit s/f, left
04007 ZBRO Turn indicator front left side
ABS (pressure control valve): Installed but no components
04008 EBS_5 configured
04008 HVA Failure of CAN message EBC2
04008 INT Braking level selector supply
04008 TBM No response to DM4 request to control unit 8
04008 ZBR2 Turn indicator, tractive unit s/f, right
04008 ZBRO Turn indicator front right side
04009 EBS_5 Central control unit
04009 HVA Failure of CAN message EEC1
04009 INT Proportional valve
04009 TBM No response to DM4 request to control unit 9
04009 ZBR2 Hall sensor, indicator stalk switch RL
Central control unit - Internal controller communication of the A-
04010 EBS_5 controller, checksum error
04010 HVA Failure of CAN message EBC1
04010 INT Earth return, proportional valve
04010 TBM No response to DM4 request to control unit 10
04010 ZBR2 Hall sensor, indicator stalk switch RR
Central control unit - Internal controller communication of the A-
04011 EBS_5 controller, interruption in communication
04011 HVA ABS signals 'Not fully operational'
04011 INT Output ADM2
04011 TBM No response to DM4 request to control unit 11
04011 ZBR2 Switch, indicators, left (button)
04011 ZBRO Turn indicator, left
Central control unit - Internal controller communication of the A-
04012 EBS_5 controller, format error
04012 HVA Cable fault oil temperature sensor (pin III/3 or IV/18)
04012 INT Speed sensor, gearbox output
04012 TBM No response to DM4 request to control unit 12
04012 ZBR2 Switch, indicators, right (button)
04012 ZBRO Turn indicator, right
04013 EBS_5 Central control unit - A-controller, format error
04013 HVA Oil pressure sensor signals 'No oil pressure' or engine stalled
SD 812a en-online 05.2007 Page 214 of 276
SPN Control unit/System Fault message
04013 INT Temperature detection, system error
04013 TBM No response to DM4 request to control unit 13
04013 ZBR2 Check lamp, hazard warning lights
04013 ZBRO Hazard warning lights check
Central control unit - Internal controller communication of the B-
04014 EBS_5 controller, checksum error
04014 HVA Oil pressure sensor signals 'Continuous oil pressure'
04014 INT Readback current, proportional valve
04014 TBM No response to DM4 request to control unit 14
04014 ZBR2 Hazard warning light switch
04014 ZBRO Hazard warning light switch
Central control unit - Internal controller communication of the B-
04015 EBS_5 controller interruption in communication
04015 HVA Cable fault oil pressure sensor (pin III/4, II/5 or I/5)
04015 INT Power supply
04015 TBM No response to DM4 request to control unit 15
04015 ZBR2 Turn indicators in trailer, left
04015 ZBRO Turn indicator left trailer
Central control unit - Internal controller communication of the B-
04016 EBS_5 controller, format error
04016 HVA Fault at output ZP1 (pin IV/11)
04016 INT Braking level selector
04016 TBM No response to DM4 request to control unit 16
04016 ZBR2 Turn indicators in trailer, right
04016 ZBRO Turn indicator right trailer
Central control unit EEPROM: Implausible values in 'General
04017 EBS_5 vehicle configuration' block
04017 HVA Fault at output ZP2 (pin IV/2 or IV/6)
04017 INT Operating hours counter, system error
04017 TBM No response to DM4 request to control unit 17
04017 ZBR2 Headlight high beam, left
04017 ZBRO High beam 1 left
Central control unit EEPROM: Checksum error in 'General
04018 EBS_5 vehicle configuration' block
04018 INT Faul memory, system error
04018 TBM No response to DM4 request to control unit 18
04018 ZBR2 Headlight high beam, right
04018 ZBRO High beam 1 right
Central control unit EEPROM: Implausible values in 'Own
04019 EBS_5 vehicle configuration' block
04019 HVA Fault at output ZP3 (pin III/13)
04019 INT CAN data bus
04019 TBM No response to DM4 request to control unit 19
04019 ZBR2 Switch, headlight high beam (button)
04019 ZBRO High beam switch
Central control unit EEPROM: Checksum error in 'Own vehicle
04020 EBS_5 configuration' block
04020 HVA Fault at output clutch main pump (pin IV/7 and III/5)
04020 INT Data bus, message EEC2 from EDC
04020 SFFR Supply voltage
04020 TBM No response to DM4 request to control unit 20
04020 ZBR2 Headlight flash button
Central control unit EEPROM: Implausible values in 'General
04021 EBS_5 wheel configuration' block
04021 INT Engine speed sensor
04021 SFFR Pedal value sensor
04021 TBM No response to DM4 request to control unit 21
04021 ZBR2 Auxiliary high beam, left
04021 ZBRO High beam 2 left
04027 SFFR Engine CAN: Time overrun when receiving EDC message EDC1
04027 TBM No response to DM4 request to control unit 27
04027 ZBR2 Fog lamp, left
04027 ZBRO Fog lamp left
Central control unit EEPROM: Checksum error in 'General CAN
04028 EBS_5 configuration' block
04028 INT CAN data bus, message EEC1 from EDC
04028 SFFR Engine CAN: Time overrun when receiving EDC message EDC2
04028 TBM No response to DM4 request to control unit 28
04028 ZBR2 Switch-on enable check lamp, fog lamps
Central control unit EEPROM: Implausible values in 'General
04029 EBS_5 function configuration' block
04029 INT CAN data bus, message TCO1 from tachograph
04029 SFFR Engine CAN: Time overrun when receiving EDC message EDC3
SD 812a en-online 05.2007 Page 216 of 276
SPN Control unit/System Fault message
04029 TBM No response to DM4 request to control unit 29
04029 ZBR2 Relay, additional fog lamps
Central control unit EEPROM: Checksum error in 'General
04030 EBS_5 function configuration' block
04030 INT LED
04030 SFFR Engine CAN: Time overrun when receiving EDC message EDC4
04030 TBM No response to DM4 request to control unit 30
04030 ZBR2 Current, parking light, tractive unit, right
Central control unit EEPROM: Implausible values in 'General
04031 EBS_5 ISR configuration' block
04031 INT CAN data bus, message CCVS from FFR
04031 SFFR Engine CAN: Time overrun when receiving EDC message EDC5
04031 TBM No response to DM4 request to control unit 31
04031 ZBR2 Current, parking light, tractive unit, left
Central control unit EEPROM: Checksum error in 'General ISR
04032 EBS_5 configuration' block
04032 INT CAN data bus, message ERC1_ER from EDC
Engine CAN: Time overrun when receiving EDC message
04032 SFFR EngineConfig
04032 TBM No response to DM4 request to control unit 32
04032 ZBR2 Current, parking light, right
Central control unit EEPROM: Implausible values in 'Own ISR
04033 EBS_5 configuration' block
04033 INT CAN data bus, message ETC1 from gearbox
MMDS CAN: Time overrun when receiving MMDS message
04033 SFFR TSC1-FME.
04033 TBM No response to DM4 request to control unit 33
04033 ZBR2 Current, parking light, left
Central control unit EEPROM: Checksum error in 'Own ISR
04034 EBS_5 configuration' block
04034 INT CAN data bus, message ETC1 from FFR
MMDS CAN: Time overrun when receiving MMDS message
04034 SFFR Time/Date
04034 TBM No response to DM4 request to control unit 34
04034 ZBR2 Side marker light, right
Central control unit EEPROM: Implausible values in 'Own ABS
04035 EBS_5 configuration' block
04035 INT CAN data bus, message ETP from EDC
MMDS CAN: Time overrun when receiving MMDS message
04035 SFFR VehDistance
04035 TBM No response to DM4 request to control unit 35
04035 ZBR2 Side marker light, left
Central control unit EEPROM: Checksum error in 'Own ABS
04036 EBS_5 configuration' block
04036 INT CAN data bus, message ERC1 from FFR
04036 TBM No response to DM4 request to control unit 36
04036 ZBR2 Current, parking light, trailer, right
04036 ZBRO Tail light right trailer
Central control unit EEPROM: Implausible values in 'Own ASR
04037 EBS_5 configuration' block
04037 INT CAN data bus, message TSC1 from FFR
04037 TBM No response to DM4 request to control unit 37
04037 ZBR2 Current, parking light, trailer, left
04037 ZBRO Tail light left trailer
Central control unit EEPROM: Checksum error in 'Own ASR
04038 EBS_5 configuration' block
04038 INT CAN data bus, time/date message from tachograph
04038 TBM No response to DM4 request to control unit 38
SD 812a en-online 05.2007 Page 217 of 276
SPN Control unit/System Fault message
04038 ZBR2 Relay, parking lights left
Central control unit EEPROM: Implausible values in 'General
04039 EBS_5 ESP configuration' block
04039 INT CAN data bus, mileage message (HRVD) from tachograph
04039 TBM No response to DM4 request to control unit 39
04039 ZBR2 Parking light switch
04039 ZBRO Parking light switch
Central control unit EEPROM: Checksum error in 'General ESP
04040 EBS_5 configuration' block
04040 INT Lamp, Bremsomat/braking control active
04040 TBM No response to DM4 request to control unit 40
04040 ZBR2 Winter service relay
Central control unit EEPROM: Implausible values in 'Own ESP
04041 EBS_5 configuration' block
04041 INT CAN data bus, ABS message from EBS/ABS
04041 TBM No response to DM4 request to control unit 41
04041 ZBR2 Relay, blackout light
Central control unit EEPROM: Checksum error in 'Own ESP
04042 EBS_5 configuration' block
04042 INT CAN data bus, FMR1 message from FFR
04042 TBM No response to DM4 request to control unit 42
04042 ZBR2 Perform lighting training again
Central control unit EEPROM: Implausible values in 'Own
04043 EBS_5 plausibility configuration' block
04043 INT Flashing code lamp
04043 TBM No response to DM4 request to control unit 43
04043 ZBR2 Interlock function, light test
Central control unit EEPROM: Checksum error in 'Own
04044 EBS_5 plausibility configuration' block
04044 INT CAN data bus, message FMR2
04044 TBM No response to DM4 request to control unit 44
04044 ZBR2 Release function, light test
Central control unit EEPROM: Implausible values from 'Error
04045 EBS_5 memory'
04045 INT CAN data bus, message EPS
04045 TBM No response to DM4 request to control unit 45
04045 ZBR2 Turn indicators operated for both directions
Central control unit EEPROM: Checksum error for 'Error
04046 EBS_5 memory'
04046 TBM No response to DM4 request to control unit 46
04046 ZBR2 ALW not calibrated
Central control unit EEPROM: Implausible values in 'Axle
04047 EBS_5 configuration' block
04047 INT Vehicle electrical system terminal 30
04047 TBM No response to DM4 request to control unit 47
04047 ZBRO Turn indicator rear left top
Central control unit EEPROM: Checksum error in 'Self-taught
04048 EBS_5 EBS data' block
04048 TBM No response to DM4 request to control unit 48
04048 ZBRO Turn indicator rear right top
Central control unit EEPROM: Checksum error in 'Own test'
