You are on page 1of 11

Journal of Environmental Management 187 (2017) 43e53

Contents lists available at ScienceDirect

Journal of Environmental Management


journal homepage: www.elsevier.com/locate/jenvman

Research article

Evaluation of permeable pavement responses to urban surface runoff


Meysam Kamali a, Madjid Delkash b, Massoud Tajrishy a, *
a
Department of Civil and Environmental Engineering, Sharif University of Technology, Tehran, Iran
b
Department of Civil and Environmental Engineering, University of Delaware, Newark, DE, USA

a r t i c l e i n f o a b s t r a c t

Article history: The construction of permeable pavement (PP) in sidewalks of urban areas is an alternative low impact
Received 25 July 2016 development (LID) to control stormwater runoff volume and consequently decrease the discharge of
Received in revised form pollutants in receiving water bodies. In this paper, some laboratory experiments were performed to
9 November 2016
evaluate the efficiency of a PP subjected to sediment loadings during its life span. Simple infiltration
Accepted 13 November 2016
Available online 20 November 2016
models were validated by the laboratory experiments to evaluate the trend and extend of PP infiltration
capacity throughout the life of the pavement operation. In addition, performances of the PP in removing
þ
total suspended solids (TSS) and selective nutrient pollutants such as NO 3 ; NH4 and PO4
3 from the
Keywords:
Permeable pavement
surface runoff have been investigated. Experimental data showed that the PP was completely clogged
Urban runoff after seven hydrological years. The model revealed that the ratio of horizontal to vertical hydraulic
Clogging conductivity is 3.5 for this PP. Moreover, it was found that 20% reduction in hydraulic conductivity
Sediments removal occurred after three hydrological years. The PP showed 100%, 23% and 59% efficiencies in sediment
þ
Nutrient removal retention (TSS removal), ðPO34 Þ, and N  NH4 removal during the entire study, respectively. However,
the removal efficiency of ðN  NO 3 Þ was 12% and we suspect the increase in effluent ðN  NO 3 Þ is due
to the nitrification process in subsurface layers. This study demonstrated that when PPs are annually
cleaned, it is expected that PPs can function hydraulically and be able to remove particulate pollutants
during their life span by a proper maintenance.
© 2016 Elsevier B.V. All rights reserved.

1. Introduction sidewalks using double ring infiltrometer tests (e.g. Qin et al., 2013;
Valinski and Chandler, 2015); however as far as authors' knowledge
Urban development increases impermeable surfaces such as permits, literature lacks studies that cover the hydraulic perfor-
pavements and buildings that diminish water infiltration to the mances of a sidewalk PP under clogging. Therefore, the authors
ground and increase runoff volume (Finkenbine et al., 2000; Nie present the literature that has studied the clogging process of PPs
et al., 2011). This runoff that was induced by impermeable sur- with the most similarity to our experimental setup. Several in-
faces, washes out pollutants from urban areas and carries them to vestigations have been performed to evaluate the performance of
waterbodies (Davis et al., 2001). Urban runoff has been known as a PPs for water quality and some representative example studies are
primary pollutant source. About 46% of surface water pollution is examined here. For instance, TSS contain attached heavy metals,
attributed to urban runoff (Chai et al., 2012; USEPA, 1996). There- which remarkably prevent aquacultural growth (Brown et al.,
fore, controlling urban runoff quantity and quality seems vital to 2009). PPs have revealed acceptable performances for TSS
properly maintain watercourses. Among several practices devel- removal from runoff. Morquecho et al. (2005) showed that a PP can
oped to obviate the abovementioned issues, the PP is known as a reduce TSS, turbidity and total phosphorus more than 50%. Tota-
LID that can mitigate first flush impacts and decrease volume of Maharaj and Scholz (2010) reported that TSS, N  NH4þ and
runoff as well as treatment costs (Sansalone and Teng, 2005; P  PO3 removal efficiencies for a PP were 91%, 84.6% and 77.5%,
4
Andersen et al., 1999). respectively. In another study, Collins (2007) asserted that a PP
Several researches have investigated infiltration rates of PPs in
noticeably decreased N  NH4þ and increased N  NO 3 effluent
concentrations compared to the asphalt pavement. Although PPs
have shown acceptable performances in TSS and some other
* Corresponding author.
E-mail addresses: meisamkamali_63@yahoo.com (M. Kamali), delkash@udel.
pollutant removal, the poor PP construction and maintenance lead
edu (M. Delkash), tajrishy@sharif.edu (M. Tajrishy). to sediments accumulation into the PP structure, which causes

http://dx.doi.org/10.1016/j.jenvman.2016.11.027
0301-4797/© 2016 Elsevier B.V. All rights reserved.
44 M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53

