Professional Documents
Culture Documents
Service Manual: Sony Confidential
Service Manual: Sony Confidential
SERVICE MANUAL
Ver 2-2010F
Revision History
Area Model Lineup
VPCZ129FJ/S
Area Model Lineup
VPCZ12L9E/B
t i a l
n
VPCZ12AFJ∗ VPCZ12M9E/B
e
Japanese Japanese VPCZ12AGJ∗ VPCZ12S9R/B
VPCZ12AHJ∗ VPCZ12S9R/S
d
VPCZ12AVJ∗ VPCZ12V9E/X
i
VPCZ122GX/B European AEP/UK VPCZ12V9R/X
f
VPCZ122GX/S VPCZ12X9E/X
n
VPCZ124GX/B VPCZ12X9R/B
VPCZ124GX/S VPCZ12Z9E/X
o
VPCZ125GX/B VPCZ12Z9R/XQ
VPCZ125GX/S VPCZ12∗
US/Canadian
C
VPCZ127GX/B VPCZ126GF/B
American
VPCZ127GX/S VPCZ126GG/B
VPCZ128GX/B International
y
VPCZ127GG/B
VPCZ128GX/S VPCZ128GG/XQ
on
VPCZ1290S∗ VPCZ129GG/XQ
VPCZ1290X∗ VPCZ126GK/B
Korean
VPCZ120GL/BI Asian/Oceania/ VPCZ128GK/XQ
Latin
S
VPCZ1290L∗ South Africa VPCZ127FC/B
Chinese VPCZ128GC/B
VPCZ1200C∗
VPCZ126GW/B
Taiwan
VPCZ129GW/XQ
Thai VPCZ126GH/B
UAE VPCZ126GA/B
∗: CTO Model
• ᧄᯏߩ᭽߅ࠃ߮ᄖⷰߪޔᡷ⦟ߩߚ੍๔ߥߊ
ᄌᦝߔࠆߎߣ߇ࠅ߹ߔ߇ੌߏޔᛚߊߛߐޕ
PERSONAL COMPUTER
9-852-892-02
Information in this document is subject to Caution Markings for Lithium/Ion Battery - The Service and Inspection Precautions
change without notice. following or similar texts shall be provided on
battery pack of equipment or in both the operating
Sony, VAIO and CLIE are trademarks or regis- and the service instructions. 1. Obey precautionary markings and 4. Inspect after completing service
tered trademarks of Sony. Microsoft, Windows, instructions
After servicing, inspect to make sure that all
Windows Media, Outlook, Bookshelf and other CAUTION: Danger of explosion if battery is
Labels and stamps on the cabinet, chassis, and screws, components, and wiring have been
Microsoft products are trademarks or registered incorrectly replaced. Replace only with the same
components identify areas requiring special pre- returned to their original condition. Also check
trademarks of Microsoft Corporation in the
or equivalent type recommended by the manu- cautions. Be sure to observe these precautions, the area around the repair location to ensure that
United States and other countries. The word
facturer. Discard used batteries according to the as well as all precautions listed in the operating repair work has caused no damage, and confirm
Bluetooth and the Bluetooth logo are trademarks
manufacturer’s instructions. manual and other associated documents. safety.
of Bluetooth SIG, Inc. AMD, the AMD logo, other
AMD product names and combinations thereof
are trademarks of Advanced Micro Devices, Inc. CAUTION: The battery pack used in this device 2. Use designated parts only 5. When replacing chip components...
Intel Inside logo, Pentium, Celeron and Core are may present a fire or chemical burn hazard if mis- Never reuse components. Also remember that
trademarks or registered trademarks of Intel Cor- treated. Do not disassemble, heat above 60°C The set’s components possess important safety the negative side of tantalum capacitors is easily
poration. Transmeta, the Transmeta logo, Crusoe (140°F) or incinerate. Dispose of used battery characteristics, such as noncombustibility and damaged by heat.
Processor, the Crusoe logo and combinations promptly. Keep away from children. the ability to tolerate large voltages. Be sure that
thereof are trademarks of Transmeta Corporation replacement parts possess the same safety charac-
6. When handling flexible print
in the USA and other countries. Graffiti, Hot- teristics as the originals. Also remember that the
Sync, PalmModem, and Palm OS are registered
CAUTION: Changing the back up battery. mark, which appears in circuit diagrams and boards...
z Overcharging, short circuiting, reverse charg-
trademarks, and the Hotsync logo and Palm are parts lists, denotes components that have particu- z The temperature of the soldering-iron tip
ing, multilation or incineration of the cells must larly important safety functions; be extra sure to
trademarks of Palm, Inc. or its subsidiaries. (M) should be about 270°C.
be avoided to prevent one or more of the fol- use only the designated components.