04049 EBS_5 block
04049 TBM No response to DM4 request to control unit 49
04049 ZBRO Turn indicator rear left side
04050 EBS_5 Brakes CAN
04050 TBM No response to DM4 request to control unit 50
04050 ZBRO Turn indicator rear right side
04051 EBS_5 ESP sensor CAN: System bus off
04051 TBM No response to DM4 request to control unit 51
04051 ZBRO Turn indicator front left
SD 812a en-online 05.2007 Page 218 of 276
SPN Control unit/System Fault message
Electrical power supply, comparison between terminal 15 and
04052 EBS_5 terminal 30
04052 TBM No response to DM4 request to control unit 52
04052 ZBRO Turn indicator front right
04053 EBS_5 Earth 2
04053 TBM No response to DM4 request to control unit 53
04053 ZBRO School bus button
04054 EBS_5 Control unit switch-off delay: Fault in electronic circuit
04054 TBM No response to DM4 request to control unit 54
04054 ZBRO School bus button
04055 EBS_5 ASR: Invalid configuration
04055 TBM No response to DM4 request to control unit 55
04055 ZBRO School bus button check
Central control unit - B-controller: Checksum error in boot
04056 EBS_5 software
04056 TBM No response to DM4 request to control unit 56
04056 ZBRO Additional turn indicator behind bumper
04057 EBS_5 Pressure control valve
04057 TBM No response to DM4 request to control unit 57
04057 ZBRO Clicker relay
04058 EBS_5 (!) Steering angle sensor, CAN communication
04058 TBM No response to DM4 request to control unit 58
04058 ZBRO Hazard warning light switch CAN
04059 EBS_5 (!) Steering angle sensor signal
04059 TBM No response to DM4 request to control unit 59
04059 ZBRO Hazard warning light switch external
04060 EBS_5 Steering angle sensor, installed but not configured
04060 TBM No response to DM4 request to control unit 60
04060 ZBRO Headlight high beam
04061 EBS_5 (!) Yaw rate sensor, quick calibration faulty
04061 TBM No response to DM4 request to control unit 61
04061 ZBRO High-beam headlight check
04062 EBS_5 (!) Yaw rate sensor signal
04062 TBM No response to DM4 request to control unit 62
04062 ZBRO Licence plate light(s)
04063 EBS_5 (!) Yaw rate sensor, CAN communication
04063 TBM No response to DM4 request to control unit 63
04063 ZBRO Rear fog lamp
04064 EBS_5 (!) Yaw rate sensor, sensor installed incorrectly
04064 TBM No response to DM4 request to control unit 64
04064 ZBRO Rear fog lamp right
04065 EBS_5 Yaw rate sensor, installed but not configured
04065 TBM No response to DM4 request to control unit 65
04065 ZBRO Rear fog lamp left
04066 EBS_5 (!) Lateral acceleration sensor, long-time calibration incorrect
04066 TBM No response to DM4 request to control unit 66
04066 ZBRO Rear fog lamp trailer right
04067 EBS_5 (!) Transverse acceleration sensor signal
04067 TBM No response to DM4 request to control unit 67
04067 ZBRO Rear fog lamp trailer left
04068 EBS_5 (!) Steering angle sensor, long-time calibration incorrect
04068 TBM No response to DM4 request to control unit 68
04068 ZBRO Fog lamps
(!) Steering angle sensor signal, implausible with regard to
04069 EBS_5 reference rate of turn
04069 TBM No response to DM4 request to control unit 69
04069 ZBRO Fog lamps
04070 EBS_5 (!) Steering angle sensor, signal gradient
04070 TBM No response to DM4 request to control unit 70
04070 ZBRO Tail light right
SD 812a en-online 05.2007 Page 219 of 276
SPN Control unit/System Fault message
04071 EBS_5 (!) Steering angle sensor, sensor installed incorrectly
04071 TBM No response to DM4 request to control unit 71
04071 ZBRO Tail light left
04072 EBS_5 ESP sensor supply
04072 TBM No response to DM4 request to control unit 72
04072 ZBRO Side marker light 1 right
04073 EBS_5 Service brake module supply
04073 TBM No response to DM4 request to control unit 73
04073 ZBRO Side marker light 1 left
04074 EBS_5 Pressure control module, outdated driver software
04074 TBM No response to DM4 request to control unit 74
04074 ZBRO Side marker light 2 right
Inconsistent driver software status between ECU and pressure
04075 EBS_5 control module
04075 TBM No response to DM4 request to control unit 75
04075 ZBRO Side marker light 2 left
Pressure control module, checksum error in external flash
04076 EBS_5 memory
04076 TBM No response to DM4 request to control unit 76
04076 ZBRO Side marker light 3 right
04077 EBS_5 Pressure control module, installed but not configured
04077 TBM No response to DM4 request to control unit 77
04077 ZBRO Side marker light 3 left
04078 EBS_5 Trailer control module - intake valve
04078 TBM No response to DM4 request to control unit 78
04078 ZBRO Side marker light 4 right
04079 EBS_5 Trailer control module - exhaust valve
04079 TBM No response to DM4 request to control unit 79
04079 ZBRO Side marker light 4 left
04080 EBS_5 Trailer control module: Check valve
04080 TBM No response to DM4 request to control unit 80
04080 ZBRO Side marker light 5 right
04081 EBS_5 Trailer control module - pressure sensor supply
04081 TBM No response to DM4 request to control unit 81
04081 ZBRO Side marker light 5 left
04082 EBS_5 Trailer control module
04082 TBM No response to DM4 request to control unit 82
04082 ZBRO Side marker light 6 right
Trailer control module, short circuit between intake and exhaust
04083 EBS_5 valves
04083 TBM No response to DM4 request to control unit 83
04083 ZBRO Side marker light 6 left
Trailer control module, short circuit between check and intake
04084 EBS_5 valves
04084 TBM No response to DM4 request to control unit 84
04084 ZBRO Side marker light 7 right
Trailer control module, short circuit between check and exhaust
04085 EBS_5 valves
04085 TBM No response to DM4 request to control unit 85
04085 ZBRO Side marker light 7 left
04086 EBS_5 (!) Wheel sensor wheel 7
04086 TBM No response to DM4 request to control unit 86
04086 ZBRO Side marker light 8 right
Wheel sensor wheel 7: Connection cable damaged or sensor
04087 EBS_5 defective
04087 TBM No response to DM4 request to control unit 87
04087 ZBRO Side marker light 8 left
04088 EBS_5 (!) Wheel sensor wheel 8
04088 TBM No response to DM4 request to control unit 88
04088 ZBRO Parking light right
SD 812a en-online 05.2007 Page 220 of 276
SPN Control unit/System Fault message
Wheel sensor wheel 8: Connection cable damaged or sensor
04089 EBS_5 defective
04089 TBM No response to DM4 request to control unit 89
04089 ZBRO Parking light left
04090 EBS_5 Brake pad wear connection wheel 1
04090 TBM No response to DM4 request to control unit 90
04090 ZBRO Outline light rear right
04091 EBS_5 Brake pad wear sensor signal wheel 7
04091 TBM No response to DM4 request to control unit 91
04091 ZBRO Outline light rear left
Brake pad wear sensor wheel 7: Difference between the 2
04092 EBS_5 signals on the left and right sides of the axle too great
04092 TBM No response to DM4 request to control unit 92
04092 ZBRO Outline light front right
04093 EBS_5 Brake pad wear sensor signal wheel 8
04093 TBM No response to DM4 request to control unit 93
04093 ZBRO Outline light front left
Brake pad wear sensor wheel 8: Difference between the 2
04094 EBS_5 signals on the left and right sides of the axle too great
04094 TBM No response to DM4 request to control unit 94
04094 ZBRO Turn indicator check
Pressure module control unit on wheel 1, incompatible software
04095 EBS_5 components
04095 TBM No response to DM4 request to control unit 95
04095 ZBRO Turn indicator check trailer
Pressure module control unit on wheel 1, fault in electronic
04096 EBS_5 circuit
04096 TBM No response to DM4 request to control unit 96
04096 ZBRO Parking light 1 (tl. 58 for body builder)
Pressure module control unit on wheel 1, internal control unit
04097 EBS_5 test incorrect
04097 TBM No response to DM4 request to control unit 97
04097 ZBRO Parking light 2 (tl. 58 for body builder)
Pressure module control unit on wheel 1, unknown pressure
04098 EBS_5 control module fault code
04098 TBM No response to DM4 request to control unit 98
04098 ZBRO Reversing light trailer
Pressure module control unit on wheel 1, incorrect system
04099 EBS_5 monitoring after activation
04099 TBM No response to DM4 request to control unit 99
Pressure module control unit on wheel 2, incompatible software
04100 EBS_5 components
04100 TBM No response to DM4 request to control unit 100
04100 ZBR2 Headlight low beam, snowplough and gritter operation, right
Pressure module control unit on wheel 2, fault in electronic
04101 EBS_5 circuit
04101 EMOS Gearshift sensor position
04101 TBM No response to DM4 request to control unit 101
04101 ZBR2 Headlight low beam, snowplough and gritter operation, left
Pressure module control unit on wheel 2, internal control unit
04102 EBS_5 test incorrect
04102 EMOS Selection sensor position
04102 TBM No response to DM4 request to control unit 102
04102 ZBR2 Headlight high beam, snowplough and gritter operation, right
Pressure module control unit on wheel 2, unknown pressure
04103 EBS_5 control module fault code
04103 EMOS Engine signal
04103 TBM No response to DM4 request to control unit 103
04103 ZBR2 Headlight high beam, snowplough and gritter operation, left
04170 EMOS Safety device (WDC/redundant shut-off path) does not function
04170 TBM No response to DM4 request to control unit 170
04171 EBS_5 CAN signal brake on wheel 2, time overrun of message 13
04171 EMOS 'Temperature sensor next to pump output stage' signal
04171 TBM No response to DM4 request to control unit 171
04172 EBS_5 CAN signal brake on wheel 2, time overrun of message 14
04172 EMOS No pressure build-up possible during pump activation
04172 TBM No response to DM4 request to control unit 172
04173 EBS_5 CAN signal brake on wheel 2, time overrun of message 21
04173 TBM No response to DM4 request to control unit 173
04174 EBS_5 CAN signal brake on wheel 2, time overrun of message 22
04174 EMOS Vibrations on gearshift controller
04174 TBM No response to DM4 request to control unit 174
04175 EBS_5 CAN signal brake on wheel 2, time overrun of message 23
04175 EMOS Vibrations on selection controller
04175 TBM No response to DM4 request to control unit 175
04176 EBS_5 CAN signal brake on wheel 2, time overrun of message 24
04176 EMOS Vibrations on clutch controller
04176 TBM No response to DM4 request to control unit 176
04177 EBS_5 CAN signal brake on wheel 3, time overrun of message 11
04177 TBM No response to DM4 request to control unit 177
04178 EBS_5 CAN signal brake on wheel 3, time overrun of message 12
04178 TBM No response to DM4 request to control unit 178
04179 EBS_5 CAN signal brake on wheel 3, time overrun of message 13
SD 812a en-online 05.2007 Page 226 of 276
SPN Control unit/System Fault message
04179 TBM No response to DM4 request to control unit 179
04180 EBS_5 CAN signal brake on wheel 3, time overrun of message 14
Sequence monitoring has detected error in function call
04180 EMOS sequence
04180 TBM No response to DM4 request to control unit 180
04181 EBS_5 CAN signal brake on wheel 3, time overrun of message 21
04181 EMOS Security layer activated
04181 TBM No response to DM4 request to control unit 181
04182 EBS_5 CAN signal brake on wheel 3, time overrun of message 22
04182 EMOS Engaged gear cannot be ascertained
04182 TBM No response to DM4 request to control unit 182
04183 EBS_5 CAN signal brake on wheel 3, time overrun of message 23
04183 TBM No response to DM4 request to control unit 183
04184 EBS_5 CAN signal brake on wheel 3, time overrun of message 24
04184 TBM No response to DM4 request to control unit 184
04185 EBS_5 CAN signal brake on wheel 4, time overrun of message 11
04185 TBM No response to DM4 request to control unit 185
04186 EBS_5 CAN signal brake on wheel 4, time overrun of message 12
04186 EMOS Vehicle speed signals
04186 TBM No response to DM4 request to control unit 186
04187 EBS_5 CAN signal brake on wheel 4, time overrun of message 13
04187 TBM No response to DM4 request to control unit 187
04188 EBS_5 CAN signal brake on wheel 4, time overrun of message 14
04188 TBM No response to DM4 request to control unit 188
04189 EBS_5 CAN signal brake on wheel 4, time overrun of message 21
04189 TBM No response to DM4 request to control unit 189
04190 EBS_5 CAN signal brake on wheel 4, time overrun of message 22
04190 TBM No response to DM4 request to control unit 190
04191 EBS_5 CAN signal brake on wheel 4, time overrun of message 23
04191 TBM No response to DM4 request to control unit 191
04192 EBS_5 CAN signal brake on wheel 4, time overrun of message 24
04192 TBM No response to DM4 request to control unit 192
04193 EBS_5 CAN signal brake on wheel 5, time overrun of message 11
04193 TBM No response to DM4 request to control unit 193
04194 EBS_5 CAN signal brake on wheel 5, time overrun of message 12