clogging. This clogging reduces PP popularity when compared to 2.1.1. PP module


the other practices (Bean et al., 2007). Several studies have been The schematic diagram of a PP module is depicted in Fig. 1a. The
investigated to assess clogging behaviors of PPs (Coleri et al., 2013; experimental area of this PP was about 2 m2 (2 m by 1 m) and
Kayhanian et al., 2012a). Types of sediments as well as methods of pavement was constructed at 2% slope. The experimental PP
applying sediments to PPs vary in literature. Sediments introduced module comprised of three different layers: (1) top layer includes
to a PP might be real samples during urban runoff campaigns or can concrete blocks with 4 cm height and 0.5 cm gaps between the two
be artificially provided (Siriwardene et al., 2007). Further, sedi- adjacent blocks; the gaps were filled with granular gravel size
ments can be applied to PPs either manually (Castro et al., 2007; ranging from 2.36 mm to 4.75 mm, (2) middle layer that consists of
Coleri et al., 2013), or by precipitation (Pezzaniti et al., 2009); 5 cm granular filter, which is comprised of granular gravel in the
however, the pavements in sidewalks are frequently cleaned and range of 2.36e4.75 mm, and (3) the bottom subbase pebble gravel
majority of the sediments are entered through surface runoff; layer with 12 cm height and granular particle size between 4.75 and
therefore, applying the sediments by runoff is a more realistic 20 mm. In addition, a geotextile fabric was installed in the bottom
experimental setup. of the granular filter (second layer) and subbase layer (third layer).
From the literature review and some of the aforementioned The top geotextile layers were installed to prevent downward flow
studies, generally the PP performances were evaluated under un- of particles into the subbase layer. The bottom geotextile layer was
realistic conditions. For instance, the simulated rainfall and applied added to prevent particle upflow movements from subbase soil into
sediments were not in accordant with real sediment loads and the subbase layer.
precipitation conditions. Therefore, experimental observations Using the rainfall records from the nearest weather station in
might differ from field observations. Pezzaniti et al. (2009) assessed Tehran (Mehrabad weather station, about 2.5 km far from the
the effective life of a PP in both laboratory and field works. Their studied streets) as well as design method suggested by the Iowa
results showed that in the field, clogging happened at a faster rate stormwater management manual for pavement systems (Iowa
compared to the laboratory work. Our study was performed by Stormwater Management, 2009), we estimated the depth of
conducting experiments through applying clean simulated rainfall reservoir layer to be about 25 cm. According to this manual, curve
(no suspended solid) from the top of the PP (representing rainfall) number, ratio of impermeable pavement to permeable pavement,
and simulated runoff with sediments that was flown from a side. In void ratio of aggregate base, and design rainfall event were
addition to this unique experimental setup, we developed a model assigned 98, 3, 0.4, and 30 mm, respectively. However, due to
to understand the water flow in this PP structure. This approach limitations in the PP modular dimension and weight, the depth of
was used to evaluate the temporal and spatial clogging trends in 12 cm was considered. The 13 cm reduction in depth was mostly
this PP and hence to find the vulnerability of the PP to sediment associated with the subbase layer that might be more significant for
loadings during rainfalls. We defined clogging in terms of the PP design with higher traffic speeds as well as load applications and
accumulation of silt within the pavement structures that corre- will be insignificant for clogging investigations in sidewalks. For
sponds to a decrease in the hydraulic conductivity of the PP (Castro example, it has been documented that pavement failure due to
et al., 2007). Castro et al. (2007) related the clogging due to the clogging is mostly associated with particles trapped in surface or
reduction in hydraulic conductivity to the entrapments of particles upper subsurface of PP pavements (Teng and Sansalone, 2004;
in the upper surface layer as well as the accumulations of particles Kayhanian et al., 2012a; Coleri et al., 2013), which is usually inde-
on the geotextile fabric. Recognizing susceptible spots for clogging pendent of bottom layer depths. Therefore, the proposed depth in
in PPs would help to locate the failed locations and to properly our experimental setup is justified in accordance with the study
clean it through an optimum maintenance schedule. One other objectives.
important feature of our investigation was addressing the pattern
of water flow through the PP as a porous media to determine the 2.1.2. Rainfall and sediment simulator setup
fraction of the total water that enters the PP and horizontally flows A schematic diagram of the rainfall and sediment loading
for sizing the drainage system in PPs. simulator is shown in Fig. 1b. Different setups were examined to
This study aims at examining performances of a PP, used in find the highest uniformity in the rainfall applied to the PP. In order
sidewalks, during a flow of runoff that contains sediment loads. We to achieve the highest uniformity, the number of nozzles and their
present the clogging steps as a runoff was exposed to the PP using heights with respect to the surface of the PP were changed. The best
specific sediment samples that were collected from some streets in experimental setup, whose uniformity was high, had a 2 m height
Tehran, Iran. Using our experimental measurements, a simple from the PP surface and 3 nozzles in one row. With some limita-
model was developed to find out the capacity of the PP, the chro- tions in our experimental set up, we calibrated the intensity of the
nological clogging trend and its age (we defined the age of the PP as rainfall simulator and found to be 36 mm/h, which is fairly close to
the time before runoff overflows the PP). Although evaluating the the average rainfall intensity in Tehran (Tehran's mean annual
PP clogging by sediments was taken as the primary objective of this rainfall ¼ 240 mm with majority of rainfall events last about 6 h and
study, the performances of the PP in removing some pollutants therefore the average hourly rainfall intensity is equal to 40 [¼240/
þ
such as TSS, PO3 
4 ; NH4 and NO3 removal were also investigated.
6] mm/hr). In order to meet the annual rainfall, the system worked
for 6.67 h (¼240/36) in each hydrological year. The rainfall simu-
lator was operated with clean tap water and applied on top of the
PP and let the water flow downward through different pavement
layers.
2. Methodology In addition to applying clean rainfall from top, an artificial sur-
face runoff was also introduced to the PP from one side (see Fig. 1b).
2.1. Experimental setup This type of PP is planned to be implemented in pedestrians of
Tehran. It will convert impermeable surfaces, which have three
Fig. 1 displays the schematic diagram of the experimental setup times greater surface area than permeable surfaces, to permeable
used to evaluate the performance of our PP under different labo- pavements. Thus the flowrate of runoff was three times larger than
ratory conditions. Several important features of the experimental rainfall intensity to be consistent with real conditions. This applied
setup are described below. runoff containing sediments in some of the experiments allowed us
M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53 45

Joints
Permeable block paved layer

40 mm Filter layer (Ds=2.36-4.75 mm)


50 mm
Geotextile
120 mm Subbase layer (Ds= 4.75 - 20 mm)

Geotextile

(a)

Rainfall simulator

Rainfall tank Artificial runoff

Permeable pavement

Bypass

600 cm 320cm 400 cm 600 cm


Tap water
Tap water F

F
Artificial runoff (Tap P First Second Third Fourth
water with sediments) P segment segment segment segment
(diameter<150 μm))

(b)

Fig. 1. (a) PP module with specified layers, and (b) schematic diagram of experimental setup.

to investigate the impact of particles in surface and subsurface 2.2. Formulation of the runoff transport in the PP
clogging.
Schematic diagram for experimental setup related to the
formulation of runoff transport over and through PP module is
2.1.3. Piezometers installation and hydraulic head measurements shown in Fig. 2. As shown, the PP module was divided into four
As mentioned before, this study defines clogging in terms of a segments. Water discharge ðqij Þ was measured for each of these
decrease in hydraulic conductivity values of the PP due to the segments (j index) at different times (i index). Water mass balance
accumulation of silt within the PP structure. On the other hand, a was taken into account for each segment. The applied runoff can
decrease in hydraulic conductivity of the surface corresponds to a infiltrate into each segment of the PP or keep flowing as surface
drop in the piezometric head in that spot. Therefore, any unusual runoff and infiltrate into the next segment (based on infiltration
drop in piezometric head in the PP indicates clogging in that spot. rate and hydraulic conductivity values). Water inside the segment
These drops were utilized to confirm the results of our model about can discharge from that segment (and the system) downward or
clogging spots and times. In this study, piezometric heads were drain in the adjacent segment horizontally according to the hy-
measured by 20 piezometers that were installed in different loca-  
tions of the PP. We assigned five piezometers to one segment of the draulic conductivity ratio KKhv . This horizontal flow is expressed by
PP to have a good distribution of piezometric heads. Therefore, the
(eq. (1)). Mass balance considers a steady precipitation (P)
PP was divided into four segments that can contribute in the total distributed uniformly on the PP as well as applied influent runoff,
PP drainage. The numbers shown in the arrows in Fig. 1b display the
horizontal water drainage ðdij Þ from each segment, and effluent
areas that are swept by each segment. The discharge in these seg-
discharge ðqij Þ from that. The mass balance relationship for each
ments were measured by dividing the water level rise in a marked
segment is shown in (eq. (2)). A quasi-steady state condition was
bucket into the time intervals. These discharge values were
assumed here for infiltration meaning that infiltration rate is con-
employed for model validation as well as prediction of the location
stant between two consecutive measurements.
and time of clogging occurrences. The approach that these mea-
surements were used in the model is explained in the latter section.  
Kh
Effluent water discharge from the first to fourth segments shows dij ¼ *qij (1)
the “drainage path” in the PP. This path is defined as the length
Kv
between the point that surface flow enters the PP and where it
leaves the PP. An increase in effluent water discharge in farther Iij þ diðj1Þ ¼ dij þ qij (2)
segments is accompanied with an increase in drainage path and
clogged surfaces (Castro et al., 2007). where Iij infiltration rate (m/s) at time (i) into segment (j), diðj1Þ
46 M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53

