Professional Documents
Culture Documents
Tda7294 Datasheet PDF
Tda7294 Datasheet PDF
R3 22K
+Vs +PWVs
C2
R2 7 13
22µF
680Ω IN- 2
-
14 OUT
C1 470nF
IN+ 3
+ C5
R1 22K 22µF
6
IN+MUTE 4 BOOT-
STRAP R6
2.7Ω
R5 10K MUTE 10
VM MUTE THERMAL S/C
STBY 9 C10
VSTBY STBY SHUTDOWN PROTECTION
100nF
R4 22K
1 8 15
STBY-GND -Vs -PWVs
C3 10µF C4 10µF
C9 100nF C8 1000µF
D93AU011
-Vs
Note: The Boucherot cell R6, C10, normally not necessary for a stable operation it could
be needed in presence of particular load impedances at VS <±25V.
BLOCK DIAGRAM
2/17
TDA7294
THERMAL DATA
Symbol Description Value Unit
Rth j-case Thermal Resistance Junction-case Max 1.5 °C/W
3/17
TDA7294
Figure 2: P.C.B. and components layout of the circuit of figure 1. (1:1 scale)
Note:
The Stand-by and Mute functions can be referred either to GND or -VS.
On the P.C.B. is possible to set both the configuration through the jumper J1.
4/17
TDA7294
5/17
TDA7294
TYPICAL CHARACTERISTICS
(Application Circuit of fig 1 unless otherwise specified)
Figure 3: Output Power vs. Supply Voltage. Figure 4: Distortion vs. Output Power
Figure 5: Output Power vs. Supply Voltage Figure 6: Distortion vs. Output Power
6/17
TDA7294
Figure 9: Quiescent Current vs. Supply Voltage Figure 10: Supply Voltage Rejection vs. Frequency
Figure 11: Mute Attenuation vs. Vpin10 Figure 12: St-by Attenuation vs. Vpin9
Figure 13: Power Dissipation vs. Output Power Figure 14: Power Dissipation vs. Output Power
7/17
TDA7294
8/17
TDA7294
+Vs
(V)
+35
-35
-Vs
VIN
(mV)
VST-BY
PIN #9 5V
(V)
VMUTE 5V
PIN #10
(V)
IP
(mA)
VOUT
(V)
OFF
ST-BY
PLAY ST-BY OFF
MUTE MUTE
D93AU013
9/17
TDA7294
+40V
T3
BC394 R4 R5
T1
BDX53A 270 270
D1 BYW98100 T4 T5
+20V BC393 BC393
270
L1 1µH D3 1N4148 R6
20K
C11 330nF Z1 3.9V
7 13
C1 C3 C5 C7 C9 IN 3 C11 22µF
1000µF 100nF 1000µF 100nF 330nF R3 680
R16 2 R7 C16
R1 13K 3.3K 1.8nF
R16 L3 5µH
2 4 13K
TDA7294
PLAY C13 10µF 14 OUT
GND 270
9 C15
ST-BY R13 20K 22µF
6 R8 C17
R2 R14 30K 3.3K 1.8nF
2 D5
1N4148 R15 10K 1
C2 C4 C6 C8 C10 10 8 15
1000µF 100nF 1000µF 100nF 330nF Z2 3.9V
C14
10µF L2 1µH D4 1N4148
T7 T8
D2 BYW98100 BC394 BC394
270
-20V
T2 R9 R10 R11
BDX54A T6 270 270 29K
BC393
-40V
D93AU016
10/17
TDA7294
Figure 19: P.C.B. and Components Layout of the Circuit of figure 18 (1:1 scale)
diodes Z1,Z2 and resistors R7,R8 define the mini- Results from efficiency measurements (4 and 8
mum drop across the power MOS transistors of Ohm loads, Vs = ±40V) are shown by figures 23
the TDA7294. L1, L2, L3 and the snubbers C9, and 24. We have 3 curves: total power dissipa-
R1 and C10, R2 stabilize the loops formed by the tion, power dissipation of the TDA7294 and
"bootstrap" circuits and the output stage of the power dissipation of the darlingtons.
TDA7294.
By considering again a maximum average
In figures 21,22 the performances of the system output power (music signal) of 20W, in case
in terms of distortion and output power at various of the high efficiency application, the thermal
frequencies (measured on PCB shown in fig. 19) resistance value needed from the heatsink is
are displayed. 2.2oC/W (Vs =±40 V and Rl= 4 Ohm).
