Professional Documents
Culture Documents
PAPOWER
A GIFT
ARC IGNITIONS
FROM ABOVE
pink) if used.
6. Hook the black trigger wire to the coil.
7. Hook the green VOES wire to VOES switch. It is recommended that you
Power Arc does not have these coils and
use of this style coil will effectively eliminate the Multi-Spark.
SR²
Electronic
use a VOES switch if one was on your motorcycle or you should add one if you
have a high performance, heavy bike or have wide engine load variations. If
Red Wire To +12 VDC FROM
IGNITION OR KILL
SWITCH, USUALLY
you did not have a VOES ground the green wire. WHITE WITH BLACK
Multi-Spark STRIPE
Ignition 8. Reconnect battery ground. 1.5 OHM
DUAL
FIRE COIL
VOES TOP DEAD CENTER TIMING METHOD: the Multi-Spark. FIRE COIL
Turn the engine over to the TDC mark of the compression stroke on the fly
SWITCH wheel. With the power on (+12 VDC ), rotate the trigger plate all the way
clockwise. Next, rotate the trigger plate (CCW) counterclockwise until the
red LED static timing light on the #1 (front cylinder) trigger just begins to light.
TACH Factory Tach Wire Red Tach Lock down the trigger plate hold down screws. Recheck engine TDC mark to BLACK
TO IGNITION MODULE
Normally Pink Trigger make sure no movement has occurred. Peg #1 will be set at approximately
8° BTDC. Additional adjustments may be made to meet your engines specific
Rev limiter is preset to 5800 RPM's. requirements.
DO NOT MOVE PINS COIL HOOKUP GUIDELINES
TIMING LINE ADVANCE WITH MODULE
USE ONLY RESISTOR (CARBON CORE) SPARK STATIC TIMING 1. Use only resistor plugs & resistor plug wires .
43
PA
PLUG WIRES & RESISTOR SPARK PLUGS. 21 2. Do not touch the green or brown coil output wires to +12 vdc.
3. A total of 2.8 ohms is the minimum allowable coi resistance.
DO NOT USE SPIRAL WOUND SUPPRESSION OR 4. Do not hook up coils with power (12 vdc) applied to the coils &
POWER ARC IGNITIONS
ignition module.
SOLID TYPE A GIFT FROM ABOVE
5. Be sure the coil used does not require a ballast resistor, if it does,
SPARK PLUG WIRES!
SR²
Electronic
it must be used.
6. Make sure not to run wiring near high heat areas of the
STOCK SPARK PLUG WIRES ARE Multi-Spark motorcycle, such as the exhaust system..
CARBON CORE WIRES & WILL WORK. Ignition 7. Use only new or known to be good coils.