and Motrola are trademarks of Motrora, Inc. Other z Do not apply the tip more than three times to
lowing occurrences; release of toxic materials,
Motrola products and services with (R) mark like the same pattern.
release of hydrogen and/or oxygen gas, rise in
Dragonball are the trademarks of Motrola, Inc. 3. Always follow the original design z Handle patterns with care; never apply force.
surface temperature.
z If a cell has leaked or vented, it should be
when mounting parts and routing
All other names of systems, products and services wires Caution: Remember that hard disk drives are
replaced immediately while avoiding to touch
in this manual are trademarks or registered trade- easily damaged by vibration. Always handle
it without any protection.
marks of their respective owners. In this manual, The original layout includes various safety fea- with care.
the (TM) or (R) mark are not specified. tures, such as inclusion of insulating materials
(tubes and tape) and the mounting of parts above
ATTETION AU COMPOSANT AYANT
the printer board. In addition, internal wiring has
RAPPORT
been routed and clamped so as to keep it away À LA SÉCURITÉ!
CAUTION - CLASS 3B VISIBLE AND INVISIBLE LASER RADIATION from hot or high-voltage parts. When mounting LES COMPOSANTS IDENTIFÉS PAR UNE
parts or routing wires, therefore, be sure to du-
WHEN OPEN. AVOID EXPOSURE TO THE BEAM. plicate the original layout.
MARQUE SUR LES DIAGRAMMES
SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE
FONCTIONNEMENT. NE REMPLACER CES
COMPOSANTS QUE PAR DES PIÈSES SONY
The components identified by mark contain DONT LES NUMÉROS SONT DONNÉSDANS
confidential information. CE MANUEL OU DANS LES SUPPÉMENTS
Strictly follow the instructions whenever the PUBLIÉS PAR SONY.
components are repaired and/or replaced.
Sony Confidential
-2- VPCZ1 Series (9-852-892-XX)
TABLE OF CONTENTS
Sony Confidential
-3- VPCZ1 Series (9-852-892-XX)
CHAPTER 1.
BLOCK DIAGRAM
㻵㻹㼂㻼㻢㻚㻡
㻌㼂㻾
㼄㻰㻼
䖩㻮㼡㼠㼠㼛㼚 㻭㼘㼑㼞㼠
㻌㻌㻙㻌㻼㼛㼣㼑㼞
㻲㻭㻺
㻌㻌㻙㻌㻭㻿㻿㻵㻿㼀 㼂㻾㻭㻹㻦㻝㻳㻮㻌
㻌㻌㻙㻌㻿 㻔㻢㻠㻹㻌㼤㻌㻝㻢㻌㻘㻌㻤㻌㼜㼏㼟㻕
䚷㻙㻌㼂㻭㻵㻻
㻌㻌㻙㻌㻻㻰㻰㻌㻱㼖㼑㼏㼠 㻼㼞㼛㼏㼑㼟㼟㼛㼞