The output power that the TDA7294 in high- All components (TDA7294 and power transistors
efficiency application is able to supply at T1 and T2) can be placed on a 1.5oC/W heatsink,
Vs = +40V/+20V/-20V/-40V; f =1 KHz is: with the power darlingtons electrically insulated
- Pout = 150 W @ T.H.D.=10 % with Rl= 4 Ohm from the heatsink.
- Pout = 120 W @ " = 1% " " " Since the total power dissipation is less than that
- Pout = 100 W @ " =10 % with Rl= 8 Ohm of a usual class AB amplifier, additional cost sav-
ings can be obtained while optimizing the power
- Pout = 80 W @ " = 1% " " " supply, even with a high headroom.
11/17
TDA7294
HIGH-EFFICIENCY
Figure 22: Distortion vs. Output Power Figure 23: Power Dissipation vs. Output Power
12/17
TDA7294
+Vs
0.22µF 2200µF
7 13
6
3
Vi + 14 22µF
0.56µF 22K -
22K
1 2
4
TDA7294 680
ST-BY/MUTE 10
9 15 8
20K
22µF 22K
-Vs
1N4148 2200µF 0.22µF
9 15 8
10
10K 30K 22µF TDA7294
6
3 22µF
+ 14
0.56µF 22K -
22K
1 2
4
7 13
680
D93AU015A
13/17
TDA7294
Figure 26: Frequency Response of the Bridge Figure 27: Distortion vs. Output Power
Application
14/17
TDA7294
mm inch
DIM.
MIN. TYP. MAX. MIN. TYP. MAX. OUTLINE AND
A 5 0.197 MECHANICAL DATA
B 2.65 0.104
C 1.6 0.063
D 1 0.039
E 0.49 0.55 0.019 0.022
F 0.66 0.75 0.026 0.030
G 1.02 1.27 1.52 0.040 0.050 0.060
G1 17.53 17.78 18.03 0.690 0.700 0.710
H1 19.6 0.772
H2 20.2 0.795
L 21.9 22.2 22.5 0.862 0.874 0.886
L1 21.7 22.1 22.5 0.854 0.870 0.886
L2 17.65 18.1 0.695 0.713
L3 17.25 17.5 17.75 0.679 0.689 0.699
L4 10.3 10.7 10.9 0.406 0.421 0.429
L7 2.65 2.9 0.104 0.114
M 4.25 4.55 4.85 0.167 0.179 0.191
M1 4.63 5.08 5.53 0.182 0.200 0.218
S 1.9 2.6 0.075 0.102
S1 1.9 2.6 0.075 0.102 Multiwatt15 V
Dia1 3.65 3.85 0.144 0.152
15/17
TDA7294
mm inch
DIM.
MIN. TYP. MAX. MIN. TYP. MAX. OUTLINE AND
A 5 0.197
MECHANICAL DATA
B 2.65 0.104
C 1.6 0.063
E 0.49 0.55 0.019 0.022
F 0.66 0.75 0.026 0.030
G 1.14 1.27 1.4 0.045 0.050 0.055
G1 17.57 17.78 17.91 0.692 0.700 0.705
H1 19.6 0.772
H2 20.2 0.795
L 20.57 0.810
L1 18.03 0.710
L2 2.54 0.100
L3 17.25 17.5 17.75 0.679 0.689 0.699
L4 10.3 10.7 10.9 0.406 0.421 0.429
L5 5.28 0.208
L6 2.38 0.094
L7 2.65 2.9 0.104 0.114
S 1.9 2.6 0.075 0.102
S1 1.9 2.6 0.075 0.102 Multiwatt15 H
Dia1 3.65 3.85 0.144 0.152
16/17
TDA7294
Information furnished is believed to be accurate and reliable. However, STMicroelectronics assumes no responsibility for the consequences
of use of such information nor for any infringement of patents or other rights of third parties which may result from its use. No license is
granted by implication or otherwise under any patent or patent rights of STMicroelectronics. Specification mentioned in this publication are
subject to change without notice. This publication supersedes and replaces all information previously supplied. STMicroelectronics products
are not authorized for use as critical components in life support devices or systems without express written approval of STMicroelectronics.
17/17