04194 TBM No response to DM4 request to control unit 194
04195 EBS_5 CAN signal brake on wheel 5, time overrun of message 13
04195 TBM No response to DM4 request to control unit 195
04196 EBS_5 CAN signal brake on wheel 5, time overrun of message 14
04196 TBM No response to DM4 request to control unit 196
04197 EBS_5 CAN signal brake on wheel 5, time overrun of message 21
04197 TBM No response to DM4 request to control unit 197
04198 EBS_5 CAN signal brake on wheel 5, time overrun of message 22
04198 TBM No response to DM4 request to control unit 198
04199 EBS_5 CAN signal brake on wheel 5, time overrun of message 23
04199 TBM No response to DM4 request to control unit 199
04200 EBS_5 CAN signal brake on wheel 5, time overrun of message 24
04200 TBM No response to DM4 request to control unit 200
04200 ZBR2 Entry light and interior lighting, right
04201 EBS_5 CAN signal brake on wheel 6, time overrun of message 11
04201 TBM No response to DM4 request to control unit 201
04201 ZBR2 Entry light and interior lighting, left
04202 EBS_5 CAN signal brake on wheel 6, time overrun of message 12
04202 TBM No response to DM4 request to control unit 202
04202 ZBRO Interior lighting check
04203 EBS_5 CAN signal brake on wheel 6, time overrun of message 13
04203 TBM No response to DM4 request to control unit 203
04203 ZBRO Interior lighting 1
04204 EBS_5 CAN signal brake on wheel 6, time overrun of message 14
04204 TBM No response to DM4 request to control unit 204
SD 812a en-online 05.2007 Page 227 of 276
SPN Control unit/System Fault message
04204 ZBRO Interior lighting 1 continuous
04205 EBS_5 CAN signal brake on wheel 6, time overrun of message 21
04205 TBM No response to DM4 request to control unit 205
04205 ZBRO Interior lighting 1 economy
04206 EBS_5 CAN signal brake on wheel 6, time overrun of message 22
04206 TBM No response to DM4 request to control unit 206
04206 ZBRO Interior lighting 1 full
04207 EBS_5 CAN signal brake on wheel 6, time overrun of message 23
04207 TBM No response to DM4 request to control unit 207
04207 ZBRO Interior lighting 2
04208 EBS_5 CAN signal brake on wheel 6, time overrun of message 24
04208 TBM No response to DM4 request to control unit 208
04208 ZBRO Interior lighting 2 continuous
Speed sensor input on pressure regulating module wheel 1,
04209 EBS_5 faulty electronic circuit
04209 TBM No response to DM4 request to control unit 209
04209 ZBRO Interior lighting 2 economy
Speed sensor input on pressure regulating module wheel 2,
04210 EBS_5 faulty electronic circuit
04210 TBM No response to DM4 request to control unit 210
04210 ZBRO Interior lighting 2 full
Speed sensor input on pressure regulating module wheel 3,
04211 EBS_5 faulty electronic circuit
04211 TBM No response to DM4 request to control unit 211
04211 ZBRO Interior lighting 2a continuous
Speed sensor input on pressure regulating module wheel 4,
04212 EBS_5 faulty electronic circuit
04212 TBM No response to DM4 request to control unit 212
04212 ZBRO Interior lighting 2a full
Speed sensor input on pressure regulating module wheel 5,
04213 EBS_5 faulty electronic circuit
04213 TBM No response to DM4 request to control unit 213
04213 ZBRO Interior lighting 2b continuous
Speed sensor input on pressure regulating module wheel 6,
04214 EBS_5 faulty electronic circuit
04214 TBM No response to DM4 request to control unit 214
04214 ZBRO Interior lighting 2b full
Speed sensor input on pressure regulating module wheel 7,
04215 EBS_5 faulty electronic circuit
04215 TBM No response to DM4 request to control unit 215
04215 ZBRO Interior lighting 3
Speed sensor input on pressure regulating module wheel 8,
04216 EBS_5 faulty electronic circuit
04216 TBM No response to DM4 request to control unit 216
04216 ZBRO Interior lighting 3
Speed sensor input on pressure regulating module wheel 1,
04217 EBS_5 faulty electronic circuit
04217 TBM No response to DM4 request to control unit 217
04217 ZBRO Interior lighting 3 check
04218 EBS_5 (!) Speed sensor wheel 2, air gap too great
04218 TBM No response to DM4 request to control unit 218
04218 ZBRO Interior lighting 3 economy
04219 EBS_5 (!) Speed sensor wheel 3, air gap too great
04219 TBM No response to DM4 request to control unit 219
04219 ZBRO Interior lighting 3 full
04220 EBS_5 (!) Speed sensor wheel 4, air gap too great
04220 TBM No response to DM4 request to control unit 220
04220 ZBRO Night lighting
04221 EBS_5 (!) Speed sensor wheel 5, air gap too great
04221 TBM No response to DM4 request to control unit 221
SD 812a en-online 05.2007 Page 228 of 276
SPN Control unit/System Fault message
04221 ZBRO Night lighting
04222 EBS_5 (!) Speed sensor wheel 6, air gap too great
04222 TBM No response to DM4 request to control unit 222
04222 ZBRO Night lighting check
04223 EBS_5 (!) Speed sensor wheel 7, air gap too great
04223 TBM No response to DM4 request to control unit 223
04223 ZBRO Interior lighting 2c full
04224 EBS_5 (!) Speed sensor wheel 8, air gap too great
04224 TBM No response to DM4 request to control unit 224
04224 ZBRO Interior lighting 1a full
04225 EBS_5 (!) Speed sensor wheel 1, impulse wheel defective
04225 TBM No response to DM4 request to control unit 225
04225 ZBRO Interior lighting 1b full
04226 EBS_5 (!) Speed sensor wheel 2, impulse wheel defective
04226 TBM No response to DM4 request to control unit 226
04226 ZBRO Interior lighting 1c full
04227 EBS_5 (!) Speed sensor wheel 3, impulse wheel defective
04227 TBM No response to DM4 request to control unit 227
04227 ZBRO Interior lighting reduction
04228 EBS_5 (!) Speed sensor wheel 4, impulse wheel defective
04228 TBM No response to DM4 request to control unit 228
04228 ZBRO Interior lighting reduct. check
04229 EBS_5 (!) Speed sensor wheel 5, impulse wheel defective
04229 TBM No response to DM4 request to control unit 229
04229 ZBRO Footwell lighting
04230 EBS_5 (!) Speed sensor wheel 6, impulse wheel defective
04230 TBM No response to DM4 request to control unit 230
04230 ZBRO Footwell lighting
04231 EBS_5 (!) Speed sensor wheel 7, impulse wheel defective
04231 TBM No response to DM4 request to control unit 231
04231 ZBRO Aisle lighting
04232 EBS_5 (!) Speed sensor wheel 8, impulse wheel defective
04232 TBM No response to DM4 request to control unit 232
04232 ZBRO Reading lights on
04233 EBS_5 (!) Speed sensor wheel 1, tyre diameter too great
04233 TBM No response to DM4 request to control unit 233
04233 ZBRO Reading lights enable
04234 EBS_5 (!) Speed sensor wheel 2, tyre diameter too great
04234 TBM No response to DM4 request to control unit 234
04234 ZBRO Interior lighting 4
04235 EBS_5 (!) Speed sensor wheel 3, tyre diameter too great
04235 TBM No response to DM4 request to control unit 235
04235 ZBR2 Left entry lighting
04236 EBS_5 (!) Speed sensor wheel 4, tyre diameter too great
04236 TBM No response to DM4 request to control unit 236
04236 ZBR2 Right entry lighting
04237 EBS_5 (!) Speed sensor wheel 5, tyre diameter too great
04237 TBM No response to DM4 request to control unit 237
04238 EBS_5 (!) Speed sensor wheel 6, tyre diameter too great
04238 TBM No response to DM4 request to control unit 238
04239 EBS_5 (!) Speed sensor wheel 7, tyre diameter too great
04239 TBM No response to DM4 request to control unit 239
04240 EBS_5 (!) Speed sensor wheel 8, tyre diameter too great
04240 TBM No response to DM4 request to control unit 240
04241 EBS_5 Pressure module intake valve on wheel 1
04241 TBM No response to DM4 request to control unit 241
Pressure module intake valve on wheel 1, valve cannot be
04242 EBS_5 switched and is opened
04242 TBM No response to DM4 request to control unit 242
04434 ACC Driving speed limiter mode / driving speed limiter switch is on
04434 EBS_5 (!) ABS logic: Implausible activation time
04435 ACC Parking brake not released/parking brake applied
Pressure module control unit on wheel 1, inconsistent driver
04435 EBS_5 software version between ECU and boot loader
04436 ACC ABS defective/invalid
Pressure module control unit on wheel 1, checksum error in
04436 EBS_5 external flash memory
04437 ACC EBS defective/invalid
SD 812a en-online 05.2007 Page 236 of 276
SPN Control unit/System Fault message
Pressure module control unit on wheel 1, outdated driver
04437 EBS_5 software
04438 ACC Pedal brake pressed
Pressure module control unit on wheel 2, inconsistent driver
04438 EBS_5 software version between ECU and boot loader
04439 ACC Sustained-action brake lever operated
Pressure module control unit on wheel 2, checksum error in
04439 EBS_5 external flash memory
04440 ACC Sustained-action brakes 'Off'
Pressure module control unit on wheel 2, outdated driver
04440 EBS_5 software
04441 ACC ASR intervention
Pressure module control unit on wheel 3, inconsistent driver
04441 EBS_5 software version between ECU and boot loader
04442 ACC ABS intervention
Pressure module control unit on wheel 3, checksum error in
04442 EBS_5 external flash memory
04443 ACC ESP intervention
Pressure module control unit on wheel 3, outdated driver
04443 EBS_5 software
04444 ACC ACC has activated EBS for too long / brake temperature
Pressure module control unit on wheel 4, inconsistent driver
04444 EBS_5 software version between ECU and boot loader
04445 ACC Engine speed too low
Pressure module control unit on wheel 4, checksum error in
04445 EBS_5 external flash memory
04446 ACC Delay too long
Pressure module control unit on wheel 4, outdated driver
04446 EBS_5 software
04447 ACC No/invalid road speed
Pressure module control unit on wheel 5, inconsistent driver
04447 EBS_5 software version between ECU and boot loader
04448 ACC No EBS intervention possible
Pressure module control unit on wheel 5, checksum error in
04448 EBS_5 external flash memory
04449 ACC EBS status check
Pressure module control unit on wheel 5, outdated driver
04449 EBS_5 software
04450 ACC ESP defective
Pressure module control unit on wheel 6, inconsistent driver
04450 EBS_5 software version between ECU and boot loader
04451 ACC No brake pedal / invalid CAN message EBC1.Brake pedal
Pressure module control unit on wheel 6, checksum error in
04451 EBS_5 external flash memory
Sustained-action brake lever defective / invalid CAN message
04452 ACC ERC1X.Sustained-action brake lever
Pressure module control unit on wheel 6, outdated driver
04452 EBS_5 software
04453 ACC No engine / invalid CAN message EEC1.Torque
Central control unit - B-controller: Configured service brake
04453 EBS_5 module characteristic has exceeded range
Engine intervention not by ACC, driver, gearbox, HGB, FGB,
04454 ACC EDR or brake
(!) Central control unit - B-controller: Implausibly large difference
between the deceleration requirements calculated by both
04454 EBS_5 controllers
04455 ACC No engine revs / invalid CAN message EEC1.Engine revs
Central control unit - B-controller critical: Variable range overrun
04455 EBS_5 or invalid function call
04460 EBS_5 Central control unit B-controller critical: Stack memory overrun
04461 ACC Retarder intervention fault
Central control unit B-controller critical: SWI instruction or
watchdog or clock pulse generator or PLL defect or external
04461 EBS_5 interruption was activated
04462 ACC No earth
Central control unit B-controller critical: Internal microcontroller
04462 EBS_5 fault detected
04463 ACC Display defective
04463 EBS_5 Central control unit B-controller critical: Internal control unit fault
No cruise control switch / invalid CAN message CCVS.Cruise
04464 ACC control switch
04464 EBS_5 Central control unit B-controller critical: Internal control unit fault
Cruise control active in ACC mode / invalid CAN message
04465 ACC CCVS.Enable == cruise control
04465 EBS_5 Central control unit B-controller critical: Internal control unit fault
No driving speed limiter switch / invalid CAN message
04466 ACC CCVS.Driving speed limiter switch
Central control unit B-controller critical: Unused interrupt routine
04466 EBS_5 activated
No OFF sustained-action brakes / invalid CAN message
04467 ACC CCVS.IntelBremsKopl
Pressure module control unit on wheel 7: Mismatch between
04467 EBS_5 control unit types of operating software and boot loader
No cruise control lever / invalid CAN message CCVS.Off switch
04468 ACC or CCVS.Lever
Supply voltage brake pad wear sensor wheel 1: Short circuit to
04468 EBS_5 ground
No distance selector switch / invalid CAN message
04469 ACC AUX1_ZBR.Switch
Supply voltage brake pad wear sensor wheel 2: Short circuit to
04469 EBS_5 ground
Driveline fault / invalid CAN message ETC1.ShiftInProcess or
04470 ACC ETC1.DrivelineEngaged
Supply voltage brake pad wear sensor wheel 3: Short circuit to
04470 EBS_5 ground
04471 ACC Clutch fault / invalid CAN message CCVS.Clutch
