Professional Documents
Culture Documents
meet2peeyush@gmail.com ▼
Unit 10 - Week 7-
Design of Experiments
Register for
Certification exam Assignment 7
Due date for this assignment: 2019-04-17, 23:59 IST.
Course Assignment not submitted
outline
1) When two random variables X and Y are independent, then the expected value for 1 point
How to access E(X) may be found from the expected values E(Y) and E(XY) in the following manner
the portal
E(X) = E(XY) - E(Y)
Pre-requisite E(X) =E(XY)/E(Y)
Assignment E(X)= E(XY) +E(Y)
E(X) =E(XY) . E(Y)
Week 1: Group
Discussion on 2) In a normal distribution, the following property is valid 1 point
Research
the mean of the distribution is always 0
Week 1: it approaches the t-distribution as the limits of the normal distribution are widened
Overview of
Research the distribution is symmetric about its mean
None of the above
Week 2:
3) 1 point
Literature
Survey,
Experimental
skills
the ratio of mean to standard deviation of the distribution is 2.5
the variance of the distribution is 4
Week 3
the area under the normal probability distribution from x=2 to x=5 is the same as the
Week 4 area from x=5 to x=8
ALL of the above
Week 5
4) In a factorial design, the 24 design strategy was chosen. This means 1 point
Week 6-
Intellectual Number of experiments is 16
property Each of the two variables is varied at four levels
After the test, ANOVA will NOT be able to detect ternary interaction effects between
Week 7- Design the variables
of Experiments
None of the above
DOE Part 1
https://onlinecourses.nptel.ac.in/noc19_ge03/unit?unit=52&assessment=98 1/3
4/17/2019 Introduction to Research - - Unit 10 - Week 7- Design of Experiments
DOE part 2 5) In a statistical design of experiments study, the effects of two factors A and B were 1 point
analysed at two levels. It was found that when A was changed from its low to high setting at the
DOE part 3
ixed lower level of B, the change in response was an increase of 10 units. Now when A is
DOE part 4 changed from its low setting to high setting at the ixed higher level of B, the change in response
DOE part 5 was a decrease of 10 units. This means that
8) When data are itted to a model then increasing number of model parameters is 1 point
penalized by the
R2 criterion
adjusted R2 criterion
Sum of squares of the residuals
Sum of absolute residuals
10)In a central composite design, involving two factors A and B, the response surface is 1 point
described by a quadratic model. If the effect of interaction between A and B is only absent, the
relevant signi icant effects are from
A only
A and B only
A, B, A2 and B2
A, B, A2, B2, A3 and B3
You may submit any number of times before the due date. The final submission will be
considered for grading.
https://onlinecourses.nptel.ac.in/noc19_ge03/unit?unit=52&assessment=98 2/3
4/17/2019 Introduction to Research - - Unit 10 - Week 7- Design of Experiments
Submit Answers
Funded by
Powered by
https://onlinecourses.nptel.ac.in/noc19_ge03/unit?unit=52&assessment=98 3/3