Professional Documents
Culture Documents
Q.S .
The t Ime .
signa1 correspond.mg t o 2i82 +lOs+
+ + 11 IS
.
58 6
(A) 26(t) + (e 3t- e 2 t) u(t) (B) 26(t) + (e 2t- e 3 t)u(t)
(C) 26(t) + (e 2t+ e 3 t) u(t) (D) 26 (t) - ( e 2t + e 3 t) u ( t)
R(s) +
2
(A) (B)
--------1-_..__-----'---'----- t
0 1 2 3
0 1 2 3
------1---...--------.---.----- t
(C) (D)
-2
Q.12 For the circuit shown below the input voltage v, is as shown in figure.
c
+ 10
R
-10
Assume the RC large and cutin voltage of diode V, = 0. The output voltage V0 is
(A) 10 l
(C) (D)
Q.13 An ideal pn junction diode is operating in the forward basic region. The change in
diode voltage, that will cause a factor of 9 increase in current, is
(A) 83 mV (B) 59 mV
(C) 43 mV (D) 31 mV
Q.14 If the base width of a bi-polar transistor is increased by a factor of three then what
is the collector current change ?
(A) Increased by a factor of three (B) Decreased by a factor of three
Q.15 For a n-channel enhancement-mode MOSFET the parameters are VTN = 0.8 V,
k ~ = 8 ~A/V and W/ L = 5. If the transistor is biased in saturation region with
2
www.examrace.com
Q.16 The value of the current measured by the ammeter in figure is
2A
3A
(A) iA (B) iA
(C) - 5 A
6 (D)~ A
Q.17 In the given lattice network the value of RL for the maximum power transfer to it is
70
Q.18 In the following circuit, the switch S is closed at t = 0. The rate of change of current
~~ (o+) is given by
S R
2 2
Q.20 A vector field is E = 4zy ux + 2ysin 2xuy + y sin 2xuz The surfa ce on which Ey = 0 is
(A) Plane y = 0 (B) Plane x = 0
Q.23 A carrier is phase modulated (PM) with frequency deviation of 10 kHz by a signal
tone frequency of 1 kHz. If the signal tone frequency is increased to 2 kHz, assuming
that phase deviation remains unchanged, the bandwidth of the PM signal is
(A) 21 kHz (B) 22 kHz
(C) 42kHz (D) 44kHz
Q.24 A die is thrown thrice. Getting 1 or 6 is taken as a success. The mean of the number
of successes is
(A) 3/2 (B) 2/3
(C) 1 (D) None
Q.25 Let f(x) = ex in [0, 1]. Then, the value of c of the mean-value theorem is
(A)0.5 (B)(e-1)
(C) log ( e- 1) (D) None
Q.26 For dyj dx = xy given that y = 1 at x = 0. Using Euler method taking the step size
0.1, the y at x = 0.4 is www.examrace.com
(A) 1.0611 (B) 2.4680
(C) 1.6321 (D) 2.4189
1 1 1
Q.28 [ [ [ ex+y+z dxdydz is equal to
Q.31 The plane 2x + 3y- 4z = 1 separates two regions. Let f.1r1 = 2 in region 1 defined
by 2x+ 3y- 4z > 1, while /11'2 = 5 in region 2 where 2x + 3y- 4z < 1. In region
H 1 = 50ux- 30u y + 20uz Ajm. In region 2,H 2 will be
(A) 63.4u x + 43.18uy + 19.4uz A/ m (B) 52.9ux - 25.66u y + 14.2uz A/ m
(C) 48.6ux - 16.4uy- 46.3u z A/ m (D) None of the above
www.examrace.com
Q.32 A total of 30 equal-power users are to share a common communication channel by
CDM. Each user transmit information at a rate of 10 kbps via DS spread spectrum
and binary PSK. The minimum chip rate to obtain a bit error probability of 10 5
(A) 1.3 X 10 6 chips/sec (B) 2.9 X 10 5 chips/sec
Q.33 The channel capacity of the binary symmetric channel shown below is
P(xt) =a
xt 0:::------=------:::0 Y1
22 CF----------:::--------'0 Y2
P(22) = 1-a
Q.34 It was found that a sampling rate 20% above the rate Would be adequate. So the
maximum SNR, that can be realized without increasing the transmission bandwidth,
would be
(A) 64.4 dB (B) 70.3 dB
(C) 50.1 dB (D) None of the above
Q.35 A superheterodyne FM receiver operates in the frequency range of 88-108 MHz. The
IF and local oscillator frequency are chosen such that ftF < fw. The infe frequency
must fall outside of the 88-108 MHz region. The range of variation in fw is
(A) [98, 128] MHz (B) [78, 128] MHz
(C) [98, 118] MHz (D) [78, 98] MHz
www.examrace.com
Q.37 Consider a ufb system whose open-loop transfer function G(s) = ( 2 K ) . The
8 8
Nyquist plot for this system is + 2s + 2
lm Im
r -.......,
I
/ '\
w= oo \
(A) Re (B) Re
' / I
I w=oo
_....,,
lm lm
(C)
R(s) +-0
-
K
s( s+l )( s+4)
C(s)
: (s+a):
4. i[ 2
[ x(t) [2 dt = 1
Q.40 If the input to this system is x( t) = cos (211:t +B), then output will be
(A) -jsin (211:t +B) (B) 3~ sin (211:t +B)
(C) 2; sin(211:t+ B) (D) None of the above
www.examrace.com
Q.43 The frequency of oscillation of the astable multivibrator shown below is
6.8 kO 24 kO
-12 v
o.o33 ~FJ
..
(A) 18.4 kHz (B) 9.86 kHz
(C) 98.6 kHz (D) 1.84 kHz
c B A
- Q K - '----- Q K Q K r- 1
I 1 1 CLK
Q.45 The circuit shown below has 4 boxes each described by input P, Q, R and output Y, Z
with Y = P EB Q EB R and Z = PQ + P R + QR.
Q
,........_.....
Output
www.examrace.com
The circuit act as a 4 bit
(A) adder giving P+ Q (B) subtract or giving P ~ Q
(C) subtractor giving Q ~ P (D) adder giving P + Q+ R
If it is given that ~~ = 10, ~: = 11. The common mode rejection ratio (CMRR) is
(A) 20.8 dB (B) 47.6 dB
(C) 41.6 dB (D) 23.8 dB
Q.47 In the circuit shown below the Q-point is in the center of the load line. The transistor
parameters are ~ = 150 and VA = co .
+5V
··f -5V
o.2 kn
Q.48 A 2.4 em X 1.5 em wave guide operates in TE10 mode a t 9 GHz. The guide is made
of brass (ac = 1.1 X 107 S/m) and filled with teflon (cr = 2.6,aa = 10 15 S/m).
The attenuation constant, due to conduction losses, ac is www.examrace.com
(A) 0.0395 (B) 0.022
(C) 0.0145 (D) 0.0193
~ x( t) Square-Law Y( t)
m(t) Ll 1---- AM Signal
Device .....__ _.
Q.51 Let W be the bandwidth of message signal m(t). AM signal would be recovered if
(A) ]c > W (B) ]c > 2 W
(C) !c> 3W (D) fc > 4 W
(C) 4 X 10 16 em 3
(D) Cannot use n+ polysilicon gate
www.examrace.com