Supply voltage brake pad wear sensor wheel 4: Short circuit to
04471 EBS_5 ground
SD 812a en-online 05.2007 Page 238 of 276
SPN Control unit/System Fault message
04472 ACC Clutch travel invalid
Supply voltage brake pad wear sensor wheel 5: Short circuit to
04472 EBS_5 ground
04476 EBS_5 Supply voltage brake pad wear sensor wheel 1: was deactivated
04477 ACC Engine speed too high
04477 EBS_5 Supply voltage brake pad wear sensor wheel 2: was deactivated
04478 ACC No gear or clutch disengaged / open driveline for about 10 s
04478 EBS_5 Supply voltage brake pad wear sensor wheel 3: was deactivated
04479 ACC Speed too slow
04479 EBS_5 Supply voltage brake pad wear sensor wheel 4: was deactivated
04480 ACC Speed too fast
04480 EBS_5 Supply voltage brake pad wear sensor wheel 5: was deactivated
04481 ACC Bend too tight / valid bending too great
04481 EBS_5 Supply voltage brake pad wear sensor wheel 6: was deactivated
04482 ACC No / invalid yaw rate
04482 EBS_5 Supply voltage brake pad wear sensor wheel 7: was deactivated
04483 ACC No / invalid transverse acceleration
04483 EBS_5 Supply voltage brake pad wear sensor wheel 8: was deactivated
04484 ACC Radar still in initialisation mode (after ACC initialisation mode)
(!) Trailer control module pressure control: Control piston (42) is
04484 EBS_5 defective
04485 ACC Bending is detected as invalid in CAN message
04485 EBS_5 (!) Wheel sensor: Speed comparison
Differential lock valve (differential lock switch): Installed
04486 EBS_5 component but not configured
ESP sensor voltage supply: Faulty electronic circuit in EBS
04487 EBS_5 control unit
04488 EBS_5 Central control unit B-controller: Cannot be switched OFF
04489 EBS_5 Central control unit A-controller: internal calculation error
J1939 (driveline CAN): Time overrun or fault condition in
04490 EBS_5 communication with ACC control unit on CAN (SA=0x2A)
Central control unit A-controller: Mismatch between control unit
04491 EBS_5 types of operating software and boot loader
Pressure module supply cable to wheel 1: Current magnitude
04492 EBS_5 too high
Pressure module supply cable to wheel 2: Current magnitude
04493 EBS_5 too high
Brake pad wear sensor wheel 1: Monitoring of brake pad wear
04494 EBS_5 signal (decreasing) between the axles of the vehicle
04525 ACC Driveline Can error / if Bus-Off is reached and 0.5 s afterwards.
Cabling between positive connection of the measuring coil of the
DK (pressure clutch) solenoid valve and the gearbox control
04525 DIW5 unit.
04525 ZBRO Articulation angle > 17 degrees
04526 ACC Driveline Can error / if overflow occurred in CAN controller
04526 EBS_5 ISO 11992 (trailer CAN): CAN-Low line defective
04526 ZBRO Anti-jackknife protection engine idling
Cannot send TSC1-EBS / last send message has not been sent
04527 ACC yet
04527 EBS_5 ISO 11992 (trailer CAN): CAN-High line defective
04527 ZBRO Anti-jackknife protection torque reduction
Cannot send TSC1-FFR / last send message has not been sent
04528 ACC yet
04528 EBS_5 Brakes CAN: No communication
04528 ZBRO Articulation button when driving forwards
04529 ACC EBC1 CAN message not received
04529 EBS_5 Sensor CAN: No communication
04529 ZBRO Articulation button in R gear/art. ang. > 48 deg.
04530 ACC ERC1_RX CAN message not received (engine brake)
Working coil of the SK solenoid valve (cabling between high
04530 DIW5 range clutch solenoid valve and the gearbox control unit)
Time overrun or implausible status in communication with the
04530 EBS_5 ACC control unit (SA=0x2A)
04530 ZBRO Articulation angle < 17 degrees
04531 ACC ERC1_RE CAN message not received (primary retarder)
04534 EBS_5 Supply voltage for the modules: Range underrun when starting
Not all control lever operations / CCVS (cruise control/vehicle
04535 ACC speed) message cycle too fast
Cabling between positive connection of the measuring coil of the
SK (high range clutch) solenoid valve and the gearbox control
04535 DIW5 unit.
04535 EBS_5 Supply voltage for the CAN: Range underrun when starting
04536 ACC TCO1 CAN message not received
04536 EBS_5 Supply voltage for the ESP sensors: Range underrun
04537 ACC EBC2 CAN message not received
04537 EBS_5 Supply voltage for the pressure module: Range underrun
04538 ACC EEC2 CAN message not received
Supply voltage for electronic pressure control of the pressure
04538 EBS_5 modules: Range underrun
04539 ACC ETC1 CAN message not received
Supply voltage for the pressure regulating valves: Range
04539 EBS_5 underrun
04540 ACC ETC2 CAN message not received
Working coil of the PB solenoid valve (cabling between pump
04540 DIW5 brake solenoid valve and the gearbox control unit)
04540 EBS_5 Supply voltage for the additional valve: Range underrun
04541 ACC TC1 CAN message not received
Measuring coil of the PB solenoid valve (cabling between pump
04541 DIW5 brake solenoid valve and the gearbox control unit)
04541 EBS_5 Supply voltage for the differential lock switch: Range underrun
04542 ACC VDC1 CAN message not received
04544 ACC Cannot send ACC1 / last send message has not been sent yet
04545 ACC Cannot send DM1 / last send message has not been sent yet
04553 EBS_5 External sequential fault: External input is implausible for ESP
Check TCO1 tachograph timeout / Timeout was only detected
04554 ACC by additional monitoring
Cabling between positive connection of the working coil of the
RBK (reverse gear brake small piston) solenoid valve and the
04554 DIW5 gearbox control unit.
External sequential fault: External input is implausible for EBS
04554 EBS_5 functions
Check delay / Excessively long delay was only detected in
04555 ACC additional monitoring
Cabling between positive connection of the measuring coil of the
RBK (reverse gear brake small piston) solenoid valve and the
04555 DIW5 gearbox control unit.
SD 812a en-online 05.2007 Page 244 of 276
SPN Control unit/System Fault message
Pressure module control unit on wheel 1: Axle load sensor
04555 EBS_5 electrical power supply is not switched on
04556 ACC Sensor CAN fault / if Bus-Off is reached
Pressure module control unit on wheel 1: Axle load sensor
04556 EBS_5 electrical power supply short circuit to terminal 30
04557 ACC SSTA not received
Pressure module control unit on wheel 1: incorrect / inconsistent
04557 EBS_5 data record parameter in EEPROM
04558 ACC STGT not received
04558 EBS_5 CAN signal brake on wheel 1: No communication
04559 ACC STGT2 not received
Pressure module control unit on wheel 2: Axle load sensor
04559 EBS_5 electrical power supply is not switched on
04560 ACC Radar fault / internal radar fault
Working coil of the TB solenoid valve (cabling between turbine
04560 DIW5 brake solenoid valve and the gearbox control unit)
Pressure module control unit on wheel 2: Axle load sensor
04560 EBS_5 electrical power supply short circuit to terminal 30
Radar fault / incorrect or irreparably damaged radar software
04561 ACC (ERROR_SOFTWARE1)
Measuring coil of the TB solenoid valve (cabling between turbine
04561 DIW5 brake solenoid valve and the gearbox control unit)
Pressure module control unit on wheel 2: incorrect / inconsistent
04561 EBS_5 data record parameter in EEPROM
Radar fault / Incorrect or irreparably damaged radar software
04562 ACC (ERROR_SOFTWARE2)
04613 DIW5 CAN message EBC1: CAN signals, ABS fully operational/active
04613 EBS_5 Central control unit: Temperature too high
04613 ZBRO Door 3 photoelectric barrier/sensor
CAN message EBC1: ABS fully operational / ABS system is not
04614 DIW5 OK.
Wheel sensor wheel 1: Connection cable damaged or sensor
04614 EBS_5 defective
04614 ZBRO Door 3 photoelectric barrier/sensor
Wheel sensor wheel 2: Connection cable damaged or sensor
04615 EBS_5 defective
04615 ZBRO Request stop buzzer
Wheel sensor wheel 3: Connection cable damaged or sensor
04616 EBS_5 defective
04616 ZBRO Fault value door system
Wheel sensor wheel 4: Connection cable damaged or sensor
04617 EBS_5 defective
04617 ZBRO Request for bus-stop brake by MTS
Wheel sensor wheel 5: Connection cable damaged or sensor
04618 EBS_5 defective
04618 ZBRO Door icing
Wheel sensor wheel 6: Connection cable damaged or sensor
04619 EBS_5 defective
04619 ZBRO Red/green display door system
04620 DIW5 Digital input signal for shift program selection (SP-SEL)
Output from additional valve: Short circuit between the
04620 EBS_5 connection cables
04620 ZBRO Stop lamp MTS
04621 DIW5 Digital input signal for automatic neutral shift (ANS)
04621 EBS_5 Output from additional valve: Circuit interrupted
04621 ZBRO Warning buzzer MTS
Digital input signal for ANS-LOCK (locking of automatic neutral
04622 DIW5 and standstill)
04622 EBS_5 Output from additional valve: Short circuit to ground
04622 ZBRO Door status
04623 DIW5 Digital input signal for AUX-CON (auxiliary consumer)
SD 812a en-online 05.2007 Page 248 of 276
SPN Control unit/System Fault message
04623 EBS_5 Output from additional valve: Short circuit after terminal 30
04623 ZBRO Door 1 / panel 1 check
04624 DIW5 Digital input signal for forced neutral (FRCD-NEUT)
04624 EBS_5 Output from additional valve: Short circuit in circuit
04624 ZBRO Door 1 / panel 1 button
04625 DIW5 Digital input signal for BSB-IN (bus stop brake input)
04625 EBS_5 Output from additional valve: Installed but not configured
04625 ZBRO Door 1 / panel 1 button
04626 DIW5 Digital input signal for FB-OFF (foot brake off)
04626 EBS_5 (!) Wheel sensor wheel 9
04626 ZBRO Door 1 / panel 2 check
Digital input signal for GEAR_ENBL (gear guard enable input
04627 DIW5 signal)
Wheel sensor wheel 9: Connection cable damaged or sensor
04627 EBS_5 defective
04627 ZBRO Door 1 / panel 2 button
04628 DIW5 Digital input signal for LIMP_HOME (limp home input signal)
04628 EBS_5 (!) Wheel sensor wheel 10
04628 ZBRO Door 1 / panel 2 button
Wheel sensor wheel 10: Connection cable damaged or sensor
04629 EBS_5 defective
04629 ZBRO Door 1 check
Gearbox mechanism, engine speed acquisition, gearbox output
04630 DIW5 speed acquisition, turbine speed acquisition
04630 EBS_5 Brake pad wear connection wheel 9
04630 ZBRO Door 1 check
Gearbox mechanism, gearbox output speed acquisition, engine
04631 DIW5 speed acquisition, turbine speed acquisition
04631 EBS_5 Brake pad wear sensor signal wheel 9
04631 ZBRO Door 1 emergency tap actuated
Gearbox mechanism, turbine speed acquisition, engine speed
04632 DIW5 acquisition, gearbox output speed acquisition
Brake pad wear sensor wheel 9: Difference between the 2
04632 EBS_5 signals on the left and right sides of the axle too great
04632 ZBRO Door 1 disrupted
04633 DIW5 Engine speed acquisition (sensor voltage gearbox control unit)
04633 EBS_5 Brake pad wear sensor signal wheel 10
04633 ZBRO Door 1 button
Gearbox output speed acquisition (sensor voltage gearbox
04634 DIW5 control unit)
Brake pad wear sensor wheel 10: Difference between the 2
04634 EBS_5 signals on the left and right sides of the axle too great
04634 ZBRO Door 1 button
04635 DIW5 Turbine speed acquisition (sensor voltage gearbox control unit)
Pressure module control unit on wheel 7, incompatible software
04635 EBS_5 components
04635 ZBRO Door 2 check
Pressure module control unit on wheel 7, fault in electronic
04636 EBS_5 circuit
04636 ZBRO Door 2 check
Pressure module control unit on wheel 7, internal control unit
04637 EBS_5 test incorrect
04637 ZBRO Door 2 emergency tap actuated
Pressure module control unit on wheel 7, unknown pressure
04638 EBS_5 control module fault code
04638 ZBRO Door 2 disrupted
Pressure module control unit on wheel 7, incorrect system
04639 EBS_5 monitoring after activation
SD 812a en-online 05.2007 Page 249 of 276
SPN Control unit/System Fault message
04639 ZBRO Door 2 button
Pressure module control unit on wheel 8, incompatible software
04640 EBS_5 components
04640 ZBRO Door 2 button
Pressure module control unit on wheel 8, fault in electronic
04641 EBS_5 circuit
04641 ZBRO Door 3 check
Pressure module control unit on wheel 8, internal control unit
04642 EBS_5 test incorrect
04642 ZBRO Door 3 check
Pressure module control unit on wheel 8, unknown pressure
04643 EBS_5 control module fault code
04643 ZBRO Door 3 disrupted
Pressure module control unit on wheel 8, incorrect system
04644 EBS_5 monitoring after activation
04644 ZBRO Door 3 button
Pressure module control unit on wheel 9, incompatible software
04645 EBS_5 components
04645 ZBRO Door 3 button
Pressure module control unit on wheel 9, fault in electronic
04646 EBS_5 circuit
04646 ZBRO Door 4 check
Pressure module control unit on wheel 9, internal control unit
04647 EBS_5 test incorrect
04647 ZBRO Door 4 check
Pressure module control unit on wheel 9, unknown pressure
04648 EBS_5 control module fault code
04648 ZBRO Door 4 button
Pressure module control unit on wheel 9, incorrect system