䖩㻿㼣㼕㼠㼏㼔
㻌㻌㻙㻌㻼㼑㼞㼒㼛㼞㼙㼍㼚㼏㼑
㻭㼞㼞㼍㼚㼐㼍㼘㼑㻌 㻿㼃
㻌㻌㻌㻌㻿㼀㻭㻹㻵㻺㻭㻛㻿㻼㻱㻱㻰㻛㻭㼁㼀㻻
㻌㻌㻙㻌㼃㼕㼞㼑㼘㼑㼟㼟
㻌㻌㻌㻌㻻㻺㻛㻻㻲㻲㻌
㼑㻰㻼
䖩㻸㻱㻰㼟
㻌㻌㻙㻌㻼㼛㼣㼑㼞
㻌㻌㻙㻌㻯㼔㼍㼞㼓㼑
㻌㻌㻙㻌㻼㼑㼞㼒㼛㼞㼙㼍㼚㼏㼑
㻌㻌㻌㻌㻿㼀㻭㻹㻵㻺㻭㻛㻿㻼㻱㻱㻰㻛㻭㼁㼀㻻
㻼㻱㻳㻌㼤㻝㻢
㻌㻌㻙㻌㻷㼑㼥㼎㼛㼍㼞㼐 㻿㼃 㻿㼃
㻌㻌㻌㻌㼚㼡㼙㻛㼏㼍㼜㼟㻛㼟㼏㼞㻌㼘㼗
㻼㻱㻯㻵 㻲㻰㻵 㻰㻹㻵
㻌㻌㻌㻙㻌㻴㻰㻰㻛㻻㼜㼠㼕㼏㼍㼘㻌㻰㼕㼟㼏㻌㻰㼞㼕㼢㼑
㻌㻌㻙㻌㼃㼕㼞㼑㼘㼑㼟㼟
㻹㼑㼙㼛㼞㼥㻌㻰㻰㻾㻟 㻜
㻌㻌㻙㻌㻯㼍㼙㼑㼞㼍
㻌㻌㻙㻌㻹㻿㻌䚸 㻿㻰 㻝
㻯㻸㻷㻳㻱㻺
㻾㼑㼍㼘㼀㼑㼗
㻾㼀㻹㻤㻥㻜㻺㻙㻢㻟㻡㻙㻳㻾㼀 㼁㻿㻮㻌㻝㻠㼜㼛㼞㼠㼟 㼁㻿㻮 㻞
㻱㻴㻯㻵㻌㻏㻝㻦㻌㻤㼜㼛㼞㼠㼟
㻱㻴㻯㻵㻏㻞㻦㻌㻢㼜㼛㼞㼠㼟
㻼㻯㻵㻌㻱㼤㼜㼞㼑㼟㼟 㻟
㻼㻯㻵㻌㻱㼤㼜㼞㼑㼟㼟 㻟
㻤㼜㼛㼞㼠㼟 㻿㻭㼀㻭
㻠
㻞 㻜
㻿㻭㼀㻭㻌㻢㼜㼛㼞㼠㼟
㻝 㻤
㻞 㻥
㻭㼦㼍㼘㼕㼍
㻟 㻝㻜
㻿㻹㻮㼡㼟
㻠 㻝㻝
㻝
㻸㻼㻯
㻝㻞
㻝㻟
SLB9635-TT1.2
㼀㼛㼡㼏㼔
㻼㻭㻰
R4F2117VBG20V
㻢
Sony Confidential
1-1 VPCZ1 Series (9-852-892-XX)
(END)
CHAPTER 2.
FRAME HARNESS DIAGRAM
(MBX206-
MEMORY
MEMORY
BT
IFX546)
MAIN
MODULE IFX-546 BOARD MINI CARD
FFC
Side A
MBX-206 FPC-201
FUN UNIT 1 BLK ANTENNA (WLAN/WiMAX) MAIN
BOARD
Side A 3 WHT ANTENNA (WLAN/MIMO)
Memory x2 WLAN 3rd Model
Model 2 GRY
ANTENNA (WLAN/WiMAX) AUX
FFC (SWX328-SWX330)
WIRELESS-LAN,
TPM WLAN/WiMAX
Model
COMBO CARD
IFX-548 BOARD N.C. FPC-197
Side A ODD
SSD x2 (To) Model SSD x2 (Sa) Model
MN-LI
RECHARGEABLE
BATTRY FPC-217
EXPRESS
CARD FPC-209 ODD Model
FPC-200
iLink
Model
HDD
FPC-213 SSD
SSD
(To) (Sa)
TOUCH PAD
FPC-198
FPC-199
(SWX328-TP)
KEYBOARD SSD
UNIT SSD
(Sa)
(To)
Back
FFC
Light KB SWX-328
Model FPC-212
BOARD
Side A FFC (SWC328-SWX329) HDD Model
Felica Model
ANL-96 BOARD
No-iLink Side A
Model IFX-545 FELICA
BOARD Top LEFT BUTTON RIGHT BUTTON FFC MODULE
SPEAKER L SPEAKER R (SWC328-
Side A FP FELICA)
Model
Front
WIRELESS
OFF ON
From board to connector (direct connection) ၮ᧼߆ࠄࠦࡀࠢ࠲߳㧔࠳ࠗࠢ࠻ធ⛯㧕 Sony Confidential
Harness (connector at both end) ࡂࡀࠬ㧔ਔ┵߇ࠦࡀࠢ࠲ઃ߈㧕
Harness (soldered at one end) ࡂࡀࠬ㧔৻ᣇ߇ඨ↰ઃߌ㧕 2-1 VPCZ1 Series (9-852-892-XX)
(END)
CHAPTER 3.
EXPLODED VIEWS AND PARTS LIST
• The exploded views and parts list are compiled by blocks. • Double-click on the paper clip mark in the Spec column to open the specifications list.
The sections are different depending on the model. 䊶㩷㪪㫇㪼㪺ᰣ䈱䉪䊥䉾䊒䊙䊷䉪䉕䉻䊑䊦䉪䊥䉾䉪䈜䉎䈫䇮䉴䊕䉾䉪䈏㐿䈐䉁䈜䇯
Please refer to list of contents shown. • To open the specifications list, Microsoft office Excel or Excel viewer is required.