Fig. 2. Scheme of PP module with variables used to develop a model to formulate runoff transport in the PP (Note: P ¼ simulated rainfall precipitation, Rj ¼ runoff rate over jth
segment, Ij ¼ infiltration rate into the jth segment, dj ¼ horizontal drainage rate into jth segment, qj ¼ effluent discharge rate from jth segment).

horizontal water drainage (m/s) at time (i) from segment (j-1) into 2.3. Laboratory experiments
segment (j), qij water exiting discharge (m/s) from segment (j) at
time (i). Three different experimental sets were performed under labo-
Porous media infiltration is dependent of hydraulic conductivity ratory conditions. The first experiment was implemented to
 
calculate the hydraulic features of the PP as a basis to evaluate
at a certain soil saturation ðKq Þ and a hydraulic head gradient DLH clogging. Then the obtained hydraulic conductivity ratio will be
as expressed by (eq. (3)): validated by another experiment. The second experimental set was
executed under sediment loadings and particles entrapments in
DH void spaces, which cause clogging. The third experiment was car-
I ¼ Kq (3)
L ried out to evaluate the performance of the PP in removal of some
selective pollutants, which are concern in urban road surface
where L is the total height of a porous media (m), DH is the dif- runoff.
ference of total head between up and downstream of fluid into the
porous media (m). Total head in the porous media is made of matric
potential (h) and elevation height (z): (H¼h þ z). 2.3.1. Experiment set 1: performance evaluation of PP based on
To study the PP responses to urban runoff and to evaluate the hydraulic response (No sediment)
clogging trends, a modeling approach was used to estimate hy- Since there is no water storage and clogging in the first exper-
iment, this experiment was performed to obtain the ratio of the
draulic conductivity. In this paper, it was assumed that PP rapidly  
meets the saturated condition. Main reason for this assumption was horizontal to vertical hydraulic conductivities KKhv of the PP. This
that the major portion of total depth (21 cm) of the PP was domi-
nated with granular and pebble gravels, so matric potential is ratio plays an important role in the horizontal water transport in
neglected for these large particles ðDðhÞ < DðzÞÞ. Hence, it is ex- porous mediums. It is estimated to be around 10 for natural soils
pected that the hydraulic conductivity immediately reaches its that have clay and other cohesive materials. However, the PP used
saturated values ðKq zKsat Þ. In addition, it was assumed that in this study was primarily made of granular and pebble gravels and
ponding height ðHponding Þ on the PP is much smaller than the PP hence, it is expected that this ratio would be smaller than normal
soils (less horizontal movements due to less matric suctions). To
column (L) ðz ¼ Hponding þ L; Hponding ≪LÞ. Thus, the infiltration  
rate (I) value was estimated by the saturated hydraulic conductivity find the value of KKhv in this PP, rainfall with the intensity of
ðKsat Þ that is shown in (eq. (4)).
36 mm/h and runoff (without sediment) with the runoff rate of
  108 mm/h were applied to the PP. Piezometric heads in the storage
DH Dðh þ zÞ Hponding L
I ¼ Kq ¼ Kq z  Ksat þ z  Ksat layer were measured by piezometers to monitor the level of PP
L L L L
saturation. Total volume of water fed into the PP was 298 L during
(4) three-hour rainfall and runoff application.
Whenever overflow (runoff and precipitation) is greater An additional experiment was run during this experimental set
than Ksat , infiltration rate shown in (eq. (5)) equals Ksat and under to assess the accuracy of predicted overflow under higher flow
the condition that overflow is lower than Ksat the infiltration rate is intensity. Water would recess from the saturated segments during
equal to the overflow rate. this experiment. This overflow would occur because of the larger
runoff and rainfall rates than infiltration rate. Thus, it was assumed

Ksat Ksat < Rij þ P that water storage was equal to the difference between inflow and
Iij ¼ (5)
Rij þ P Ksat > Rij þ P outflow in each segment. The mass balance for this condition is
expressed by (eq. (6)). Water would recess from each segment to
where Iij is the infiltration rate (m/s) at time i and segment j, Rij the surface when accumulation volume, VACij (m), was greater than
runoff overflowing on the PP (m/s) and P the precipitation applied segment capacity. Water accumulation is the multiplication of
on the PP (m/s). accumulation rate and time intervals (eq. (7)). Segment capacity is
M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53 47