04649 EBS_5 monitoring after activation
04649 ZBRO Door 4 button
04650 DIW5 Digital output signal BRK-SIG (brake signal)
Pressure module control unit on wheel 10, incompatible software
04650 EBS_5 components
04650 ZBRO Block door panel 1
04651 DIW5 Digital output signal BSB-OUT (bus stop brake out)
Pressure module control unit on wheel 10, fault in electronic
04651 EBS_5 circuit
04651 ZBRO Block door panel 1
04652 DIW5 Digital output signal NEUT-SIG (neutral signal)
Pressure module control unit on wheel 10, internal control unit
04652 EBS_5 test incorrect
04652 ZBRO Block door panel 2
04653 DIW5 Digital output signal RG-SIG (reverse gear signal)
Pressure module control unit on wheel 10, unknown pressure
04653 EBS_5 control module fault code
04653 ZBRO Block door panel 2
04654 DIW5 Digital output signal SPD-SIG (speed signal)
Pressure module control unit on wheel 10, incorrect system
04654 EBS_5 monitoring after activation
04654 ZBRO Door release
04655 DIW5 Digital output signal TEMP-SIG (temperature signal)
Pressure module control unit on wheel 7, EEPROM data record
04655 EBS_5 is not compatible with the system
04655 ZBRO Door release
Pressure module control unit on wheel 7, EEPROM cannot be
04656 EBS_5 written
04656 ZBRO Door release checkback MTS
Pressure module control unit on wheel 8, EEPROM data record
04657 EBS_5 is not compatible with the system
SD 812a en-online 05.2007 Page 250 of 276
SPN Control unit/System Fault message
04657 ZBRO Ignition 1 on for MTS
04658 DIW5 Digital output signal STRT-ENBL (starter enable)
Pressure module control unit on wheel 8, EEPROM cannot be
04658 EBS_5 written
04658 ZBRO Light enable
04659 DIW5 Output signal PWN signal proportional to speed
Pressure module control unit on wheel 9, EEPROM data record
04659 EBS_5 is not compatible with the system
04659 ZBRO Request stop display
Pressure module control unit on wheel 9, EEPROM cannot be
04660 EBS_5 written
04660 ZBRO MTS activation (K3-CAN)
Pressure module control unit on wheel 10, EEPROM data record
04661 EBS_5 is not compatible with the system
04661 ZBRO Emergency tap
Pressure module control unit on wheel 10, EEPROM cannot be
04662 EBS_5 written
04662 ZBRO Door 1 external button
Power supply pressure module on wheel 7, short circuit to
04663 EBS_5 terminal 15
04663 ZBRO Door 1 door release checkback
04664 EBS_5 Power supply pressure module on wheel 7
04664 ZBRO Door 2 door release checkback
Power supply pressure module on wheel 7, short circuit between
04665 EBS_5 the connection cables
04665 ZBRO Door 3 door release checkback
Power supply pressure module on wheel 8, short circuit to
04666 EBS_5 terminal 15
04666 ZBRO Door 4 door release checkback
Power supply pressure module on wheel 8, short circuit to
04667 EBS_5 terminal 15
04667 ZBRO Bus-stop switching backwards
Power supply pressure module on wheel 8, short circuit between
04668 EBS_5 the connection cables
04668 ZBRO Bus-stop switching backwards
Power supply pressure module on wheel 9, short circuit to
04669 EBS_5 terminal 15
04669 ZBRO Bus-stop switching forwards
04670 EBS_5 Power supply pressure module on wheel 9
04670 ZBRO Bus-stop switching forwards
Power supply pressure module on wheel 9, short circuit between
04671 EBS_5 the connection cables
04671 ZBRO External request stop by person with disability
Power supply pressure module on wheel 10, short circuit to
04672 EBS_5 terminal 15
04672 ZBRO Display request stop by person with disability
04673 EBS_5 Power supply pressure module on wheel 10
04673 ZBRO Door malfunction
Power supply pressure module on wheel 10, short circuit
04674 EBS_5 between the connection cables
04674 ZBRO Door 1 activation (K3-CAN)
04675 EBS_5 CAN signal brake on wheel 7
04675 ZBRO Door 1 / panel 1 open
04676 EBS_5 CAN signal brake on wheel 8
04676 ZBRO Door 1 / panel 1 opening
04677 EBS_5 CAN signal brake on wheel 9
04677 ZBRO Door 1 / panel 1 closing
04678 EBS_5 CAN signal brake on wheel 10
04678 ZBRO Door 1 / panel 2 open
04679 EBS_5 CAN signal brake on wheel 7, time overrun of message 11
SD 812a en-online 05.2007 Page 251 of 276
SPN Control unit/System Fault message
04679 ZBRO Door 1 / panel 2 opening
04680 EBS_5 CAN signal brake on wheel 7, time overrun of message 12
04680 ZBRO Door 1 / panel 2 closing
04681 EBS_5 CAN signal brake on wheel 7, time overrun of message 13
04681 ZBRO Door 1 request stop display
04682 EBS_5 CAN signal brake on wheel 7, time overrun of message 14
04682 ZBRO Door 1 request stop display
04683 EBS_5 CAN signal brake on wheel 7, time overrun of message 21
04683 ZBRO Door 1 request stop by person with disability
04684 EBS_5 CAN signal brake on wheel 7, time overrun of message 22
04684 ZBRO Door 1 ignition on
04685 EBS_5 CAN signal brake on wheel 7, time overrun of message 23
04685 ZBRO Door 1 entry lighting
04686 EBS_5 CAN signal brake on wheel 7, time overrun of message 24
04686 ZBRO Door 1 in local mode
04687 EBS_5 CAN signal brake on wheel 8, time overrun of message 11
04687 ZBRO Door 2 request stop by person with disability
04688 EBS_5 CAN signal brake on wheel 8, time overrun of message 12
04688 ZBRO Door 1 ready
04689 EBS_5 CAN signal brake on wheel 8, time overrun of message 13
04689 ZBRO Door 1 standstill signal
04690 EBS_5 CAN signal brake on wheel 8, time overrun of message 14
04690 ZBRO Door 2 activation (K3-CAN)
04691 EBS_5 CAN signal brake on wheel 8, time overrun of message 21
04691 ZBRO Door 2 / panel 1 open
04692 EBS_5 CAN signal brake on wheel 8, time overrun of message 22
04692 ZBRO Door 2 / panel 1 opening
04693 EBS_5 CAN signal brake on wheel 8, time overrun of message 23
04693 ZBRO Door 2 / panel 1 closing
04694 EBS_5 CAN signal brake on wheel 8, time overrun of message 24
04694 ZBRO Door 2 / panel 2 open
04695 EBS_5 CAN signal brake on wheel 9, time overrun of message 11
04695 ZBRO Door 2 panel 2 opening
04696 EBS_5 CAN signal brake on wheel 9, time overrun of message 12
04696 ZBRO Door 2 / panel 2 closing
04697 EBS_5 CAN signal brake on wheel 9, time overrun of message 13
04697 ZBRO Door 2 request stop display
04698 EBS_5 CAN signal brake on wheel 9, time overrun of message 14
04698 ZBRO Door 2 request stop display
04699 EBS_5 CAN signal brake on wheel 9, time overrun of message 21
04699 ZBRO Door 2 ignition on
04700 DIW5 Unknown engine load source
04700 EBS_5 CAN signal brake on wheel 9, time overrun of message 22
04700 ZBRO Raise lift
04701 DIW5 CAN message EEC2, CAN signal accelerator pedal position
04701 EBS_5 CAN signal brake on wheel 9, time overrun of message 23
04701 ZBRO Raise lift
04702 DIW5 CAN message EEC1, CAN signal current engine torque
04702 EBS_5 CAN signal brake on wheel 9, time overrun of message 24
04702 ZBRO Lift in motion
CAN message EngConf, CAN signal (percent torque at point
04703 DIW5 3,4,5)
04703 EBS_5 CAN signal brake on wheel 10, time overrun of message 11
04703 ZBRO Lower lift
CAN message EEC3, CAN signal (nominal friction percent
04704 DIW5 torque)
04704 EBS_5 CAN signal brake on wheel 10, time overrun of message 12
04704 ZBRO Lower lift
04705 DIW5 CAN message EngConf, CAN signal engine reference torque
04705 EBS_5 CAN signal brake on wheel 10, time overrun of message 13
SD 812a en-online 05.2007 Page 252 of 276
SPN Control unit/System Fault message
04705 ZBRO Ramp full deployed
04706 DIW5 CAN message EEC2, engine load signal (idling switch position)
04706 EBS_5 CAN signal brake on wheel 10, time overrun of message 14
04706 ZBRO Ramp in motion
CAN message EEC1, engine load signal (nominal engine
04707 DIW5 torque)
04707 EBS_5 CAN signal brake on wheel 10, time overrun of message 21
04707 ZBRO Ramp multifunction display
Engine load source CAN: Error that cannot be diagnosed with
04708 DIW5 greater precision.
04708 EBS_5 CAN signal brake on wheel 10, time overrun of message 22
04708 ZBRO Ramp enable
04709 EBS_5 CAN signal brake on wheel 10, time overrun of message 23
04709 ZBRO Ramp enable
04710 EBS_5 CAN signal brake on wheel 10, time overrun of message 24
04710 ZBRO Ramp flashing light
04711 DIW5 Engine load source Bosch EDC
Speed sensor input on pressure regulating module wheel 9,
04711 EBS_5 faulty electronic circuit
04711 ZBRO Ramp fully retracted
Speed sensor input on pressure regulating module wheel 10,
04712 EBS_5 faulty electronic circuit
04712 ZBRO Door 2 entry lighting
04713 EBS_5 (!) Speed sensor wheel 9, air gap too great
04713 ZBRO Door 2 in local mode
04714 EBS_5 (!) Speed sensor wheel 10, air gap too great
04714 ZBRO Door 3 request stop by person with disability
04715 EBS_5 (!) Speed sensor wheel 9, impulse wheel defective
04715 ZBRO Door 2 ready
Engine load source Bosch EDC: Speed range in data record
04716 DIW5 faulty.
04716 EBS_5 (!) Speed sensor wheel 10, impulse wheel defective
04716 ZBRO Door 2 standstill signal
04717 DIW5 Engine load source Bosch EDC: Error in engine map
04717 EBS_5 (!) Speed sensor wheel 9, tyre diameter too great
04717 ZBRO Door 3 activation (K3-CAN)
Engine load source Bosch EDC: Error that cannot be diagnosed
04718 DIW5 with greater precision.
04718 EBS_5 (!) Speed sensor wheel 10, tyre diameter too great
04718 ZBRO Door 3 / panel 1 open
04719 EBS_5 Pressure module intake valve on wheel 7
04719 ZBRO Door 3 / panel 1 opening
04720 DIW5 Brake request evaluation: Unknown brake sensor in data record.
Pressure module intake valve on wheel 7, valve cannot be
04720 EBS_5 switched and is opened
04720 ZBRO Door 3 / panel 1 closing
Brake request evaluation: Impermissible brake sensor
04721 DIW5 combination in data record.
Pressure module intake valve on wheel 7, valve cannot be
04721 EBS_5 switched and is closed
04721 ZBRO Door 3 / panel 2 open
04722 DIW5 Brake request evaluation: No brake sensor set in data record.
04722 EBS_5 Pressure module intake valve on wheel 8
04722 ZBRO Door 3 / panel 2 opening
Brake request evaluation: Invalid brake sensor priority in data
04723 DIW5 record.
04736 DIW5 Brake signal source CAN: Brake pedal continuously pressed.
04736 EBS_5 Brake pad wear connection wheel 8
04736 ZBRO Door 4 / panel 2 open
Brake signal source CAN: Error that cannot be diagnosed with
04737 DIW5 greater precision.
04737 EBS_5 Pressure module exhaust valve on wheel 7
04737 ZBRO Door 4 / panel 2 opening
Pressure module exhaust valve on wheel 7, valve cannot be
04738 EBS_5 switched and is opened
04738 ZBRO Door 4 / panel 2 closing
Pressure module exhaust valve on wheel 7, valve cannot be
04739 EBS_5 switched and is closed
04739 ZBRO Door 4 request stop display
04740 DIW5 Brake sensor signal source pedal brake sensor 3-stage
04740 EBS_5 Pressure module exhaust valve on wheel 8
04740 ZBRO Door 4 ignition on
04741 DIW5 Brake sensor signal source infinitely variable (WABCO)
04770 EBS_5 (!) Wheel 10 in conjunction with ABS logic: Wheel speed fault
04770 ZBRO Waiting room
(!) Wheel 9 in conjunction with ABS logic: Change between
04771 EBS_5 active and inactive ABS intervention too fast
04771 ZBRO Door 1 preliminary storage request stop
(!) Wheel 10 in conjunction with ABS logic: Change between
04772 EBS_5 active and inactive ABS intervention too fast
04772 ZBRO Door 1 interior sign/exterior sign
External sequential fault: Time overrun in communication with
04773 EBS_5 trailer control unit 3
04773 ZBRO Switch doors back to active
External sequential fault: Time overrun in communication with
04774 EBS_5 trailer control unit 4
04774 ZBRO Switch doors back to active
External sequential fault: Time overrun in communication with
04775 EBS_5 trailer control unit 5
04775 ZBRO Door manual/automatic
(!) Pressure regulating module pressure control on wheel 7:
Pressure comparison plausibility error: Request is greater than
04776 EBS_5 the measured pressure
04776 ZBRO Request stop display 2
(!) Pressure regulating module pressure control on wheel 8:
Pressure comparison plausibility error: Request is greater than
04777 EBS_5 the measured pressure
04777 ZBRO Door 2 block
(!) Pressure regulating module pressure control on wheel 9:
Pressure comparison plausibility error: Request is greater than
04778 EBS_5 the measured pressure
04778 ZBRO Door 1 constrained closing
(!) Pressure regulating module pressure control on wheel 10:
Pressure comparison plausibility error: Request is greater than
04779 EBS_5 the measured pressure
04779 ZBRO Door 2 constrained closing
Plug and cabling of the transmission identification module (TIM,
04780 DIW5 identification data of the gearbox)
(!) Pressure regulating module pressure control on wheel 7:
Pressure comparison plausibility error: Measured pressure is
04780 EBS_5 greater than request
04780 ZBRO Door 3 constrained closing
04781 DIW5 Identification data of the gearbox (TIM)
(!) Pressure regulating module pressure control on wheel 8:
Pressure comparison plausibility error: Measured pressure is
04781 EBS_5 greater than request
04781 ZBRO Cancel stop request button
04837 EBS_5 Supply voltage brake pad wear sensor wheel 9: was deactivated
Supply voltage brake pad wear sensor wheel 10: was
04838 EBS_5 deactivated
Pressure module supply cable to wheel 7: Current magnitude
04839 EBS_5 too high
04840 DIW5 Engine control unit, gearbox control unit
Pressure module supply cable to wheel 8: Current magnitude
04840 EBS_5 too high
Pressure module supply cable to wheel 9: Current magnitude
04841 EBS_5 too high
Pressure module supply cable to wheel 10: Current magnitude
04842 EBS_5 too high
Brake pad wear sensor wheel 9: Monitoring of brake pad wear
04843 EBS_5 signal (decreasing) between the axles of the vehicle
Brake pad wear sensor wheel 10: Monitoring of brake pad wear
04844 EBS_5 signal (decreasing) between the axles of the vehicle
Brake pad wear sensor wheel 9: Monitoring of brake pad wear
04845 EBS_5 signal (decreasing) within the axles
Brake pad wear sensor wheel 10: Monitoring of brake pad wear
04846 EBS_5 signal (decreasing) within the axles
Pressure module control unit on wheel 9: Axle load sensor
04847 EBS_5 electrical power supply is not switched on
Pressure module control unit on wheel 9: Axle load sensor
04848 EBS_5 electrical power supply short circuit to terminal 30
Pressure module control unit on wheel 9: incorrect / inconsistent
04849 EBS_5 data record parameter in EEPROM
Software module event memory: Data record value
EVENTMEM_DELETE_ELEMENT_AFTER_ is set to '0' which is
04850 DIW5 not permitted.
04850 EBS_5 CAN signal brake on wheel 9: No communication
Software module event memory: An error was detected in the
04851 DIW5 software when checking the EventTab event table.
Pressure module control unit on wheel 10: Axle load sensor
04851 EBS_5 electrical power supply is not switched on
Software module event memory: A signalled event is in the
04852 DIW5 EventTab event table without reference.
Pressure module control unit on wheel 10: Axle load sensor
04852 EBS_5 electrical power supply short circuit to terminal 30
04861 DIW5 Gearshift manager: Invalid dynamic tyre radius in data record.
Pressure module exhaust valve on wheel 6, valve cannot be
04861 EBS_5 switched and is closed
04862 DIW5 Gearshift manager: Invalid axle ratio in data record.
J1939 (driveline CAN): Time overrun or fault condition in
04862 EBS_5 communication with engine control unit (SA=0x00)
Gearshift manager: Invalid maximum gear hunting time in data
04863 DIW5 record.
04863 EBS_5 Brake pad wear connection wheel 10
Gearshift manager: Invalid maximum time for a forced downshift
04864 DIW5 in data record.
Pressure module intake valve on wheel 8, valve cannot be
04864 EBS_5 switched and is closed
Gearshift manager: Incorrectly configured gearshift program in
04865 DIW5 data record.
Central control unit EEPROM: Implausible values in 'General
04865 EBS_5 ABS configuration' block
Gearshift manager: Error that cannot be diagnosed with greater
04866 DIW5 precision.
Central control unit EEPROM: Checksum error in 'General ABS
04866 EBS_5 configuration' block
External sequential fault: Time overrun or fault condition in
04867 EBS_5 communication with engine control unit (SA=0x00)
External sequential fault: Time overrun or fault condition in
communication with vehicle management computer control unit
04868 EBS_5 (SA=0x27)
External sequential fault: Time overrun or fault condition in
04869 EBS_5 communication with tachograph (SA=0xEE)
04870 DIW5 Security Manager software module
External sequential fault: Time overrun or fault condition in
04870 EBS_5 communication with TCU control unit (SA=0x03)
04871 DIW5 Identification data software module
External sequential fault: Time overrun or fault condition in
04871 EBS_5 communication with EAC control unit (SA=0x30)
04872 DIW5 Safety computer
External sequential fault: Time overrun or fault condition in
04872 EBS_5 communication with ECAS control unit (SA=0x2F)
04873 DIW5 Memory test
External sequential fault: Time overrun or fault condition in
communication with central on-board computer control unit
04873 EBS_5 (SA=0x21)
04874 DIW5 Internal system error (TRAP error)
04874 EBS_5 Steering angle sensor not calibrated
SD 812a en-online 05.2007 Page 261 of 276
SPN Control unit/System Fault message
Analog/digital converter: ADC still occupied or ADC channel
04875 DIW5 faulty.
CAN bus fault: Time overrun or fault condition in communication
04875 EBS_5 with the electronically steered rear axle
04877 DIW5 CAN message time / date
04934 DIW5 CAN receipt message, number of bytes in the receipt message
CAN receipt message, package sequence in the receipt
04935 DIW5 message
04936 DIW5 CAN receipt message TSC1, timeout of the message
04937 DIW5 CAN receipt message LFC, timeout of the message
04938 DIW5 CAN receipt message EBC5, timeout of the message
04939 DIW5 CAN receipt message EBC5, timeout of the message
04965 DIW5 The operational data structure has been set up again/modified
CAN protocol VOITH private CAN: Error that cannot be
04969 DIW5 diagnosed with greater precision.
05000 ECO2 ZF environmental condition
05000 HDS Air pressure sensor after throttle
05000 VSM Time overrun message ETC1
05000 ZBR2 Audio-visual warning device and display
05000 ZFR CAN data bus: EDC message EEC1
05001 CRT CAN message engine temperature
05001 ECO2 ZF environmental condition
05001 HDS Air pressure ahead of throttle
05001 RAS Oil level check
05001 VSM Time overrun message ETC2
05001 WSK Retarder accumulator charge valve
05001 ZBR2 Check, instrumentation failure
CAN data bus: Torque converter and clutch system message
05001 ZFR Transmission Fluid WSK
05002 CRT CAN message EEC1
05002 HDS Temperature after catalytic converter
05002 RAS Steering angle sensor front axle
05002 VSM Time overrun message ETC3
05002 WSK Valve of torque converter lockup clutch
05002 ZBRO Alarm level red (prio. 1) check
05002 ZFR CAN data bus: EDC message Eng Temp
05003 CRT CAN message BAM
05003 HDS Temperature ahead of catalytic converter
05003 RAS Steering angle sensor steered rear axle
05003 VSM Time overrun message EBC1
05003 ZBRO Switch off display lighting
05003 ZFR CAN data bus: EDC message Inlet Exhaust Condition
05004 CRT CAN messages
05004 HDS AdBlue pressure
05004 RAS Speedometer / EBC speed signal comparison
05004 WSK Retarder proportional valve
05004 ZBRO Display dimming (0-15)
05004 ZFR CAN data bus: Tachograph message TCO1
05005 CRT Exhaust temperature sensor
05005 HDS AdBlue temperature in pump module
05005 RAS Shut-off valve
05005 VSM Time overrun message EEC1
05005 WSK Retarder proportional valve, fault
05005 ZBRO Display dimming bottom pressed
05005 ZFR CAN data bus: Retarder message ERC1_RE
SD 812a en-online 05.2007 Page 263 of 276
SPN Control unit/System Fault message
05006 CRT Exhaust differential pressure sensor
05006 HDS EEPROM error
05006 RAS Control valve working circuit
05006 WSK Output earth return proportional valve
05006 ZBRO Display dimming top pressed
05006 ZFR CAN data bus: Retarder message ERC1_RX
05007 CRT Charge air temperature sensor
05007 HDS Frost monitoring
05007 RAS Deviation from setpoint in steering angle of rear axle
05007 ZBRO Display change 1
05007 ZFR CAN data bus: Retarder message ERC1_RD
05008 CRT Engine brake butterfly
05008 HDS Emergency off switch-off
05008 RAS Monitoring circuit control unit
05008 WSK Turbine speed: No signal
05008 ZBRO Display change 2
05008 ZFR CAN data bus: Retarder message Ret_Config_BAM (RE)
05009 CRT CRT temperature too low for regeneration
External hose heating (frozen line detected between tank and
05009 HDS pump module)
05009 RAS Working circuit control unit for valve control
05009 WSK Sensor, cooling water temperature
05009 ZBRO Horn
05009 ZFR CAN data bus: Retarder message Ret_Config_Packet (RE)
05010 CRT CRT is not regenerating although filter temperature is correct
05010 HDS Nitrogen oxide (NOx) sensor
05010 WSK Read-back current of the proportional valve output
05010 ZBRO Horn
05010 ZFR CAN data bus: Retarder message Ret_Config_BAM (RX)
05011 CRT CRT is blocked and must be cleaned
05011 HDS Metering on/off via CAN
05011 WSK Vehicle electrical system voltage (TL 30)
05011 ZBRO Horn a
05011 ZFR CAN data bus: Retarder message Ret_Config_Packet (RX)
05012 CRT CRT temperature too high
05012 ECO2 Load sensor (A3)
05012 HDS Air control valve
05012 RAS CAN signal, speedometer speed
05012 VSM Time overrun message Time_Date
05012 WSK Vehicle electrical system voltage (TL 15)
05012 ZBRO Horn b
05012 ZFR CAN data bus: Retarder message Ret_Config_BAM (RD)
05013 CRT Charge air temperature outside permitted tolerance range
05013 ECO2 Voltage output (5V) AU
05013 HDS Heating supply line
05013 RAS CAN signal, EBC vehicle speed
05013 VSM Time overrun message VehicleDistance
05013 ZBRO Supply instrument lighting
05013 ZFR CAN data bus: Retarder message Ret_Config_Packet (RD)
05014 CRT CAN message EEC3
05014 ECO2 Retarder control lever (A12)
05014 HDS Hose heating internal