䊶㩷䉴䊕䉾䉪䉕㐿䈒䈢䉄䈮䈲㩷㪤㫀㪺㫉㫆㫊㫆㪽㫋㩷㪦㪽㪽㫀㪺㪼㩷㪜㫏㪺㪼㫃㩷䉁䈢䈲㩷㪜㫏㪺㪼㫃㩷䊎䊠䊷䊪䊷䈏ᔅⷐ䈮䈭䉍䉁䈜䇯
• ಽ⸃࿑䈫ㇱຠ䈲䇮䊑䊨䉾䉪䈗䈫䈮ಽ䈎䉏䈩䈇䉁䈜䇯
㵘ᯏ⒳䈮䉋䈦䈩䉶䉪䉲䊢䊮䈏⇣䈭䉍䉁䈜䈱䈪䇮⚦䈲৻ⷩ䉕ෳᾖ䈚䈩䈒䈣䈘䈇䇯 Palmrest Main Board Bottom LCD Accessories Spec
Z129FJ/S P-1 M-1 B-1 L-1 A-1
Section Page Z12AFJ∗ P-1 M-1 B-1 L-1 A-1
J Z12AGJ∗ P-1 M-1 B-1 L-1 A-1
Note ................................................................................... 3-2 Z12AVJ∗ P-1 M-1 B-1 L-1 A-1
Palmrest Z12AHJ∗ P-1 M-1 B-1 L-1 A-1
Z128GX/B P-1 M-1 B-1 L-1 A-1
P-1 ............................................................................. 3-3
Z128GX/S P-1 M-1 B-1 L-1 A-1
Main Board Z127GX/B P-1 M-1 B-1 L-1 A-1
M-1 ........................................................................... 3-4 Z127GX/S P-1 M-1 B-1 L-1 A-1
Bottom Z125GX/B P-1 M-1 B-1 L-1 A-1
Z125GX/S P-1 M-1 B-1 L-1 A-1
B-1 ............................................................................ 3-5 Z122GX/B P-1 M-1 B-1 L-1 A-1
AM
LCD Z122GX/S P-1 M-1 B-1 L-1 A-1
L-1 ............................................................................ 3-6 Z124GX/B P-1 M-1 B-1 L-1 A-1
Z124GX/S P-1 M-1 B-1 L-1 A-1
Accessories Z1290X∗ P-1 M-1 B-1 L-1 A-1
A-1 ............................................................................ 3-7 Z1290S∗ P-1 M-1 B-1 L-1 A-1
Z120GL/BI P-1 M-1 B-1 L-1 A-1
Z1290L∗ P-1 M-1 B-1 L-1 A-1
Z12Z9E/X P-1 M-1 B-1 L-1 A-1
Z12X9E/X P-1 M-1 B-1 L-1 A-1
Z12V9R/X P-1 M-1 B-1 L-1 A-1
Z12X9R/B P-1 M-1 B-1 L-1 A-1
LCD Z12S9R/B P-1 M-1 B-1 L-1 A-1
EU Z12S9R/S P-1 M-1 B-1 L-1 A-1
Z12M9E/B P-1 M-1 B-1 L-1 A-1
Z12L9E/B P-1 M-1 B-1 L-1 A-1
Z12Z9R/XQ P-1 M-1 B-1 L-1 A-1
Z12V9E/X P-1 M-1 B-1 L-1 A-1
Palmrest Z12∗ P-1 M-1 B-1 L-1 A-1
Z128GG/XQ P-1 M-1 B-1 L-1 A-1
Z128GK/XQ P-1 M-1 B-1 L-1 A-1
Z127GG/B P-1 M-1 B-1 L-1 A-1
Z126GG/B P-1 M-1 B-1 L-1 A-1
Z126GH/B P-1 M-1 B-1 L-1 A-1
Z126GF/B P-1 M-1 B-1 L-1 A-1
Z126GA/B P-1 M-1 B-1 L-1 A-1
AO
Z126GW/B P-1 M-1 B-1 L-1 A-1
Z126GK/B P-1 M-1 B-1 L-1 A-1
Main Board Z129GG/XQ P-1 M-1 B-1 L-1 A-1
Z129GW/XQ P-1 M-1 B-1 L-1 A-1
Z128GC/B P-1 M-1 B-1 L-1 A-1
Z127FC/B P-1 M-1 B-1 L-1 A-1
Z1200C∗ P-1 M-1 B-1 L-1 A-1
Bottom ∗: CTO Model
Sony Confidential
3-1 VPCZ1 Series (9-852-892-XX)
Note
Parts List is attached on the upper right portion of each EXPLODED VIEW. If there is the Remarks column in the parts list,
Items marked “ * “ are not stocked since they are seldom required for routine the features of applicable models are indicated in it
service. Some delay should be anticipated when ordering these items. for the parts that are different depending on each model.
The parts marked “ $ “ are the Reuse Parts.
For the abbreviations used in the remarks column, please refer to the <table 1>.
The parts marked with "&" indicates specific parts handling for Japan region.