the total void volume in each segment wherein water can occupy. It eutrophication and reduces the overall quality of water.
is worthy to note that all the calculations were done in unit of area. To carry out these experiments, the 150 lit tank was filled with
   an urban stream with base flow around the studied streets. The TSS,
Kh PO3 þ 
Sij ¼ Iij þ diðj1Þ  dij  qij ¼ Iij þ diðj1Þ  þ 1 qij (6) 4 , N  NH4 and N  NO3 concentrations in the tank were about
Kv 720, 3, 3.5 and 2.2 mg/L. For a better control of influent and effluent
rates and path of pollutants, the direct rainfall is removed from the
VACij ¼ Sij *DðtÞ (7) setup. It should be noted that the PP surface had been fully cleaned
before this stage was begun. Pollutants had a higher influent con-
During this experiment, 62 mm/h uniform and steady precipi-
centration at the beginning of this experiment to consider the first
tation was applied to the PP. This applied precipitation is about 70%
flush phenomena. To achieve this goal, tap water was added to the
times greater than the first experiment to study the PP capacity and
tank as the polluted water was conveyed to the PP. This substitution
overflow. As compared with the first experiment, the runoff rate
makes the pollutants diluted and keeps the water at a constant
applied to the first segment during this experiment was three times
flowrate (108 mm/h). Runoff flew for 240 min and the measure-
greater than precipitation (3*62¼192 mm/h). In addition, the
ments went on 30 min after the runoff stoppage. Seven samples
application of source water (precipitation and runoff) on the PP
were harvested from influent runoff and effluent discharge of each
lasted one hour and then the PP was left to drain the applied runoff
segment. A spectrophotometer device was utilized to measure the
and precipitation.
concentrations of the pollutants. The concentration differences
between influent and effluent from the segments indicated the role
2.3.2. Experimental set 2: performance evaluation of PP for clogging of PP in the nutrients removal efficiency.
under sediment loading
The aim of the second experimental set was to get the age of the 3. Results and discussion
PP before having any overflow bypass. Infiltration of runoff that
contains sediments leads to PP clogging. This clogging depends on 3.1. Performance results based on hydraulic behavior
PP hydraulic conductivity, sediment and runoff loadings.
An artificial runoff was prepared by addition of dry sediments The results of this experiments are categorized into two
collected from the streets to the tap water in a mixing tank depicted different parts: (1) finding the ratio of hydraulic conductivities and
in Fig. 1b. This mixing tank was used to keep the TSS concentration (2) validating the model by predicting the runoff overflow under
constant during the experiments. Based on a study carried out by more intense rainfall and runoff rates. This validated model is used
Kamali et al. (2012), the median concentration of TSS was about to better understand the governing mechanisms and evaluate the
400 mg/L in urban runoff of Tehran during nine field measurements long-term hydraulic performance of the pavement structure.
from different surfaces including urban stream, rusted iron roof,
galvanized iron roofs, asphalt street and storm channels. Therefore,
3.1.1. Ratio of hydraulic conductivities
runoff with average TSS concentration of 400 mg/L was exposed to
The results of exiting discharge for four different segments
the PP. The runoff was transported to the surface of the PP by a
during the experiment set 1 are tabulated in Table S1 (supple-
pump. A float ball used to fix the water elevation in tank. During
mentary document). As shown, higher drainages occurred in the
6.67 h, steady-state precipitation rate of 36 mm/h and runoff
farther segments to the influent and the first segment underwent
108 mm/h were applied to the PP during each hydrological year.
the least water drainage, which can be explained by slope of the
Generally, there was a day gap between each hydrological simula-
experimental setup (2%) that enforces the water to move down-
tion to make the needed TSS for the next hydrological year.
stream. This observation is consistent with literature (e.g. Castro
Dry sediments were swept up from the edges of streets with
et al., 2007). Castro et al. (2007) investigated the role of PP's
low, medium and high traffic volumes. Average of annual daily
slope on the water discharge and found that the slope affects the
traffic of these streets is about 1200. After sampling, they were
drainage path. They reported that although over 70% of total water
carried to the laboratory to be washed and granulated, respectively,
was drained from the first half of the PP under zero slope condition,
and finally were dried in an oven. The sieving results of these
the water drainage path shifted to the middle and end of the PP
sediments revealed that sediment sizes in streets with medium and
when the slope gently increased to 2%.
low traffic volumes are somehow similar. One representative
The water influent into the PP in 180 min was 898.2 lit and the
example of a sample sediment size distribution is displayed in
amount of effluent was 821 lit. Afterward, 7.15 lit water exited from
Fig. S1 (supplementary document). As shown, about 50% of sedi-
the PP in 24 h. Totally, 8% difference was found between water fed
ment size was smaller than 150 mm. For this reason and the fact that
into the PP and the outlet volume. This difference between the
particle less than 150 mm is more responsible for clogging in PPs
volumes of water in the influent and effluent has a descending
(Coleri et al., 2013), these particle size ranges were used during our
trend. We associated this observation with 1) grain affinity in
experiments.
adsorbing water, 2) errors in measurements, 3) incomplete infil-
tration of the rainfall into the PP (e.g. forming ponds on the PP), and
2.3.3. Experiment set 3: performance evaluation of PP for pollutants 4) water retention in the PP due to the slope, which brings about
removal incomplete discharge.
This part of the experiment aims to determine pollution removal Insignificant storage in all the segments was assumed during
efficiencies of the PP and detect influences of drainage path length this experiment, so water would only be discharged out or drained
 
in nutrient removal efficiencies. Four different water quality pa-
rameters were taken into account to assess PP performances to the adjacent segment in KKhv ratio over vertical discharge. A
þ  
including: TSS, PO3 
4 , NH4 and NO3 . The pollutants were selected
global KKhv value was searched for the PP, which means that this
because an elevated concentration of these constituents were
measured in storm drain channels; especially when mixed with ratio was considered to be for the whole of the PP during the
wastewater streams (Kamali et al., 2012). Discharge of storm drains experimental steps. The least square error between the observed
containing these pollutants into surface water bodies causes discharge ðqi Þ and predicted values was used to get the most
48 M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53

   
Kh Kh influent.
representative value . The representative ratio for ob-
Kv Kv Predicted discharges (qij Þ for each segment at different times are
tained was 3.5, which is reasonable for a porous media with large plotted vs. observed discharges in Fig. 3. Predicted water discharge
void ratio, less matric suction, and lower horizontal water from each segment was compared to the measured value to assess
 
movement.
the accuracy of KKhv . The results unveil an acceptable prediction of
this ratio for the studied PP. Total measured and predicted overflow
3.1.2. Evaluating the PP capacity are 7.7*105 and 3.6*105m/s, respectively. It can be seen that they
As discussed in the methodology section, the applied rainfall are in order of magnitude; however, this difference might be
and runoff intensities were 62 and 186 mm/h, respectively. The PP associated with the quasi-steady state assumption, complicated
was saturated 26 min after experimental initiation and a pond was behaviors of water during recession and averaging long intervals of
formed in the outlet. A higher discharge rate was seen for the first measurements.
hour when we had both runoff and rainfall. A decreasing trend in
water drainage after the first hour is related to stopping water flow
entrance the PP. The third and fourth segments made the highest 3.2. PP performance for clogging under sediment loading
contributions in discharge, which was related to the horizontal
water movement in the porous structure. In this experiment, the Evaluating the PP clogging trends under sediment loading was
relative difference between the total water that came into the PP the primary objective of this stage of the experiments. The water
module and exited was about 1.4%, which infers that water was not discharge of these four segments and runoff coefficient during all
noticeably stored in the PP. seven hydrological years are displayed in Fig. 4. The PP had a free
 