05014 RAS CAN signal, engine speed
05014 ZBRO Display day/night changeover
05014 ZFR CAN data bus: Tachograph message TimeDate
05015 CRT CAN message time / date
05015 ECO2 Voltage failure
05015 HDS Heating pressure equalisation
05015 RAS CAN signal, weight
05015 WSK Checksum operating hours counter
SD 812a en-online 05.2007 Page 264 of 276
SPN Control unit/System Fault message
05015 ZBRO Buzzer alarm level
05015 ZFR CAN data bus: Tachograph message Vehicle Distance
05016 CRT CAN message vehicle clearance
05016 ECO2 Switch retarder (retarder pedal digital S12)
05016 HDS Pump heating in pump module
05016 RAS CAN signal, lifting axle
05016 WSK Checksum fault memory
05016 ZBRO Buzzer function indicator
05017 CRT AGR throttle
05017 ECO2 Retarder temperature sensor (B4)
05017 HDS Heating pressure line
05017 RAS CAN signal, parking brake
05017 WSK Data bus, message EEC2 from FFR
05017 ZBRO Buzzer advance warning level
05018 CRT Internal system fault
05018 ECO2 Sump temperature sensor (B14)
05018 HDS AdBlue metering module
05018 RAS CAN signal, bus transmitter-receiver
05018 VSM EEPROM error
05018 WSK Engine brake
05018 ZBRO Adv. warning level yellow (prio. 2) check
05019 CRT EEPROM memory defective
05019 HDS Coolant valve for AdBlue heating circuit
05019 RAS Calibrate parameter value
05019 WSK Internal system error control unit
05019 ZBRO On-board diagnosis fault
05020 CRT Exhaust temperature after the filter
05020 HDS AdBlue fill level plausibility error
05020 RAS ZF environmental condition
05020 VSM EEPROM error
05020 WSK Data bus, message TSC1 (braking torque)
05020 ZBRO On-board diagnosis enable
05021 CRT CAN message ETC 1
05021 ECO2 Output to gear element A valve (Y17)
05021 HDS Detection of overspeeding and pump motor blocked
05021 WSK CAN data bus, memory overflow
05021 ZBRO Horn changeover
05022 CRT CRT filter burnt out or not fitted
05022 ECO2 Output to gear element B valve (Y16)
05022 HDS Bleed valve output stage
05022 WSK CAN data bus, switched off
05022 ZBRO Horn changeover
05023 ECO2 Output to gear element C valve (Y15)
05023 HDS Blocked nozzle
05023 ZBRO Horn changeover check
05024 ECO2 Output to gear element D valve (Y14)
05024 HDS Air pressure sensor plausibility
05024 WSK CAN data bus, receive confirmation
05024 ZBRO Outside temperature
05025 ECO2 Output to gear element E valve (Y13)
05025 HDS Air control valve fault during startup
05025 RAS Calibration
05025 WSK Data bus, message EEC1 from FFR
05025 ZBRO Ice warning
05026 ECO2 Output to gear element F valve (Y12)
05026 HDS Blockage of air control valve
05026 RAS Ambient temperature
05027 ECO2 Output to gear element G valve (Y11)
Air control valve mechanically open or closed, or no compressed
05027 HDS air in circuit 4
SD 812a en-online 05.2007 Page 265 of 276
SPN Control unit/System Fault message
05027 RAS Rear axle too close to measured stop
05027 VSM Time overrun message TCO1
05027 WSK Data bus, message ETC1_TCU
05028 ECO2 Output to torque converter lock-up clutch WK valve (Y18)
05028 HDS Temperature after catalytic converter
05028 WSK Data bus, message TC1_TWSK from ASTRONIC
05029 ECO2 Output to retarder accumulator valve (Y2)
05029 HDS Detection of blocked metering module
05029 WSK Time / date message from TCO
05030 HDS Pump motor fault during startup
05030 WSK Data bus, mileage (km) message
05031 ECO2 Output to engine brake relay (K1)
05031 HDS Unable to build up AdBlue pressure
05032 ECO2 Output to gear signal relay (K2)
05032 HDS Temperatures not plausible during startup
05033 ECO2 Output to gear signal relay 2
05033 HDS AdBlue pressure not plausible
05034 ECO2 Output to speed signal relay (K3)
05034 HDS AdBlue temperature of pump module
05035 ECO2 Output to speed signal relay 2
05035 HDS AdBlue temperature of tank
05036 ECO2 Output to power take-off valve (Y3)
05036 HDS Bleed valve implausible during startup
05037 ECO2 Output to accelerator interlock valve (Y4)
05037 HDS Bleed valve implausible or return line blocked during startup
05038 ECO2 Output to load enable relay (K11)
05038 HDS Temperature fault ahead of catalytic converter
05039 ECO2 Output to detent solenoid relay (K4)
05039 HDS Temperature fault after catalytic converter
05041 ECO2 Output to selector lever lamp
05042 ECO2 Output ADVP (continuous signal)
05043 ECO2 Output to retarder brake lamp relay (K10)
05043 VSM Time overrun message EBC2
05044 ECO2 Output to proportional solenoid D1 (Y20)
05045 ECO2 Output to retarder proportional solenoid (Y1)
05046 ECO2 Selector lever (A2)
05047 ECO2 Speedo signal output via pin SD2 (A10)
05048 ECO2 PWM interface (A8)
05049 ECO2 EEPROM data checksum
05051 ECO2 CAN B application CAN
05051 HDS AdBlue quality sensor
05052 ECO2 System fault electronic control unit EST146
05053 ECO2 Malfunction SAE J 1708 (BUSOFF)
05054 ECO2 Malfunction SAE J 1708 (warning)
05055 ECO2 CAN A vehicle CAN
05056 ECO2 Output to retarder on valve (Y19)
05057 ECO2 Input speed (B13)
05058 ECO2 Output speed (B11)
05059 ECO2 Gearbox input speed (B12)
05062 ECO2 Retarder identifier (B16)
05063 ECO2 Gearbox coding
05064 ECO2 Gearbox slip monitoring
05065 ECO2 Retarder outlet temperature
05066 ECO2 Sump temperature
05067 ECO2 Digital output (AD) not occupied
05068 ECO2 Control unit reset
05071 ECO2 Temperature warning output
05072 ECO2 PWM signal oil level sensor (B15)
05073 ECO2 Temperature warning output
05074 ECO2 Temperature warning output
SD 812a en-online 05.2007 Page 266 of 276
SPN Control unit/System Fault message
05075 ECO2 Retarder sensor 'Manual' (retarder control lever digital S12)
05076 ECO2 Gear element slip time
05077 ECO2 Motor limit
05078 ECO2 WK slip monitoring
05079 ECO2 Operating voltage
05080 HDS Limit value error for exhaust mass and nitrogen oxide
05081 ECO2 Output relay selector lever 'Neutral 1'
Pressure differential between AdBlue pressure and ambient
05081 HDS pressure
05082 ECO2 Output relay selector lever 'Neutral 2'
05082 HDS Temperature sensor pump module plausibility
05083 ECO2 Output relay reversing light
05083 HDS Temperature plausibility ahead of catalytic converter
05084 ECO2 EEPROM data customer (checksum)
05084 HDS Temperature plausibility after catalytic converter
05085 ECO2 Output to status monitoring (H1)
05085 HDS Coolant valve for AdBlue heating circuit is stuck in open position
05086 ECO2 Output 'Neutral at standstill (NBS) active'
05086 HDS AdBlue tank temperature plausibility
05087 ECO2 Input terminal 15
Detection of increasing AdBlue leakage between pump module
05087 HDS and metering module
Detection of steady AdBlue leakage between pump module and
05088 HDS metering module
Plausibility error in running-on through AdBlue pressure sensor
05089 HDS (AdBlue pressure too high after blowing out)
Plausibility error in running-on through air pressure (air pressure
05090 HDS differential ahead of/after the throttle too great)
05091 ECO2 Special function 1 set in parameters
Plausibility error in running-on through vent valve (insufficient
05091 HDS pressure dissipation possible through vent valve)
05093 ECO2 D1 shift pressure adaptation upshift under load
05094 ECO2 D1 shift pressure adaptation coasting downshift
05095 ECO2 Shift time adaptation
05096 ECO2 Contact pressure adaptation
05098 ECO2 Special function 2 set in parameters
05100 HDS Dummy
05100 ZBRO Radio
05100 ZFR Additional fan
05101 ZBRO Radio
05101 ZFR Main fan
05102 ZBRO Radio check
05102 ZFR Additional compressor
05103 ZBRO Loudspeaker changeover external
05103 ZFR Speed-dependent output
05104 ZBRO Loudspeaker changeover external
05104 ZFR Additional fan valve
05105 ZBRO Loudspeaker changeover ext. check
05106 ZBRO PA system
05107 ZBRO PA system
05108 ZBRO PA system check
05109 ZBRO Input alarm system active
05110 HDS AdBlue pressure
05110 ZBRO Alarm system horn
05111 HDS Compressed air ahead of throttle
05111 ZBRO IBIS BON active
05112 HDS Engine revs
05112 ZBRO Switch on IBIS
05113 HDS Metering volume
SD 812a en-online 05.2007 Page 267 of 276
SPN Control unit/System Fault message
05113 ZBRO IBIS transmit active
05114 HDS Status
05114 ZBRO IBIS external loudspeaker
05115 ZBRO IBIS mike active
05116 ZBRO IBIS control input 1 (output)
05117 ZBRO IBIS control input 2 (output)
05118 ZBRO IBIS call
05119 ZBRO IBIS call active
05120 HDS Monitoring error in monitoring module
05120 ZBRO IBIS acknowledgement
05121 ZBRO IBIS acknowledgement active
05122 ZBRO IBIS door criterion
05126 ZBRO Switch canceller OFF
05127 ZBRO Output canceller OFF
05128 ZBRO Switch IBIS OFF
05129 ZBRO Output IBIS OFF
05130 ZBRO Switch coin box OFF
05131 ZBRO Output coin box OFF
05200 ZBRO Driver's area door
05201 ZBRO Driver's area door
05202 ZBRO Driver's area door check
05203 ZBRO Driver's area door buzzer
05204 ZBRO Destination box lighting
05205 ZBRO Destination box lighting
05206 ZBRO Destination box lighting Check
05207 ZBRO Paying console/driver's area lighting
05208 ZBRO Paying console/driver's area lighting
05209 ZBRO Paying console/driver's area lighting check
05210 ZBRO Paying console socket
05211 ZBRO Paying console socket
