THE
FOUR EASY STEPS TO
GOOD SHAFT ALIGNMENT
STUDENT
WORKBOOK‘This workbook and the material contained herein are the property of
carrier Corporation and may not be copied, reproduced, or released
without written permission of Carrier Corporation.GENERAL GUIDELINES TO STUDENTS
This training unit consists of a video tape presentation
with an accompanying workbook. The video program is
divided into sections. After each video tape section,
you will be directed to the workbook where you complete
an exercise (answer questions and do readings).
This training program takes approximately two hours to
complete.
The recommended sequence is as follow:
(1) After the administrator gives the introductory remarks,
the student reads the objectives.
(2) The student briefly discusses the objectives with the
administrator and other class members.
(3) The videotape is turned on and the student views the
material. Upon completion of tape Section I, the tape
is turned off. The student opens the workbook, reads
the questions and writes the answers directly in the
workbook. When the group has completed the workbook
questions, the administrator will review and discuss
the material just completed.
(4) When there is no further discussion, the administrator
will start the videotape for Section 2. When this is
completed, the tape will be turned off and again the
Students return to the workbook.
Troubleshooting Rotating Machinery: Including Centrifugal Pumps and Compressors, Reciprocating Pumps and Compressors, Fans, Steam Turbines, Electric Motors, and More