drainage condition that was governed in the first two years. The
Knowing the KKhv , which is porous medium specific, helps us
drainages prevented releasing of water in the first hour of each
model more experimental setups. PP performance under high other hydrological year. As shown in Fig. 4, runoff overflow was not
rainfall intensity and drainage prediction would be another inter- observed in the first five years. The runoff coefficient in the sixth
esting point about the PP. Applying higher rainfall and runoff rates year was 15%. During the seventh period, the runoff coefficient
than PP capacity would lead to a runoff overflow. Observation of increased from 15% to 35%. During all these hydrological years,
runoff that is overflowing from the fourth segment infers that the coarse sediments infilled the gaps between the blocks, which in-
PP failed at controlling runoff quantity. The data of this experi- crease the runoff coefficient (Pezzaniti et al., 2009). Castro et al.
mental setup are displayed in Table S2. (2007) compared infiltration rate and runoff percent between
The results presented in Table S2 reveal that water was more two conditions (no clogging, fully clogging) in 2% slope. They found
discharged from the third and fourth segments compared to the that the filter water volume decreased from 98.45% to 70.98% and
first and second one. The authors believe that this distribution of runoff percentage increased from 1.6% to 29%, which is consistent
water discharge highly depends on PP slope, PP particle size dis- with our observation. During all seven years of our experiment,
tributions and water flow rates. As water influent stops (after one water discharge from segments 1 and 2 decreased from 48.4% to
hour), discharged volume was decreased in all the segments except 10.5%, and water discharge from segments 3, 4 and the weir
the first one. We related this observation to water backward increased from 51.6% to 89.5%.
movement from the farther segments to the first one due to un- The hydraulic heads recorded by piezometers for the experi-
balance water distribution in segments after stoppage of water ments since the fourth until seventh hydrological years are shown

Fig. 3. Predicted and observed discharge for each segment at each measurement time.
M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53 49

segment 1 segment 2 segment 3 segment 4 runoff


60

50

Outflow percentage (%)


40

30

20

10

0
1 2 3 4 5 6 7
Hydrological year

Fig. 4. Comparison between the percent output water volume water effluent percentage from the drainages and weir in seven hydrological periods during the experiments with
clean runoff.

Forth
FourthSimulation
SimulationPeriod
Period Fifth Simulation Period
Sixth Simulation Period seventh Simulation Period

160

140
Pizeometeric head (mm)

120

100

80

60
First segment Second segment Third segment Fourth segment
40

20

0
0 200 400 600 800 1000 1200 1400 1600 1800 2000
distance from upsteam of the PP (mm)

Fig. 5. Temporal and spatial variations in piezometric heads.

in Fig. 5. As seen, there is a noticeable clogging in the PP in a dis- experiments went on. It was related to sediments trapped in the
tance about 80 cm from the zone where runoff was applied during particles of the PP at the surface, which is concurrent with former
the fourth and fifth hydrological years. However, the observations studies (James, 2004; Teng and Sansalone, 2004; Kayhanian et al.,
are different in last two hydrological years. During these years, a 2012a). James (2004) and Pratt et al. (1995) reported that the ma-
sharp drop occurred in the third segment. The clogging in these two jority of TSS usually accumulate on a very thin layer on top of the PP.
years occurred in a distance about 130 cm from the beginning of the Teng and Sansalone (2004) called this thin layer “schmutzdecke”
PP, which is located in the third segment. It can be seen that the cake and found that this layer forms when the ratio of sediment
drop was shifted from the second to the third segment during the diameter to the medium diameter is less than 10. Here, since the
last three years. According to Fig. 5, water discharge from the first ratio of the medium diameter was about 2.7 mm and the sediment
and second segments decreased from 22% to 10.5%, and from the diameter was about 150e300 mm, sediments were strained in this
third, fourth segments and weir increased from 78% to 89.5%. cake on top of our PP. In another study, Kayhanian et al. (2012a)
Pezzaniti et al. (2009) reported that these changes are associated utilized scanned image analysis and found that top 2.5 cm of a PP
with 1) accumulations of fine sediments on the geotextile layers, had noticeable smaller porosities compared to the bottom of the PP.
and 2) coarse sediments on PP surface that bring about an increase Further, no water receded from inside the PP into the surface during
in drainage passage from the fourth to the seventh year. this experimental stage. It means that the reason for runoff effluent
Eqn. (3) was taken into account as the governing equation to after a few years is surface clogging and capacity of the PP is still
obtain the temporal and spatial clogging trends. Although the higher than water that enters the PP. Thus, a thin cake layer (1 cm)
maximum infiltration rate of the PP might not be affected by par- was assumed to be formed on top of the PP. Further, since water can
ticles trapped in the initial years (because of higher hydraulic be drained easily, no water storage inside the PP was assumed
conductivity compared to the runoff and precipitation rates), within each two consecutive measurements. It means that as water
infiltration rate should be decreased as sediments are introduced to comes into each segment, it discharges out of the system or travels
the PP. A cake was formed on top of the pavement as the to the next segment. This quasi-steady state assumption eases the
50 M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53

