Professional Documents
Culture Documents
3
Technical Notes – Voice Select Functions
“Voice-2” Select Pin – This contact selects Voice-2 when connected to ground via switch.
If open (not connected) the pickup defaults to Voice-1. This is a control pin only, so
there is no signal present. Therefore, it can be combined with Voice-2 control pins from
multiple Fluence pickups on the same switch contact if need be without interaction. (This
can help simplify switch requirements in some cases.)
“Single Coil” Voice-3 Select Pin – This contact selects Voice-3 Single Coil mode when
connected to ground via switch. If open (not connected) the pickup defaults to Voice-1/
Voice-2 as selected by the Voice-2 pin. Voice-3 Single Coil mode overrides the setting
of the Voice-2 pin when activated. In Voice-3 Single Coil mode, the active coil is the one
closest to the neck for both Bridge and Neck pickups. In the same way as the Voice-2
pin, “Single Coil” Voice-3, it can be combined with “Single Coil” control pins from
multiple Fluence pickups on the same switch contact without interaction.
“SCO” and “NCO” Solder Pads – These stand for “South Coil Out” for the Bridge
pickup and North Coil Out” for the Neck. These are used on Tosin’s switch position-2 to
connect the inner coils together while feeding the signal through the Bridge pickup in
Voice-3 Single Coil mode.
4
CAUTION! Excessive pressure may puncture the battery. Isolate all components
during installation to eliminate shorting or risk of fire. 9V Battery
oice-2)
Neck Pickup Bridge Pickup
Tosin Abasi Signature 6 7 & 8 String Pickup Set
Fishman Recomended Wiring Diagram
Use 5-way Super Switch Selector
1xVolume, 1xTone (pull for humbucker Voice-2)
(+) (-)
Output
Jack
OUTPUT
OUTPUT
GND
GND
Ring
Single Coil
Single Coil
GND
GND
GND
GND
+9-18V
+9-18V
Voice 2
Voice 2
Sleeve
TOSIN
Tosin ABASI
Abasi TOSIN ABASI
Neck Bridge
RALNICO
ev1.0
Rev 2.0 Rev 2.0
CERAMIC Ground Tip
NCO
SCO SCO
25k
25k
.22uF
Neck
Wire
5 fishman.com
CAUTION! Excessive pressure may puncture the battery. Isolate all components
during installation to eliminate shorting or risk of fire. 9V Battery
(+) (-)
Output
Jack
OUTPUT
OUTPUT
GND
GND
Ring
Single Coil
Single Coil
GND
GND
GND
GND
+9-18V
+9-18V
Voice 2
Voice 2
Sleeve
Bridge
Ground
TOSIN ABASI TOSIN ABASI
ALNICO CERAMIC
Rev 2.0
Tip
Pull for
NCO
SCO SCO Voice-1
on 1,3,& 5
Positions
25k
4 3 2
5 1
Neck Volume
Wire
Switch Positions:
1. Bridge Humbucker (Voice-1 or 2 selectable) 1 5 Bridge
2. Bridge & Neck Inner Coils (Bridge Voice-3) 2 4
Wire
3 3
3. Bridge & Neck Humbucker (Voice-1 or 2 selectable) 4 2 Switch:
4. Neck Outer Coil (Voice-3) 5 OTAX 1 Otax
5. Neck Humbucker (Voice-1 or 2 selectable) C C
3PS1VLX91
6 fishman.com
CAUTION! Excessive pressure may puncture the battery. Isolate all components
during installation to eliminate shorting or risk of fire. 9V Battery
(+) (-)
Output
Jack
OUTPUT
OUTPUT
GND
GND
Ring
Single Coil
Single Coil
GND
GND
GND
GND
+9-18V
+9-18V
Voice 2
Voice 2
Sleeve
TOSIN
Tosin ABASI
Abasi TOSIN ABASI
Neck Bridge
RALNICO
ev1.0
Rev 2.0 Rev 2.0
CERAMIC Ground Tip
NCO
SCO SCO
Volume 25k
Pull for
.22uF
Voice-2
25k
Neck Tone,
Note: Voice-3 (single coil mode) Wire
Pull for
over rides the Voice-1/Voice-2 Voice-3
selection. Bridge
Pickup Selector Wire
(Single Coil)
3-Position
Import Toggle Switch Ground
(Optional)
7
fishman.com
fishman.com
Fishman and Fishman Transducers are trademarks or tradenames of Fishman Transducers Inc. 514-300-161 r0