05212 ZBRO Paying console socket check
05213 ZBRO Paying console lighting 1
05215 ZBRO Driver's area lighting
05216 ZBRO Driver's area lighting 1
05217 ZBRO Driver's area lighting
05218 ZBRO Paying console activation coin box
05219 ZBRO Paying console activation coin box
05300 ZBRO Economy circuit front-end heater
05301 ZBRO Front-end heater circulating pump
05302 ZBRO Front-end heater inclined seat valve
05303 ZBRO Roof ventilator
05304 ZBRO Roof ventilator left
05305 ZBRO Roof ventilator right
05306 ZBRO Roof duct heating
05307 ZBRO Roof duct ventilation
05308 ZBRO Roof hatch check
05309 ZBRO Roof hatch 1 rear open
05310 ZBRO Roof hatch 1 rear open
05311 ZBRO Roof hatch 1 completely open
05312 ZBRO Roof hatch 1 front open
05313 ZBRO Roof hatch 1 front open
05314 ZBRO Roof hatch 2 rear open
05315 ZBRO Roof hatch 2 rear open
05316 ZBRO Roof hatch 2 completely open
05317 ZBRO Roof hatch 2 front open
05318 ZBRO Roof hatch 2 front open
05319 ZBRO Heating
05320 ZBRO Air-conditioning requested
05321 ZBRO Cool driver's area
05322 ZBRO Coolant valve driver's area
SD 812a en-online 05.2007 Page 268 of 276
SPN Control unit/System Fault message
05323 ZBRO Set driver's area to recirculating air
05324 ZBRO Recirculation ventilation hatch front-end
05325 ZBRO Roof duct blower reduction
05326 ZBRO Ice warning air-conditioning
05327 ZBRO Air-conditioning fault
05328 ZBRO Set roof to fresh air
05329 ZBRO Ventilation hatch roof +
05330 ZBRO Compressor activated
05331 ZBRO Input check air-conditioning
05332 ZBRO Air conditioning idling speed increase
05333 ZBRO Engine running to air-conditioning
05334 ZBRO Terminal 58 to air-conditioning
05335 ZBRO Air-conditioning circulating pump on
05336 ZBRO Inclined seat valve from air-conditioning
05337 ZBRO Auxiliary heater to air-conditioning
05338 ZBRO Ventilation
05339 ZBRO Passenger area heater stage 1
05340 ZBRO Heater fan 1 left stage 1
05341 ZBRO Heater fan 2 left stage 1
05342 ZBRO Heater fan 3 left stage 1
05343 ZBRO Heater fan 2a right stage 1
05344 ZBRO Heater fan 2b right stage 1
05345 ZBRO Passenger area heater stage 2
05346 ZBRO Heater fan 1 left stage 2
05347 ZBRO Heater fan 2 left stage 2
05348 ZBRO Heater fan 3 left stage 2
05349 ZBRO Heater fan 2a right stage 2
05350 ZBRO Heater fan 2b right stage 2
05351 ZBRO Heater fan 2c right stage 2
05352 ZBRO Interior thermostat (low=heating)
05353 ZBRO Circulating pump a cooling water
05354 ZBRO Circulating pump b cooling water
05355 ZBRO Inclined seat valve cooling water
05356 ZBRO Valve convector heating
05357 ZBRO Auxiliary heater check
05358 ZBRO Auxiliary heater economy circuit
05359 ZBRO Auxiliary heater pre-set timer
05360 ZBRO Auxiliary heater pre-set timer
05361 ZBRO Auxiliary heater water v./circ. pump
05362 ZBRO Roof ventilator
05363 ZBRO Roof ventilator
05364 ZBRO Roof ventilator
05365 ZBRO Roof ventilator a
05366 ZBRO Roof ventilator b
05367 ZBRO Ventilation hatch roof -
05368 ZBRO Set roof to recirculating air
05369 ZBRO Recirculation ventilation hatch roof +
05370 ZBRO Recirculation ventilation hatch roof -
05371 ZBRO Interior thermostat fault
05372 ZBRO Air-conditioning auxiliary heater request
05373 ZBRO Passenger area heater stage 1
05374 ZBRO Passenger area heater stage 2
05375 ZBRO Interior thermostat (low=heating)
05376 ZBRO Interior thermostat (high=heating)
05377 ZBRO Roof ventilator fault
05378 ZBRO Auxiliary heater fault
05379 ZBRO Air-conditioning fault
05380 ZBRO Driver's fan switched off or fault
05381 ZBRO Driver's fan fault
05382 ZBRO Pedestal heater stage 1
SD 812a en-online 05.2007 Page 269 of 276
SPN Control unit/System Fault message
05383 ZBRO Pedestal heater stage 2
05384 ZBRO Pedestal heater stage 1
05385 ZBRO Pedestal heater stage 2
05386 ZBRO Sw. driver's fan 2nd stage switched off or defective
05387 ZBRO Driver's fan stage 1
05388 ZBRO Driver's fan stage 2
05389 ZBRO Roof hatch 3 rear open
05390 ZBRO Roof hatch 3 rear open
05391 ZBRO Roof hatch 3 completely open
05392 ZBRO Roof hatch 3 front open
05393 ZBRO Roof hatch 3 front open
05394 ZBRO Water pump requested
05395 ZBRO Parking lights heating control
05396 ZBRO Auxiliary heater requested via passenger area heater
05397 ZBRO Recirculation/ventilation hatch
05398 ZBRO Recirculation/ventilation hatch
05399 ZBRO Interior thermostat forebody fault
05400 ZBRO Driver's seat heating switch
05401 ZBRO Driver's seat heating
05402 ZBRO ATC fault
05403 ZBRO Air-conditioning system lower deck
05404 ZBRO Air-conditioning system upper deck
05500 HDS CAN error (no AAI message)
05500 ZBRO Window heater
05501 HDS CAN error (no ABC message)
05501 ZBRO Window heater
05502 HDS CAN error (no ATI message)
05502 ZBRO Mirror heaters
05503 HDS CAN error (no EEC1 message)
05503 ZBRO Mirror heater left
05504 HDS CAN error (no ETP message)
05504 ZBRO Mirror heater right
05505 HDS CAN error (no CEXH message)
05505 ZBRO Door window heater
05506 HDS CAN error (no FEC message)
05506 ZBRO Door window heater a
05507 HDS CAN error (no IEC message)
05507 ZBRO Door window heater b
05508 HDS CAN error (no NO1 message)
05508 ZBRO Door window heater c
05509 HDS CAN error (no PRO message)
05509 ZBRO Door window heater d
05510 HDS CAN error (no CTDA message)
05510 ZBRO Windscreen heater
05511 HDS Control unit or 'Heating on' faulty
05511 ZBRO Windscreen heater
05512 HDS CAN error (no CVDR message)
05513 HDS CAN error (no CUQS message)
05514 HDS Catalytic converter has been thermally overloaded
05515 HDS AdBlue fill level is in 'reserve area'
05516 HDS Exhaust gas mass outside the limits
05600 KSM Cab lock.
05600 ZBR2 Cab lock
05700 ZBR2 ACC rated distance
05800 ZBRO Check CSR2
05801 ZBRO Check CSR2
05802 ZBRO Check CSR3
05803 ZBRO Check CSR3
05804 ZBRO Check CSR4
05805 ZBRO Check CSR4
SD 812a en-online 05.2007 Page 270 of 276
SPN Control unit/System Fault message
05806 ZBRO Check CSR5
05807 ZBRO Check CSR5
05808 ZBRO Check CSR6
05809 ZBRO Check CSR6
05810 ZBRO Switch CSR1 bottom pressed
05811 ZBRO Switch CSR1 bottom pressed
05812 ZBRO Switch CSR1 top pressed
05813 ZBRO Switch CSR1 top pressed
05814 ZBRO Switch CSR1 check
05815 ZBRO Switch CSR2 bottom pressed
05816 ZBRO Switch CSR2 bottom pressed
05817 ZBRO Switch CSR2 top pressed
05818 ZBRO Switch CSR2 top pressed
05819 ZBRO Switch CSR2 check
05820 ZBRO Switch CSR4 bottom pressed
05821 ZBRO Switch CSR4 bottom pressed
05822 ZBRO Switch CSR4 top pressed
05823 ZBRO Switch CSR4 top pressed
05824 ZBRO Switch CSR4 check
05825 ZBRO Switch CSR5 bottom pressed
05826 ZBRO Switch CSR5 bottom pressed
05827 ZBRO Switch CSR5 top pressed
05828 ZBRO Switch CSR5 top pressed
05829 ZBRO Switch CSR5 check
05830 ZBRO Switch CSR6 bottom pressed
05831 ZBRO Switch CSR6 bottom pressed
05832 ZBRO Switch CSR6 top pressed
05833 ZBRO Switch CSR6 top pressed
05834 ZBRO Switch CSR6 check
05835 ZBRO Switch CSR7 bottom pressed
05836 ZBRO Switch CSR7 bottom pressed
05837 ZBRO Switch CSR7 top pressed
05838 ZBRO Switch CSR7 top pressed
05839 ZBRO Switch CSR7 check
05840 ZBRO Switch CSR8 bottom pressed
05841 ZBRO Switch CSR8 bottom pressed
05842 ZBRO Switch CSR8 top pressed
05843 ZBRO Switch CSR8 top pressed
05844 ZBRO Switch CSR8 check
05900 ZBRO Speed signal
05901 ZBRO Speed signal fault
05902 ZBRO Speed signal
06000 ZBR2 TCO1 message, tachograph
06001 ZBR2 ACC
06002 ZBR2 Date / time
06003 ZBR2 Road speed governing, road speed
06004 ZBR2 Instrumentation
06005 ZBR2 EBC1 message, EBS
06006 ZBR2 ECAS1 message, ECAS
06007 ZBR2 ECAM1 message, ECAM
06008 ZBR2 EEC1 message, FFR
06009 ZBR2 ERC_RD message, secondary retarder
06010 ZBR2 ERC_RE message, primary retarder
06011 ZBR2 Engine oil pressure
06012 ZBR2 Coolant temperature
06013 ZBR2 Ambient conditions missing, FFR message
06014 ZBR2 FFR
06015 ZBR2 EBC2 missing message, EBS
06016 ZBR2 EBC3 missing message, EBS
06017 ZBR2 EBC4 missing message, EBS
SD 812a en-online 05.2007 Page 271 of 276
SPN Control unit/System Fault message
06018 ZBR2 Engine speed missing
06019 ZBR2 ETC1 missing message, FFR
06020 ZBR2 ETC2 missing message, FFR
06021 ZBR2 ETC3 missing message, FFR
Fuel consumption missing, total fuel consumption / consumption
06022 ZBR2 since last reset
06023 ZBR2 Fuel economy missing, fuel consumption in litres per hour
06024 ZBR2 Inlet/exhaust conditions missing, boost pressure information
06025 ZBR2 TC1_FT missing, FFR message to automatic gearbox
06026 ZBR2 ACC1 message missing, display message from ACC
Aux_stat_ZBR_1 not on T-CAN, switch message 1 not on T-
06027 ZBR2 CAN
06030 ZBR2 ERC1_RX missing, engine brake message missing from FFR
06041 ZBR2 Vehicle weight (ECAS) missing, vehicle weight (ECAS) missing
08129 INST CAN message central on-board computer: DM1 body controller
08129 STON Failure of DM1 Body Controller message (monitoring)
CAN message EDC: Cruise control vehicle speed for cruise
08130 INST control function (CCVS)
08130 STON Failure of CC/VHS message (cruise control function)
08131 STON Failure of vehicle identification message (chassis number)
Failure of Transmission Fluids exclusive message or
08132 STON Transmission Fluids converter and clutch unit message