modeling of water flow in the PP. 3.3. Performance evaluation of PP in pollutants removal
The infiltration model was used to simulate the temporal and
spatial clogging trends. Hydraulic conductivity variations during As mentioned before, if PPs are properly designed, constructed,
seven hydrological years are shown in Fig. S2. It can be seen that the and maintained, they can be a good alternative method to manage
first and fourth segments did experience insignificant variations, stormwater runoff in urban areas. Beside the runoff volume
while the second and the third segments got clogged (about 12%), reduction, PPs are capable to remove most of the particulate and
which complies with literature. During an experiment with some dissolved pollutants in the urban runoff. The performance of
200 mg/L sediment, a formpave showed 10% decline in hydruclic the PP for the removal of selected pollutants investigated in our
conductivity after 5 hydrological years (Valkman, 1999). Based on study (namely, TSS, NH4þ , NO 3
3 and PO4 ) are discussed below.
the results presented in Fig. S2, the second segment was clogged
since the third hydrological year, which is somehow consistent 3.3.1. Total suspended solids (TSS)
with piezometric observations (Fig. 4). Furthermore, it was found Total suspended solids are an important water quality param-
that the third segment had clogging since the sixth hydrological eter that is commonly used to design and evaluate the performance
year, which is concurrent with the piezometric measurements. of best management practices or sustainable urban drainage sys-
Comparing our observations with other studies (Castro et al., tems. Although TSS intuitively are not a pollutant of concern, their
2007; McKenzie et al., 2008; Pezzaniti et al., 2009) reveals that measurement could be used as a surrogate parameter to evaluate
the clogging of the PP highly depends on sediments loading, the particle bound organic and inorganic pollutants in runoff. TSS could
way of applying sediments to the PP, PP hydraulic conductivity, and also impact the turbidity of runoff and influence the quality of
particle size distribution. We learnt that sediment loadings have a receiving waters. The concentration of TSS in urban runoff may vary
big influence on age of the PP. Pezzaniti et al. (2009) reported that between 100 and 3000 mg/lit. Generally, the size of particles found
their PP age was about 35 years in experimental setup; however, in runoff influences the measurement of TSS in laboratory and
our PP clogged after 7 years. They imported sediments with a rate settling or their removal in BMPs (Kayhanian et al., 2012b).
32.62 gr/yr to the PP, while we applied 583.2 gr/yr of sediments to Permeable pavements are generally considered a good LID to
the PP. Therefore, our sediment load was about 18 times greater remove TSS or particle bound pollutants with an efficiency varying
than the load in Pezzaniti et al. (2009). between 72% and 100% (Pezzaniti et al., 2009; Yong et al., 2008;
Particle size distribution plays an important role in PP clogging. Rowe et al., 2009; Brown et al., 2009; Tota-Maharaj and Scholz,
Generally, the range of urban runoff particle size has been reported 2010). A complete removal (100%) of TSS with our PP module was
in great variety. For instance, just 3% of the dry solids in runoff were accomplished during 180 min. Although TSS are captured
smaller than 50 mm (Li et al., 2005). In another study, Sansalone and throughout the PP depth, the geotextile layer improved the effi-
Tribouillard (1999) reported that the fraction of particles less than ciency of removal TSS in this experiment. In a study, a geotextile
50 mm in a PP was 10%, while in another research, majority of layer between gravel layers increased efficiency of TSS removal by
particles on a PP were less than 50 mm (McKenzie et al., 2008). about 30% (Rowe et al., 2009). Although PPs have great perfor-
According to Stoke's law, this variety in particle size distribution mances in TSS removal from urban runoff, this TSS capturing
would lead to different settling velocities. Sphere shapes were hardens water flow in PPs. These TSS trapped in structures of PPs
assumed for the particles to calculate the horizontal distance that occupy pore spaces that leads to a decrease in porosity of PPs and as
the particles pass to settle down; however, small particles might a result, a decrease in hydraulic conductivity of PPs.
have non-sphere shapes, which makes them more suspended than
sphere shapes. The results of Stoke's law reveal that if the second 3.3.2. Orthophosphate ðPO34 Þ
segment in the PP (50e100 cm) was noticeably clogged, the ma- Fig. 6 displays effluent PO3
4 concentrations from the first and
jority of sediments should have particle sizes less than 7 mm. In an fourth segments. The PP removed 32% and 35% of PO3 4 from the
investigation about road dust and stormwater sampling, McKenzie
first and fourth segments in the first 30 min, respectively. The total
et al. (2008) found that the majority of particles are smaller than
removal efficiency was 9% and 38% for the first and fourth seg-
7 mm, which confirms the results found here.
ments, respectively. This better PO3
4 removal seen at initial time of
The way of importing sediments to the PP is one of important
elements in evaluating PP performances. In this study, sediments the experiment can be explained by chemical adsorption. Lower
were imported to the PP from one side and clogging occurred from effluent PO3 4 concentrations in the fourth (last) segment than the
upstream of the water flow, which is called “clogging front”. In this first segment implies time dependency of PO3
4 removal from this
condition, upstream of the PP is initially clogged and then clogging porous medium. It infers that as the travel time lengthens, PO3 4
extends to downstream regions. Although what Pezzaniti et al. removal increases. The results obtained from our study are com-
(2009) found in their field work accords well with our observa-
parable with other studies. For instance, the PO3 4 removal effi-
tion, they did not observe this process in their experimental effort.
ciencies reported by Tota-Maharaj and Scholz (2010) and Collins
Moreover, their results showed that clogging occurs in a faster rate
(2007), were about 78% and 58%, respectively. The lower removal
in the field compared to the laboratory experiment. Therefore, this
efficiencies of PO3
4 in our study may be due to minimum adsorp-
comparison infers that our experimental setup is closer to what
happens in reality (fields). tion capacity by granular gravel (and aggregates), and lack of
Another key element in the PP performance is hydraulic con- insufficient nutrient and time for biogeochemical processes
ductivity, which causes easier flow in PPs. The PP utilized in including biological activities within the short depth of PP depth.
Pezzaniti et al. (2009) had a hydraulic conductivity more than two
3.3.3. Ammonia nitrogen (N  NH4þ Þ
orders (4.7*102 m/s) of magnitude greater than our PP
(2.1*104m/s). This difference can somehow explain the higher Fig. 7 compares N  NH4þ effluent concentrations from the first
duration of their PP. However, a hydrapave constructed in Australia and fourth segments. As shown, the concentration of N  NH4þ
with a hydraulic conductivity 6.5*103m/s (one order of magnitude increased in the effluent of the fourth segment is greater than the
greater than ours) had about 10 year as effective life (Yong et al., first segment between 70 and 170 min. This event was coincident
2008), which is closer to the age of our PP. with the runoff overflow of the PP. However, the concentration in
this segment dropped compared to the first one after this period.
M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53 51

3.5
influent concentration
3
effluent concentration of the first segment

Concentration (mg/L)
2.5
effluent concentration of the fourth segment
2

1.5

0.5

0
0 30 60 90 120 150 180 210 240 270
Time (min)

Fig. 6. Performance of PP in Orthophosphate removal. Time in X-axis begins as the water discharge was seen in each segment.

4.5 influent concentration

effluent concentration of the first segment

effluent concentration of the fourth segment


concentration (mg/l)

1.5

0
0 30 60 90 120 150 180 210 240 270
Time (min)

Fig. 7. Performance of PP in ammonia removal.[Note: Time in X-axis begins as the water discharge was seen in each segment].

We relate less N  NH4þ concentrations in the fourth segment this period, we believe that nitrification process was evolved and
compared to the first segment after 170 min to thriving nitrification N  NO 3 concentration is higher in the fourth segment. During our
conditions that convert N  NH4þ to N  NO measurements, N  NO 3 removal efficiencies were 3% and 15% for
3 . The removal effi-
ciencies of N  NH4þ during early part of the experiment (e.g., the first and fourth segments at first 30 min, respectively. Con-
30 min) were 68% and 79% in the first and the fourth segments, centrations of N  NO 3 in the effluent were usually lower in the
respectively. However, removal efficiencies decreased to 57% and fourth segment than the first segment. In total, this removal effi-
60% in the first and fourth segments in total of the experiment time ciency decreased to 17% and 6% for the first and fourth seg-
period. We believe that oxygen is being consumed as runoff moves ments, respectively. It can be associated with the higher N  NO 3
through the PP (increasing degree of saturation) and this low level production rate in the nitrification than its removal in the denitri-
of oxygen could prevent nitrification process that is required for the fication process. This low N  NO 3 removal efficiency is consistent
oxidation of available N  NH4þ . Comparing our results with liter- with the findings in literature. Tota-Maharaj and Scholz (2010) and
ature [e.g. Tota-Maharaj and Scholz (2010)], the lower N  NH4þ Collins (2007) reported that removal efficiencies for N  NO3 in PPs
removal in our PP could be related to lower retention times and less are low.
available nutrients to support effective biological conversion in our
experiment.
3.4. Limitations and uncertainty

3.3.4. Nitrate nitrogen (NO


3Þ Although this study reveals some interesting points about the
Fig. 8 compares effluent N  NO3 concentrations of the first and behaviors of PPs, there are some uncertainties and limitations in
fourth segments. Comparing Fig. 8 and 11 reveals that N  NO 3 this investigation that should be pointed out to be considered in
concentrations are lower in the fourth segment compared to the future studies. These limitations originated from our experimental
first segment between 70 and 220 min, which is coincident with setup, measurements, and model assumptions include:
higher N  NH4þ concentrations in the fourth segment than the first
one. This negative correlation between N  NH4þ and N  NO 3  Limitation in the size of the PP because of module weight and
clearly represents the importance of the nitrification process. After laboratory limitations.
52 M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53

3
influent concentration

effluent concentration of the first segment

Concentration (mg/l)
2
effluent concentration of the fourth segment

0
0 30 60 90 120 150 180 210 240 270
Time (min)

Fig. 8. PP performance inN  NO


3 removal. Time in X-axis begins as the water discharge was seen in each segment.

 Systematic errors in the measurements and human errors that the larger aggregate and sand size.
are inevitable during our measurements. For instance, the water The experimental results with applied sediment loads showed
might not be completely discharged from the PP due to the that the PP failure occurred in the seventh hydrological year. Runoff
slope. overflow was not observed during the beginning five hydrological
 Some assumptions were made during model development that years with zero runoff coefficient. The runoff coefficient in the sixth
might be violated under some conditions. For instance, although year increased to 15%. During the seventh period, the runoff coef-
water was not significantly accumulated in the PP, a small ficient increased from 15% to 35%. Coarse sediments infilled the
fraction might be stored in the PP. Other assumption is quasi gaps between pavements blocks during all these years, which
steady-state condition. Since one measurement was carried out increased the runoff coefficient.
during a long period (e.g. 30 min for the first experiment), this The experimental results were further used in a simple infil-
assumption was inevitable. However, water discharge might tration model to simulate the clogging effect. Both experimental
alter within each measurement time interval. Utilizing a data observations and simulation performance revealed that the mid-
logger, which obtains data in a shorter time interval, can section (e.g., 9 cm from the pavement surface) of the PP were
improve the accuracy of the model. clogged during the hydrological years.
 Although our experimental setup has high similarity to actual The performance of the PP highly depends on the local condi-
conditions, we believe that PPs should have better performances tions including particle size distribution, sediments loadings, and
compared to our experiment for some reasons. We loaded one- the way of importing sediments to the PP. It means that each region
year rainfall to the PP during only 6.7 h, which puts the PP under should have specific experiments to evaluate the performances of
more stress compared to the actual conditions. Some exterior the PP instead of comparing the results of different PP under
parameters such as sunlight can dry the sediments on the PP different conditions.
and makes a hard cluster on it, which improves the PP perfor- The experimental results also showed that PPs could completely
mance (Brown et al., 2009). remove TSS; however, medium removal efficiencies were measured
 Although we evaluated the performance of the PP for one for N  NH4þ and PO3 
4 , while the removal efficiency for N  NO3
greater rainfall, the sensitivity of the PP performance to water was negative.
and sediment loadings are of interest in this regard. The authors We suggest further researches about influences of the rainfall
suggest more investigations about the sensitivity of the PP to intensity, slope, particle size distribution of sediments, block di-
these loadings. mensions of pavements, and space between blocks on hydraulic
conductivity as well as lifespan of PPs. These investigations can
evaluate these influences on performance of PPs in pollutants
4. Conclusions removal. Moreover, they can help develop more accurate infiltra-
tion models.
This study investigated the performance of a PP under sediment
loadings during its life span. Main purpose of this study was to
Appendix A. Supplementary data
evaluate the temporal and spatial clogging trends of this PP and
find the vulnerability of the PP to sediment loadings during rain-
Supplementary data related to this article can be found at http://
falls. Afterward, simple infiltration models were validated by the
dx.doi.org/10.1016/j.jenvman.2016.11.027.
laboratory experiments to evaluate the trend and extend of the PP
infiltration capacity throughout the life of the operation. At the end,
performances of the PP in removing TSS and selective nutrient References
þ
pollutants such as NO 3
3 ; NH4 and PO4 from the surface runoff were Andersen, C., Foster, I., Pratt, C., 1999. The role of urban surfaces (permeable
investigated. The conclusions drawn from this study are: pavements) in regulating drainage and evaporation: development of a labora-
Kh tory simulation experiment. Hydrol. Process 13 (4), 597e609. http://dx.doi.org/
The Kv ratio was determined to be about 3.5, which is much 10.1002/(SICI)1099-1085(199903)13:4<597::AID-HYP756>3.0.CO;2-Q.
Bean, E.Z., Hunt, W.F., Bidelspach, D.A., 2007. Field survey of permeable pavement
smaller than the KKhv ratio for normal soils. This low value for KKhv ratio
surface infiltration rates. J. Irrig. Drain. Eng. 133 (3), 249e255. http://dx.doi.org/
for the PP system was related to low matric suction that mostly due 10.1061/(ASCE)0733-9437(2007)133:3(249).
M. Kamali et al. / Journal of Environmental Management 187 (2017) 43e53 53

Brown, C., Chu, A., Van Duin, B., Valeo, C., 2009. Characteristics of sediment removal stormwater. Impacts Glob. Clim. Change 173 (216), 1e12. http://dx.doi.org/
in two types of permeable pavement. Water Qual. Res. J. Can. 44 (1), 59e70. 10.1061/40792(173)216.
https://www.cawq.ca/journal/temp/article/413.pdf. Nie, W., Yuan, Y., Kepner, W., Nash, M.S., Jackson, M., Erickson, C., 2011. Assessing
Castro, D., Gonz alez-Angullo, N., Rodríguez, J., Calzada, M., 2007. The influence of impacts of Landuse and Landcover changes on hydrology for the upper San
paving-block shape on the infiltration capacity of permeable paving. Land Pedro watershed. J. Hydrol. 407 (1e4), 105e114. http://dx.doi.org/10.1016/
Contam. Reclam 15 (3), 335e344. http://dx.doi.org/10.2462/09670513.855. j.jhydrol.2011.07.012.
Chai, L., Kayhanian, M., Givens, B., Harvey, J.T., Jones, D., 2012. Hydraulic perfor- Pezzaniti, D., Beecham, S., Kandasamy, J., 2009. Influence of clogging on the effective
mance of fully permeable highway shoulder for storm water runoff manage- life of permeable pavements. Proc. ICE-Water Manag. 162 (3), 211e220. http://
ment. J. Environ. Eng. 138 (7), 711e722. http://dx.doi.org/10.1061/(ASCE) dx.doi.org/10.1680/wama.2009.00034.
EE.1943-7870.0000523. Pratt, C., Mantle, J., Schofield, P., 1995. UK research into the performance of
Coleri, E., Kayhanian, M., Harvey, J.T., Yang, K., Boone, J.M., 2013. Clogging evaluation permeable pavement, reservoir structures in controlling stormwater discharge
of open graded friction course pavements tested under rainfall and heavy quantity and quality. Water Sci. Technol. 32 (1), 63e69. http://dx.doi.org/
vehicle simulators. J. Environ. Manag. 129, 164e172. http://dx.doi.org/10.1016/ 10.1016/0273-1223(95)00539-Y.
j.jenvman.2013.07.005. Qin, H., Li, Z., Fu, G., 2013. The effects of low impact development on urban flooding
Collins, K.A., 2007. A Field Evaluation of Four Types of Permeable Pavement with under different rainfall characteristics. J. Environ. Manage 129, 577e585.
Respect to Water Quality Improvement and Flood Control. Master thesis. Uni- Rowe, A., Borst, M., O’Connor, T., Stander, E., 2009. Pervious pavement system
versity of North Carolina. http://www.bae.ncsu.edu/info/permeable-pavement/ evaluation. World Environmental and Water Resources Congress, pp. 1e8.
CollinsThesis.pdf. http://dx.doi.org/10.1061/41036(342)141.
Davis, A.P., Shokouhian, M., Ni, S., 2001. Loading estimates of lead, copper, cadmium, Sansalone, J., Teng, Z., 2005. Transient rainfall-runoff loadings to a partial exfiltra-
and zinc in urban runoff from specific sources. Chemosphere 44 (5), 997e1009. tion system: implications for urban water quantity and quality. J. Environ. Eng.
http://dx.doi.org/10.1016/S0045-6535(00)00561-0. 131 (8), 1155e1167. http://dx.doi.org/10.1061/(ASCE)0733-9372(2005)131:
Finkenbine, J., Atwater, J., Mavinic, D., 2000. Stream health after urbanization. Am. 8(1155).
Water Resour. Assoc. 36 (5), 1149e1160. http://dx.doi.org/10.1111/j.1752- Sansalone, J., Tribouillard, T., 1999. Variation in characteristics of abraded roadway
1688.2000.tb05717.x. particles as a function of particle size: implications for water quality and
Iowa Stormwater Management Manual, 2009. Version 3. drainage. Transp. Res. Rec. J. Transp. Res. Board 1690, 153e163. http://
James, W., 2004. Clogging of permeable concrete block pavement by street par- dx.doi.org/10.3141/1690-18.
ticulates and rain. J. Water Manag. Model. http://dx.doi.org/10.14796/ Siriwardene, N.R., Deletic, A., Fletcher, T.D., 2007. Modeling of sediment transport
JWMM.R220-29. R220-29. through stormwater gravel filters over their lifespan. Environ. Sci. Technol. 41
Kamali, M., ghazvinizadeh, S., Tajrishy, M., Kayhanian, M., 2012. Urban runoff (23), 8099e8103. http://dx.doi.org/10.1021/es062821v.
characteristics in Tehran, Iran. In: 9th International Conference on Urban Teng, Z., Sansalone, J., 2004. In situ partial exfiltration of rainfall runoff. II: particle
Drainage Modeling. Belgrade. separation. J. Environ. Eng. 130 (9), 1008e1020. http://dx.doi.org/10.1061/
Kayhanian, M., Anderson, D., Harvey, J.T., Jones, D., Muhunthan, B., 2012a. Perme- (ASCE)0733-9372(2004)130:9(1008).
ability measurement and scan imaging to assess clogging of pervious concrete Tota-Maharaj, K., Scholz, M., 2010. Efficiency of permeable pavement systems for
pavements in parking lots. J.Environ.Manage. 95 (1), 114e123. http://dx.doi.org/ the removal of urban runoff pollutants under varying environmental condi-
10.1016/j.jenvman.2011.09.021. tions. Environ. Prog. Sustain. Energy 29 (3), 358e369. http://dx.doi.org/10.1002/
Kayhanian, M., Fruchtman, B.D., Gulliver, J.S., Montanaro, C., Ranieri, E., Wuertz, S., ep.10418.
2012b. Review of highway runoff characteristics: comparative analysis and U.S. Environmental Protection Agency (USEPA), 1996. “Environmental Indicators of
universal implications. Water Res. 46 (20), 6609e6624. http://dx.doi.org/ Water Quality in the United States.” Rep. No. EPA-841R9602, Washington, DC.
10.1016/j.watres.2012.07.026. Valinski, N.A., Chandler, D., 2015. Infiltration performance of engineered surfaces
Li, Y., Lau, S., Kayhanian, M., Stenstrom, M.K., 2005. Particle size distribution in commonly used for distributed stormwater management. J. Environ. Manage
highway runoff. J. Environ. Eng. 131 (9), 1267e1276. http://dx.doi.org/10.1061/ 160, 297e305.
(ASCE)0733-9372(2005)131:9(1267). Valkman, R., 1999. “Lifespan” of Permeable/Permeable Paving Systems, Internal
McKenzie, E.R., Wong, C.M., Green, P.G., Kayhanian, M., Young, T.M., 2008. Size Report. Urban Water Resources Centre, University of South Australia.
dependent elemental composition of road-associated particles. Sci. Total Envi- Yong, C., Deletic, A., Fletcher, T., Grace, M., 2008. The Clogging Behaviour and
ron. 398 (1e3), 145e153. http://dx.doi.org/10.1016/j.scitotenv.2008.02.052. Treatment Efficiency of a Range of Porous Pavements. 11th International Con-
Morquecho, R.E., Pitt, R., Clark, S., 2005. Pollutant associations with particulates in ference on Urban Drainage. Edinburg, Scotland, UK.

You might also like